Product ID:RECHARGEABLE SEALED LEAD-ACID BATTERY,400-702-00
MSDS Date:07/05/1992
FSC:6140
NIIN:01-232-8980
MSDS Number: BSGGY

POWER-SONIC CORP

3106 SPRING ST
REDWOOD CITY, CA 94063-3929
US

Emergency Phone: 415-364-5001

Info Phone: 415-364-5001

Cage: 56309

POWER-SONIC CORP

5242 REDWOOD CITY, CA 94063-3929 US

Telephone: 650-364-5001

Cage: 56309

SULFURIC ACID (SARA III), ELECTROLYTE

CAS: 7664-93-9

RTECS: WS5600000

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3; 9394

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LEAD (SARA III)

CAS: 7439-92-1

RTECS: OF7525000

OSHA PEL SEE 1910.1025

ACGIH TLV: 0.15 MG/M3,DUST;9394

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

LEAD OXIDES

OSHA PEL 0.05 MG/M3 AS PB

ACGIH TLV: 0.15 MG/M3 AS PB

LD50 LC50 Mixture:TLV FOR SULFURIC ACID IS 1 MG/M3.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE- LEAD MAY CAUSE GI UPSET,
DIARRHEA, CRAMPING & FATIGUE. SULFURIC ACID MAY CAUSE EYE, SKIN &
RESPIRATORY TRACT IRRITATION, BURNS, CORNEAL & LUNG DAMAGE.
CHRONIC- LEAD MAY CAUSE ANEMIA, KIDNEY & N ERVOUS SYSTEM DAMAGE.
ACID CAN CAUSE BRONCHITIS, EROSION OF TOOTH ENAMEL. TARGET
ORGANS:EYES, SKIN, LUNGS, KIDNEY.
Explanation of Carcinogenicity:CONTAINS LEAD.
Effects of Overexposure:GI UPSET, LOSS OF APPETITE, DIARRHEA,
CONSTIPATION, CRAMPING, LACK OF SLEEP, FATIGUE, EYE, SKIN &
RESPIRATORY TRACT IRRITATION, BURNS, CORNEAL & LUNG DAMAGE
Medical Cond Aggravated by Exposure:INORGANIC LEAD AND ITS COMPOUNDS
CAN AGGRAVATE CHRONIC FORMS OF KIDNEY, LIVER AND NEUROLOGIC
DISEASES. CONTACT OF SULFURIC ACID WITH THE SKIN MAY AGGRAVATE SKIN
DISEASES SUCH AS ECZEMA AND DERMATITIS.

First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES OF EXPOSURE.
EYES/SKIN:FLUSH WITH WATER FOR 15 MINUTES. KEEP EYELIDS OPEN.
INHALATION:MOVE TO FRESH AIR. INGESTION:DO NOT INDUCE VOMITING.
WASH OUT MOUTH. GARGLE TO WASH THROAT. DRINK MILK PREFERRABLY
MIXED WITH EGG WHITES OR VEGETABLE OIL. CALL PHYSICIAN IMMEDIATELY.

Flash Point:NON-FLAMMABLE
Extinguishing Media:WATER SPRAY, FOAM OR DRY CHEMICAL. WATER SPRAY MAY
BE USED TO COOL FIRE-EXPOSED CONTAINER & DECREASE VAPORS.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:HYDROGEN GAS IS PRODUCED WHILE CHARGING.
KEEP AWAY SPARKS AND OTHER SOUCES OF IGNITION. THE NON-CONDUCTIVE
CASE IS NON-FLAMMABLE.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENTS. REMOVE
COMBUSTIBLES & IGNITION SOURCES (H2 MAY BE PRESENT). CONTAIN BY
DIKING AND COVER SPILL WITH SODA ASH OR QUICKLIME. MIX WELL. CHECK
THAT MIXTURE IS NEUTRAL. COLLECT A ND PLACE IN A DRUM. DO NOT FLUSH
TO SEWER.
Neutralizing Agent:SODA ASH (SODIUM CARBONATE), QUICKLIME (CALCIUM
OXIDE)

Handling and Storage Precautions:STORE NEAR EYEWASH FOUNTAIN AND SAFETY
SHOWER. STORAGE AREA SHOULD BE EQUIPPED WITH A DRAIN WHICH CAPTURES
SPILLS OF ACID FOR PROPER DISPOSAL.
Other Precautions:KEEP TERMINALS COVERED IN PLASTIC CASE. AVOID
SHORTING BATTERIES. DO NOT CRACK OR OVERCHARGE BATTERIES. KEEP
LIGHTED CIGARETTES, SPARKS, AND FLAMES AWAY FROM CHARGING
BATTERIES. KEEP OUT OF REACH OF C HILDREN.

Respiratory Protection:NOT REQUIRED UNDER NORMAL USE. USE
NIOSH-APPROVED ACID-MIST FILTER RESPIRATOR IF 1 MG/M3 TWA IS
EXCEEDED (ACID).
Ventilation:ADEQUATE GENERAL VENTILATION
Protective Gloves:RUBBER IF LEAKING OR BROKEN
Eye Protection:SPLASH-PROOF CHEMICAL GOGGLES
Other Protective Equipment:RUBBER APRON AND BOOTS. EYES WASH STATION
AND SAFETY SHOWER. USE ACID-PROOF CLOTHING FOR MAJOR SPILLS.
Work Hygienic Practices:REMOVE METALLIC JEWELRY-SHOCK POTENTIAL. WASH
THOROUGHLY AFTER HANDLING AND BEFORE EATING AND DRINKING.
Supplemental Safety and Health
THE 6350 (FSC) WILL BE CHANGED TO 6140.

HCC:C1
NRC/State Lic Num:NOT RELEVANT
Spec Gravity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:NOT RELEVANT
Appearance and Odor:BATTERY. RECTANGULAR OR SQUARE IN SHAPE - NO ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG REDUCING AGENTS, MOST METALS, STRONG
BASES
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES, OVERCHARGING,
SMOKING, SPARKS
Hazardous Decomposition Products:OXIDES OF LEAD AND SULFUR, HYDROGEN,
SULFUR DIOXIDE AND SULFUR TRIOXIDE

Waste Disposal Methods:DISPOSE AS HAZARDOUS WASTE. OBSERVE ALL FEDERAL,
STATE AND LOCAL ENVIRONMENTAL REGULATIONS FOR ACID OR LEAD SCRAP.
SEND BATTERIES TO LEAD SMELTER FOR RECLAMATION FOLLOWING APPLICABLE
FEDERAL, STATE AN D LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.