Product ID:PALGARD EPOXY COATING BLACK
MSDS Date:07/23/1991
FSC:8010
NIIN:00N043697
MSDS Number: BRZQG

PRATT AND LAMBERT

BUFFALO, NY 14240
US

Emergency Phone: 716-873-8000; 800-255-3924

Info Phone: 716-873-8000

Cage: 61196

PRATT AND LAMBERT INC

CLEVELAND, OH 44101-1027 US

Telephone: 216-566-2902

Cage: 61196

APPROP PROT FACTOR. REFER TO OSHA 29CFR1910.134

RTECS: 9999999ZZ

INDUSTRIAL HYGIENE ASSOCIATION".

RTECS: 9999999ZZ

SECTION BELOW LOWEST EXPOS LIMIT STATED. REMOVE DECOMP

RTECS: 9999999ZZ

BRAZING OBJECTS COATED W/THIS PROD. REFER TO

RTECS: 9999999ZZ

RPTD EXCESSIVE

RTECS: 9999999ZZ

KIDNEY DAM. RPTS HAVE ASSOC PRLNGD/RPTD OCCUP

RTECS: 9999999ZZ

MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE

RTECS: 9999999ZZ

IMMED FLUSH CONTAMD AREAS W/LGE AMTS OF

RTECS: 9999999ZZ

ETHYLENE GLYCOL MONOBUTYL ETHER IS

RTECS: 9999999ZZ

THIS SUBSTANCE IS EXCRETED IN URINE. EXCESSIVE EXPOS

RTECS: 9999999ZZ

RETICULOCYTOSIS, GRANULOCYTOSIS, LEUKOCYTOSIS,

RTECS: 9999999ZZ

MATL (E.G. SAND/EARTH). TRANSFER LIQS TO COVERED

RTECS: 9999999ZZ

INERT ABSORB. USE ONLY NON-SPARKING TOOLS. PLACE

RTECS: 9999999ZZ

PREVENT CONTAMINATION OF SEWERS, STREAMS &

RTECS: 9999999ZZ

DISCARDED DIRECTLY WOULD BE CLASSIFED A HAZ

RTECS: 9999999ZZ

OF RESTRICTED VENT, A NIOSH/MSHA APPRVD ORG VAP

RTECS: 9999999ZZ

SPRAYING, A MECH PREFILTER MAY ALSO BE REQD. IN

RTECS: 9999999ZZ

AIR SUPPLIED RESP MAY BE REQD. IF TLV/PEL ARE

RTECS: 9999999ZZ

PLYAMIDE RESIN

CAS: 68410-23-1

Fraction By Weight: 30%

OSHA PEL N/K

ACGIH TLV: N/K

1%.

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: 15%

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9293

7%

CAS: 64742-88-7

Fraction By Weight: 15%

OSHA PEL N/K

ACGIH TLV: N/K

SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (SOLVENT

CAS: 64742-95-6

RTECS: WF3400000

Fraction By Weight: <5%

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 5%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

3.36 LB/GAL (403 G/L) LESS

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ANIMAL STUDIES HAVE CLEARLY
DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON THE CNS, HEMATOPOIETIC
TISS, BLOOD, KIDNEYS & LIVER ASSOC W/ADMIN OF ETHYLENE GLYCOL
MONOBUTYL ETHER (EGBE). (EXTRACTED FROM DHHS (NIOSH) PUB NO.
90-118) . INGEST:MAY CAUSE NAUS, RED BLOOD CELL DAM & POSS LIVER &
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:KIDNEY DAM. CAN CAUSE GI IRRIT, NAUS &
VOM. ASPIR OF MATL INTO LUNGS MAY CAUSE CHEM PNEUMONITIS WHICH CAN
BE FATAL. INHAL:MAY CAUSE NOSE/THROAT IRRIT. HIGH CONC MAY CAUSE
ACUTE CNS DEPRESS CH ARACT BY HDCH, DIZZ, NAUS & CONFUSN. EYES:MAY
CAUSE SEV EYE IRRIT & CORNEAL DAM. SKIN:LIQ MATL MAY BE ABSORBED
(SUP DAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INGEST:DO NOT INDUCE VOM. GIVE 1 OR 2 GLASSES OF WATER TO
DILUTE (NEVER GIVE ANYTHING BY MOUTH TO AN UNCON PERS). CALL POIS
CTL CTR, HOSP EMER ROOM OR MD IMMED. INHAL:REMOVE TO FRESH AIR
IMMED. IF BRT HG HAS STOPPED, GIVE ARTF RESP. KEEP WARM/QUIET. GET
MED ATTN IMMED. EYES:FLUSH W/LGE AMTS OF WATER, LIFTING UPPER/LOWER
LIDS OCCASNLY. CONTINUE FOR AT LEAST 15 MINS. GET MED ATTN. SKIN:
(ING 10)

Flash Point Method:SCC
Flash Point:106F,41C
Lower Limits:SEE INGREDS
Upper Limits:SEE INGREDS
Extinguishing Media:USE NFPA CLASS B FIRE EXTINGS (CO2, ALL PURPOSE DRY
CHEM OR ALCOHOL FOAM) DESIGNED TO EXTING FLAMM LIQ FIRES. (SUP DAT)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER MAY BE INEFT, BUT MAY BE USED TO COOL EXPOSED CONTRS TO
PVNT PRESS BUILD-UP & POSS (SUP DAT)
Unusual Fire/Explosion Hazard:DURING EMER CNDTNS, OVEREXPOS TO DECOMP
PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN
MED ATTN. KEEP CONTRS TIGHTLY CLSD. ISOLATE (SUP DAT)

Spill Release Procedures:WEAR NIOSH/MSHA APPRVD RESPS, EYE, HAND & BODY
PROT APPROP FOR SIZE OF SPILL & EXPOS ENCOUNTERED. KEEP SPECTATORS
AWAY. ELIM ALL IGNIT SOURCES (FLAMES, HOT SURF & SOURCES OF ELEC,
STATIC OR FRICATIONA L SPARKS). DIKE & CONTAIN SPILL W/INERT(ING
14)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE >115F. STORE LGE QTYS IN
COMPLIANCE W/OSHA 29CFR1910.16. DO NOT TAKE INTERNALLY. CLOSE CONTR
AFTER EACH USE. AVOID SKIN CONTACT.
Other Precautions:EMPTY CONTRS MUST NOT BE WASHED & REUSED FOR ANY
PURPOSE. CONTRS SHOULD BE GROUNDED & BONDED TO THE RECEIVING CONTR.
DO NOT WELD, BRAZE OR CUT ON EMPTY CONTR. NEVER USE PRESS TO EMPTY.
DRUM IS NOT A P RESS VESSEL.

Respiratory Protection:PROPER SELECTION OF RESP PROT DEPENDS UPON MANY
FACTORS INCL DURATION & LEVEL OF EXPOS & CNDTNS OF USE. IN GEN
EXPOS TO ORG CHEMS SUCH AS THOSE CONTAINED IN PROD MAY NOT REQ USE
OF RESP PROT IF USED I N WELL VENTD AREAS. IN AREAS (ING 18)
Ventilation:PROVIDE GEN DILUTION & LOC EXHST VENT IN SUFFICIENT VOL &
PATTERN TO KEEP CONC OF HAZ INGREDS LISTED IN INGRED (ING 23)
Protective Gloves:SOLVENT IMPERMEABLE GLOVES.
Eye Protection:CHEMICAL SAFETY GOGGLES .
Other Protective Equipment:EYE WASH FACILITY & SAFETY SHOWER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXTING MEDIA:POLYMER FOAM IS PREF FOR LGE FIRES. FIRE FIGHT
PROC:AUTO-IGNITION OR EXPLOS WHEN EXPOSED TO EXTREME HEAT. IF WATER
IS USED, FOG NOZZ ARE PREF. EXPLO HAZ:FROM HEAT, ELEC EQUIP, SPARKS
& FL AME. CLSD CONTRS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
EFTS OF OVEREXP:THRU SKIN IN HARMFUL AMTS. MAY (ING 7)

HCC:F4
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.1
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:48

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F, >46C) &
SOURCES OF IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRDCE SMOKE, CARBON MONOXIDE & CARBON
DIOXIDE.

Waste Disposal Methods:DISP I/A/W FED, STATE & LOC LAWS. INCIN ONLY IN
EPA PERMITTED FACILITY. DO NOT INCIN CLSD CONTRS. OBSERVE PRECS FOR
DISP OF FLAMM MATLS. CONTAMD ABSORB MAY BE DISPOSED IN A HAZ WASTE
LANDFILL. DISP ON LY I/A/W FED, STATE & LOC REGS. PROD, IF (ING 17)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.