Product ID:MIL-C-22750E 17875 WHITE EPOXY, F-09P328
MSDS Date:09/18/1992
FSC:8010
NIIN:01-116-4577
Kit Part:Y
MSDS Number: BRNRW

SEAGRAVE COATINGS CORP OF VA

4030 SEAGUARD AVE
PORTSMOUTH, VA 23701
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 804-488-4411

Cage: 60163

SHERWIN-WILLIAMS, SEAGUARD

PORTSMOUTH, VA 23704 US

Telephone: 757-397-2223

Cage: 60163

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 35%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

10 @

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 15%

OSHA PEL SEE TABLE Z3

ACGIH TLV: 0.1 MG/M3 RDUST;9293

3 @

CAS: 64742-94-5

RTECS: WF3100000

Fraction By Weight: 5%

83 @ 20C.

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 20%

OSHA PEL 200 PPM;300 PPM STEL

ACGIH TLV: 200 PPM;300 PPM STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

EPOXY RESIN

CAS: 25068-38-6

RTECS: KC2100000

Fraction By Weight: 35%

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:IRRITATION TO RESPIRATORY TRACT,
HEADACHE, DIZZINESS & NAUSEA. SKIN CONTACT:PRIMARY IRRITATION. EYE
CONTACT:PRIMARY IRRITATION.
Explanation of Carcinogenicity:CRYSTALLINE SILICA - QUARTZ:GRP2A (IARC
SUPP7, P341, 1987), ANTICIP TO BE A CARCIN (NTP 6TH ANN RPT, 1991).
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS CAN CAUSE HEIGHTENED REACTION TO EXPOSURE TO THIS PRODUCT.

First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR,
RESTORE BREATHING. CONSULT MD. SKIN:FLUSH W/WATER. EYE:FLUSH
IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
CONSULT MD.

Flash Point Method:TCC
Flash Point:25.0F,-3.9C
Lower Limits:0.8%
Upper Limits:7%
Extinguishing Media:FOAM, WATER FOG, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER MAY BE USED TO COOL CLSD CNTNRS TO PVNT PRESS BUILD-UP &
POSS AUTOIGNIT/EXPLO WHEN EXPOSED (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, SPARKS & OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.

Spill Release Procedures:AVOID BREATHING SOLVENT VAPOR. ENSURE ADEQUATE
VENTILATION. AVOID SPARKS, FLAMES & ANYTHING WHICH COULD CAUSE
FIRE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL DRY AREA W/VENTILATION
SUITABLE FOR STORING MATERIALS SHOWN IN INGREDIENTS SECTION.
Other Precautions:PROVIDE NIOSH/MSHA APPROVED RESPIRATORY PROTECTION
AGAINST FUMES GENERATED DURING BURNING.

Respiratory Protection:NIOSH/MSHA APPROVED RESP TYPES SUITABLE FOR
MATLS IN INGREDIENTS SECTION RECOM. NIOSH/MSHA APPROVED
CHEMICAL/MECHANICAL FILTERS RECOM WHEN VENT IS RESTRICTED.
NIOSH/MSHA APPROVED AIRLINE TYPE RESPS/HO ODS RECOM IN CONFINED
AREAS.
Ventilation:SUFFICIENT VENT, IN VOL & PATTERN, SHLD BE PROVIDED TO KEEP
AIR CONTAM BELOW CURRENT APPLIC OSHA PEL/ACGIH'S TLV LIMIT.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEM GOGG W/SIDESHLDS OR FACESHLD.
Other Protective Equipment:USE PROTECTIVE CREAMS WHERE SKIN CONTACT IS
LIKELY.
Work Hygienic Practices:WASH HANDS BEFORE EATING/SMOKING. SMOKE IN
DESIGNATED AREAS ONLY. REMOVE & WASH CONTAM CLTHG BEFORE REUSE.
Supplemental Safety and Health
FIRE FIGHT PROC:TO EXTREME HEAT.

Boiling Pt:B.P. Text:>175F,>79C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE LIQUID; KETONE SOLVENTS ODOR.
Percent Volatiles by Volume:37.3

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS CAN CAUSE A VIGOROUS REACTION.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AS W/ANY OTHER ORGANIC MATERIAL,
COMBUSTION WILL PRODUCE CARBON DIOXIDE & PROBABLY CARBON MONOXIDE.

Waste Disposal Methods:SOAK LIQUIDS W/SAWDUST OR RAGS & REMOVE. FLUSH
W/WATER IF POSSIBLE. AVOID SKIN CONTACT. DISPOSAL SHOULD BE I/A/W
LOCAL, STATE & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.