Product ID:CERAMICAST 4-200, PART B
MSDS Date:09/08/1991
FSC:8030
NIIN:00-229-8735
Kit Part:Y
MSDS Number: BSGDV

Emergency Phone: 800-424-9300

Info Phone: 516-349-1100/ 800-645-7546

Cage: 13549

Telephone: 516-349-1100/800-424-9300(CHEMTREC)

Cage: 13549

MODIFIED ALIPHATIC AMINE (VAPOR PRESSURE 1.0 MM HG @ 20C)

Fraction By Weight: 82-90%

ACGIH TLV: 1 PPM

Health Hazards Acute and Chronic:VAPORS MAY IRRITATE THE EYES. VAPORS
MAY IRRITATE RESPIRATORY TRACT. PROLONGED EXPOSURE MAY CAUSE
HEADACHE, DIZZINESS, NAUSEA & VOMITING. CONTACT IRRITATING TO EYES.
MAY CAUSE SKIN SENSITIZATION & OTH ER ALLERGIC REACTIONS. SEVERE
SKIN IRRITATION MAY OCCUR. MAY CAUSE BLINDNESS OR PERMANENT EYE
INJURY.

First Aid:MOVE TO FRESH AIR. APPLY ARTIFICIAL RESPIRATION, IF NEEDED.
WASH SKIN WITH SOAP & WATER OR WATERLESS HAND CLEANERS. REMOVE
CONTAMINATED CLOTHING. DO NOT INDUCE VOMITING. DRINK LARGE
QUANTITIES OF WATE R IMMEDIATELY. FLUSH EYES WITH WATER FOR 15
MINUTES, GET MEDICAL ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO
UNCONSCIOUS PERSON. IF INGESTED, SEE DR IMMED. IF BREATHING
DIFFICULT, GIVE OXYGEN.

Flash Point Method:PMCC
Flash Point:300F,149C
Lower Limits:1.4
Extinguishing Media:WATER FOG, FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:USE WATER FOG TO COOL CONTAINERS. WEAR
PROTECTIVE CLOTHES. FIGHT FIRE FROM DISTANCE. CLOSE VALVES TO AREA.
SHUT OFF POWER. TURN EMERG LIGHTS ON. USE SCBA.
Unusual Fire/Explosion Hazard:UNDER FIRE CONDITIONS IRRITATING AND/OR
TOXIC GASES MAY BE PRESENT.

Spill Release Procedures:ABSORB W/SAND.REMOVE IGNIT SOURCE.WEAR PROTECT
CLOTHING.DIKE W/SAND.PREVENT FROM ENTERING UNDERGRND
WATER.VENT.FLUSH W/WATER (NOT TO SEWER).EMULSIFY REMAINING W/SOAP &
WATER.ABSORB.SCOOP UP CONTAM SOI L.PUT IN DRUMS.TRANSPRT SPILL
800-424-9300.

Handling and Storage Precautions:PROTECT FROM FREEZING. OVERHEATING MAY
CAUSE CONTAINER TO RUPTURE. STORE IN COOL, DRY PLACE. KEEP AWAY
FROM OPEN FLAMES. KEEP CONTAINER CLOSED.
Other Precautions:STORE AWAY FROM FOOD & BEVERAGES. CHECK CONTAINERS
FOR LEAKS. AVOID PROLONGED BREATHING OR CONTACT WITH SKIN. AVOID
BREATHING FUMES, MISTS, VAPOR. ALWAYS WORK IN AREAS WITH ADEQUATE
VENT TO ALLOW DISS IPATION OF CHEMICAL FUMES.

Respiratory Protection:MISHA/NIOSH APPROVED RESPIRATOR IS HIGHLY
RECOMMENDED. SELF-CONTAINED BREATHING APPARATUS IN CONCENTRATIONS
ABOVE PEL/TLV.
Ventilation:PROVIDE ADEQUATE CROSS AIR CIRCULATION. EXHAUST AT POINT OF
USE. MECHANICAL IN CONFINED AREAS.
Protective Gloves:RUBBER OR NEOPRENE (RESISTANT) GLOVES
Eye Protection:CHEMICAL WORKER & SPLASH GOGGLES
Other Protective Equipment:EYEWASH STATION, EMERGENCY SHOWER, BARRIER
CREAM, CHEM APRON, RUBBER FOOT COVERING, CLEAN LONG SLEEVE/LEG
CLOTHING.
Work Hygienic Practices:WASH AFTER HANDLING. WASH BEFORE EATING,
DRINKING, SMOKING OR USING TOILET.
Supplemental Safety and Health
KEY1:T6. THIS ENTRY DESCRIBES PART B OF A TWO PART KIT. SEE THIS SAME
NSN, P/N IND A AND P/N IND C, FOR PART A DATA.

HCC:T6
Vapor Density:< AIR
Spec Gravity:1.02
Evaporation Rate & Reference:SLOWER THAN N-BUTYL AC
Solubility in Water:NEGLIGIBLE (<0.1)
Appearance and Odor:STRAW COLORED LIQUID, AMINE ODOR

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG BASES AND/OR CONCENTRATED ALKALI, EPOXY RESIN
UNDER UNCONTROLLED CONDITIONS.
Hazardous Decomposition Products:OXIDES OF CARBON, OXIDES OF NITROGEN,
TOXIC MONOMER FUMES AND/OR SHORT CHAIN HYDROCARBONS.

Waste Disposal Methods:INCINERATE IN APPROVED MANNER. DISPOSE OF IN
ACCORDANCE WITH LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.