Product ID:RECHARGEABLE SEALED LEAD-ACID BATTERY PS126
MSDS Date:07/05/1992
FSC:3695
NIIN:01-268-9156
Kit Part:Y
MSDS Number: BQYMX

POWER-SONIC CORP

3106 SPRING ST
REDWOOD CITY, CA 94063-3929
US

Emergency Phone: 415-364-5001

Info Phone: 415-364-5001

Cage: 56309

STANDARD MFG. CO. INC.

210300 DALLAS, TX 75211-0300 US

Telephone: 214-337-8911

Cage: 98296

SULFURIC ACID (SARA III)

CAS: 7664-93-9

RTECS: WS5600000

Fraction By Weight: 39.1%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LEAD (SARA III)

CAS: 7439-92-1

RTECS: OF7525000

OSHA PEL 0.05 MG/M3;1910.1025

ACGIH TLV: 0.15 MG/M3;DUST 9293

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

LD50 LC50 Mixture:LD50 ORAL RAT IS 2140 MG/KG.
Routes of Entry: Inhalation:NO Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: SEVERE BURNS AND ULCERATION OF
SKIN, EYES, MOUTH, THROAT, ESOPHAGUS AND STOMACH. INFLAMMATION OF
BRONCHIAL MEMBRANES. LEAD MAY CAUSE GASTROINTESTINAL DISORDERS AND
CNS EFFECTS. CHRONIC: EROSION OF TEETH, INFLAMMATION OF NOSE,
THROATAND BRONCHIAL TUBES. LEAD MAY CAUSE ANEMIA, DAMAGE TO KIDNEYS
AND CNS.
Explanation of Carcinogenicity:LEAD IS LISTED UNDER IARC AND NTP.
Effects of Overexposure:IF CONTACTED, SEVERE BURNS AND ULCERATION OF
SKIN AND EYES. IF INHALED, COUGH, SEVERE RESPIRATORY IRRITATION. IF
INGESTED, SEVERE BURNS AND ULCERATION. TEETH MAY BECOME DISCOLORED.
Medical Cond Aggravated by Exposure:SULFURIC ACID MAY AGGRAVATE SKIN
DISEASES SUCH AS ECZEMA AND DERMATITIS. LEAD CAN AGGRAVATE CHRONIC
FORMS OF KIDNEY, LIVER AND NEUROLOGIC DISEASES.

First Aid:EYES/SKIN: FLUSH WITH PLENTY OF WATER. SEE DOCTOR
IMMEDIATELY. REMOVE CONTAMINATED CLOTHING AND SHOES. INHALATION:
REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED. SEE DOCTOR.
INGESTION: DO NOT INDUCE VOMITING. GIVE MILK OR WATER, FOLLOWED BY
2 OUNCES OF MILK OF MAGNESIA (NO CARBONATES). SEE DOCTOR
IMMEDIATELY.

Flash Point:NONE
Lower Limits:4.0(HYDROGN)
Upper Limits:75(HYDROGEN)
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, WATER FOG, WATER.
Fire Fighting Procedures:EVACUATE AREA. REMOVE ALL IGNITION SOURCES.
WEAR SULFURIC ACID RESISTANT CLOTHING AND A FULL FACED SCBA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:HYDROGEN GAS MAY BE PRODUCED AND MAY
EXPLODE IF IGNITED. REMOVE ALL IGNITION SOURCES. WATER GENERATES
HEAT AND CAUSES ACID TO SPLATTER.

Spill Release Procedures:WEAR APPROPIATE PROTECTIVE EQUIPMENT. DILUTE
CAUTIOUSLY WITH WATER. COVER WITH SODA ASH OR QUICKLIME. SCOOP UP
AND PLACE IN APPROPIATE DISPOSAL CONTAINER. FLUSH AREA WITH LARGE
AMOUNTS OF WATER.
Neutralizing Agent:SODA ASH (SODIUM CARBONATE), BAKING SODA OR
QUICKLIME (CALCIUM OXIDE).

Handling and Storage Precautions:STORE AT ROOM TEMPERATURE AWAY FROM
FLAMES, IGNITION SOURCES, COMBUSTIBLE AND ORGANIC MATERIALS. AVOID
PROLONGED OVERCHARGING. WEAR PROTECTIVE EQUIPM.
Other Precautions:DO NOT CARRY BATTERY BY TERMINALS. DO NOT DROP
BATTERY, PUNCTURE OR ATTEMPT TO OPEN BATTERY CASE. KEEP TERMINALS
COVERED IN PLASTIC CASE. AVOID SHORTING BATTERIES. PLACE BROKEN
BATTERIES IN PLASTIC CO NTAINERS AND DELIVER TO BATTERY RECYCLER

Respiratory Protection:NONE NORMALLY REQUIRED. NIOSH/MSHA-APPROVED
CARTRIDGE RESPIRATOR FOR ACIDS OR FULL FACE MASK AS APPROPIATE FOR
EXPOSURE OF CONCERN WHEN TLV IS EXCEEDED.
Ventilation:GENERAL (MECHANICAL) VENTILATION. LOCAL EXHAUST IN CONFINED
AREAS.
Protective Gloves:RUBBER GLOVES IF CONTACT IS EXPECTED.
Eye Protection:GOGGLES IF CONTACT IS EXPECTED.
Other Protective Equipment:RUBBER APRON AND BOOTS IF CONTACT IS
EXPECTED. EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
KEY1:N1. NOTE TO PHYSICIAN: IF GASTRIC LAVAGE IS PERFORMED,
ENDOTRACHEAL OR ESOPHAGOSCOPIC CONTROL IS SUGGESTED. OXYGEN, WITH
USE OF INTERMITENT POSITIVE-PRESSURE BREATHING APPARATUS, 5%
SOLUTION OF S ODIUM BICARBONATE AS AEROSOL, AND BRONCODILATORS
AND/OR DECONGESTANTS MAY BE USED.

HCC:Z4
Boiling Pt:=113.9C, 237.F
Vapor Pres:10 @ 68F
Vapor Density:>1
Spec Gravity:1.280
pH:<1
Evaporation Rate & Reference:<1 (ETHER = 1)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS GEL, WITH SHARP, PENETRATING, PUNGENT
ODOR IN SEALED BATTERY.
Percent Volatiles by Volume:0

Stability Indicator/Materials to Avoid:YES
ORGANIC MATERIALS, CHLORATES, CARBIDES, FULMINATES, WATER, POWDERED
METALS, SOME NON-ACID-RESISTANT PLASTICS.
Stability Condition to Avoid:AVOID SHORTING, USE ONLY APPROVED CHARGING
METHODS. AVOID HIGH HEAT, OPEN FLAMES AND OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:SULFURIC ACID FUMES, SULFUR DIOXIDE,
SULFUR TRIOXIDE, HYDROGEN GAS, LARGE QUANTITIES OF HEAT.

Waste Disposal Methods:CONSULT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGUALTIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.