Product ID:A-661, PART A
MSDS Date:03/20/1990
FSC:8040
NIIN:01-342-1511
Kit Part:Y
MSDS Number: BSGJG

MORTON INTL INC SPECIALTY CHEMICALS GROUP

333 W WACKER DR
CHICAGO, IL 60606-1218
US

Emergency Phone: 815-338-1800

Info Phone: 312-807-3137

Preparer: DAVID B WIENCKOWSKI

Cage: 32063

MORTON INTL INC SPECIALTY CHEMICALS GROUP

CHICAGO, IL 60606-1218 US

Telephone: 312-807-2000

Cage: 32063

11,4000

CAS: 25068-38-6

Fraction By Weight: 10-30%

ALUMINUM, METALLIC, POWDER (SARA III) (AS AL)

CAS: 7429-90-5

RTECS: BD0330000

Fraction By Weight: 20-30%

OSHA PEL 5 MG/M3 TOTAL PARTIC

ACGIH TLV: 10 MG/M3 RESP FRACT

POLYFUNCTIONAL EPOXY RESIN

Fraction By Weight: 10-30%

GLASS FIBERS

CAS: 65997-17-3

Fraction By Weight: 10-30%

OSHA PEL 5 MG/M3 TOTAL PARTIC

ACGIH TLV: 10MG/M3 TOTAL PARTIC

SILICA, AMORPHOUS/SILICON DIOXIDE, AMORPHOUS (LD50 ORAL

CAS: 7631-86-9

Fraction By Weight: 1-5%

OSHA PEL 80 MG/M3/%SIO2

ACGIH TLV: 10MG/M3 TOTAL PARTIC

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE: MILD TO MODERATE IRRITATION.
SKIN: MILD TO MODERATE IRRITATION. PROLONGED/REPEATED: IRRITATION,
LEAD TO DERMATITIS, HYPERSENSITIVITY (ALLERGY) IN SUSCEPTIBLE.
INHALATION: NO ADVERSE EFFECTS. INGE STION: GASTROINTESTINAL
IRRITATION.
Effects of Overexposure:DEPENDING ON THE ROUTE, FREQUENCY, AND DURATION
OF EXPOSURE, TOXICITY MAY OCCUR IN THE FOLLOWING ORGANS AND/OR
SYSTEMS: EYE, SKIN, IMMUNE SYSTEM (E.G., ALLERGIC REACTIONS).
Medical Cond Aggravated by Exposure:SKIN, IMMUNE SYSTEM, SPECIFIC
CHEMICAL ALLERGIES. ADDITIONAL INFO:IF DROWSY OR
UNCONSCIOUS,CONVULSING,NO GAG REFLEX,DON'T GIVE ANYTHING BY MOUTH
OR LEAVE ALONE.LOOSEN CLOTHING,CLEAR AIRWAY.KEEP WARM.

First Aid:GET MED AID. EYE: FLUSH W/WATER 15 MIN. LIFT LIDS FREQUENTLY.
SKIN: REMOVE CONTAM CLOTH & SHOES. WASH SKIN W/SOAP & WATER. IF
IRRIT, SEE DR. WASH CONTAM CLOTH BEFORE REUSE. INHAL: REMOVE TO
FRESH AIR. IF SYMPTOMS, GET IMMED MED AID. NO BREATH, GIVE ARTIF
RESP (MOUTH TO MOUTH). INGESTION: CALL POISON CONTROL CTR, EMERG
ROOM, DR. INDUCE VOMIT UNLESS ADVISED (IPECAC THEN WATER/FINGER
DOWN THROAT).

Flash Point Method:SCC
Flash Point:>200F,>93C
Extinguishing Media:SMALL FIRES: FOAM, CO2, DRY CHEMICAL, OR WATER
SPRAY. LARGE FIRES: FOAM, WATER SPRAY, OR FOG.
Fire Fighting Procedures:FIRE FIGHTERS AND OTHERS WHO MAY BE EXPOSED TO
PRODUCTS OF COMBUSITON SHOULD BE EQUIPPED WITH NIOSH POSITIVE
PRESSURE SCBA AND FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:MAY LIBERATE IRRITATING VAPORS DURING
COMBUSTION OR DECOMPOSITION.

Spill Release Procedures:STOP DISCHARGE, DIKE. LARGE SPILL: PUMP,
RECOVER W/VACUUM TRUCK. USE ABSORBENT. PLACE IN CNTNR. USE SAFETY
MEASURES & PROTECTIVE EQUIP. DON'T FLUSH TO SEWER,STREAM,WATER
BODIES UNLESS AUTHORIZED BY GO VERNMENT. MAY NEED TO
REPORT-800-424-8802.

Handling and Storage Precautions:PROTECT FROM FREEZING. STORE IN COOL,
DRY, VENTED AREA. DON'T STORE > 60F. FOLLOW GOOD MANUFACTURING &
HANDLING PRACTICES.
Other Precautions:THIS CONTAINER CAN BE HAZARDOUS WHEN EMPTY, BECAUSE
IT CAN RETAIN RESIDUES. DO NOT REUSE CONTAINER FOR FOOD, CLTOHING
OR PRODUCTS FOR HUMAN OR ANIMAL CONSUMPTION OR WHERE SKIN CONTACT
MAY OCCUR.

Respiratory Protection:ABOVE TLV/PEL, WEAR NIOSH/MSHA APPROVED
EQUIPMENT. SEE RESP MFR FOR APPROP EQUIP. OBEY RESPIRATOR USE
LIMITATION. HIGH CONCENTRATIONS, USE SCBA OR SUPPLIED AIR
RESPIRATOR. RESPIRATORY PROTECTION PROGR AMS MUST BE IN COMPLY W/29
CFR 1910.134.
Ventilation:VENT TO KEEP BELOW TLV/PEL. GENERAL VENT MAY BE ACCEPTABLE.
LOCAL EXHAUST VENT RECOMMENDED WHEN VAPOR/MIST/DUST RELEASED
Protective Gloves:APPROPRIATE IMPERVIOUS GLOVES-SEE MFR
Eye Protection:CHEM SPLSH GOGGLES,SFTY GLASSES W/SDSHLD
Other Protective Equipment:WEAR PROTECTIVE CLOTHING. AN EYEWASH
FACILITY SHOULD BE READILY AVAILABLE.
Supplemental Safety and Health

HCC:N1
Spec Gravity:1.42 (WATER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:GREY VISCOUS FLUID; MILD ODOR
Percent Volatiles by Volume:0

Stability Indicator/Materials to Avoid:YES
AMINES, MERCAPTANS, OXIDIZING AGENTS, ACIDS, STRONG BASES, AMMONIA
Hazardous Decomposition Products:PHENOLICS, SMOKE, SOOT, TOXIC FUMES
(E.G., CARBON DIOXIDE AND CARBON MONOXIDE), METALLIC OXIDES

Waste Disposal Methods:NO HAZARD IF IN ORIGINAL,UNUSED FORM. MANAGE
(STORE/TREAT/DISPOSE/ETC) AT AUTHORIZED FACILITY IN COMPLIANCE
W/FED,STATE,& LOCAL REGS. CONTACT EPA IF FURTHER DISPOSAL GUIDANCE
NEEDED. 1)RECYCLE. 2)INCI NERATE. 3)TREAT AT TREATMENT FACILITY.
4)LANDFILL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.