Product ID:DURABOND CONCRETE WATER STOP-N-PLUG EASY MIX, 71094
MSDS Date:04/24/1992
FSC:5610
NIIN:00N040489
MSDS Number: BSGQL

DAP INC

DAYTON, OH 45401-0277
US

Emergency Phone: 800-543-3840

Info Phone: 513-667-4461

Cage: 90300

DAP INC.

277 DAYTON, OH 45401-0277 US

Telephone: 513-253-7154/800-543-3840

Cage: 90300

SILICATE, PORTLAND CEMENT

CAS: 65997-15-1

RTECS: VV8770000

Fraction By Weight: 60-70%

OSHA PEL 10MG/M3 TDUST,5RDUST

ACGIH TLV: 10 MG/M3 TDUST

CEMENT BINDERS; (CALCIUM ALUMINATE CEMENT)

CAS: 65997-16-2

Fraction By Weight: 30-40%

ACGIH TLV: 10 MG/M3 TDUST (MFR)

CALCIUM OXIDE

CAS: 1305-78-8

RTECS: EW3100000

Fraction By Weight: 1-5%

OSHA PEL 5 MG/M3

ACGIH TLV: 2 MG/M3

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: WET CEMENT CAN DRY SKIN & CAUSE
ALKALI BURNS. EXPOSURE TO DUST MAY RESULT IN BUILD-UP OF MATERIAL
IN EYES, EARS, NOSE AND MOUTH WHICH MAY CAUSE IRRITATION. CHRONIC:
INHALATION OF DUST MAY RESUL T IN PULMONARY AND RESPIRATORY DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ASTHMA AND ASTHMA-LIKE CONDITIONS
MAY WORSEN FROM PROLONGED AND REPEATED EXPOSURE.

First Aid:EYE: FULSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. CONTACT A PHYSICIAN. SKIN: WASH WITH SOAP AND WATER.
INHAL: REMOVE TO FRESH AIR. CONTACT PHYSICIAN IMMEDIATELY. INGEST:
DO NOT INDUCE VO MITING. CONTACT PHYSICIAN OR REGIONAL POISON
CONTROL CENTER IMMEDIATELY.

Flash Point:>200F,>93C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER SPRAY TO COOL EXPOSED SURFACES.
Unusual Fire/Explosion Hazard:NONE KNOWN.

Spill Release Procedures:VACUUM UP AND REUSE EXCESS POWDER. PLACE
REMAINING POWDER INTO CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AWAY FROM CAUSTICS & OXIDIZERS.
KEEP CONTRS TIGHTLY CLSD WHEN NOT IN USE. KEEP OUT OF REACH OF
CHILDREN. KEEP CONTR FROM EXCESS HEAT & FREEZING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:IF 8-HR EXPOS LIM/VALUE IS EXCEEDED FOR ANY
COMPONENT, USE AN NIOSH/MSHA APPROVED RESPIRATOR. CONSULT YOUR
SAFETY EQUIPMENT SUPPLIER AND OSHA REGULATION, 29CFR1910.134 FOR
RESPIRATOR REQUIREMENTS.
Ventilation:NORMAL ROOM VENTILATION.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

Spec Gravity:2.3(H*2O=1)
Solubility in Water:ALKALINE DISPERSION
Appearance and Odor:GRAY POWDER, LOW ODOR
Percent Volatiles by Volume:<1

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND CAUSTICS.
Stability Condition to Avoid:EXCESSIVE HEAT AND FREEZING.
Hazardous Decomposition Products:NONE KNOWN.

Waste Disposal Methods:DISPOSE OF ACCORDING TO FEDERAL, STATE AND LOCAL
STANDARDS. DO NOT REUSE EMPTY CONTAINERS. THIS PRODUCT IS
NON-HAZARDOUS ACCORDING TO U.S. EPA'S HAZARDOUS WASTE MANAGEMENT
REGULATIONS, 40 CFR SECTION 261.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.