Product ID:DURABOND D-50 THIN SET MORTAR, 71155
MSDS Date:08/25/1988
FSC:5610
NIIN:00N042234
MSDS Number: BSVVM

DAP INC

DAYTON, OH 45401-0277
US

Emergency Phone: 800-543-3840;513-667-4461

Info Phone: 800-543-3840;513-667-4461

Cage: 90300

DAP INC.

277 DAYTON, OH 45401-0277 US

Telephone: 513-253-7154/800-543-3840

Cage: 90300

SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 50-60%

OSHA PEL 0.1 MG/M3 RDUST

ACGIH TLV: 0.1 MG/M3 RDUST

SILICATE, PORTLAND CEMENT

CAS: 65997-15-1

RTECS: VV8770000

Fraction By Weight: 25-35%

OSHA PEL 10MG/M3 TDUST,5RDUST

ACGIH TLV: 10 MG/M3 TDUST

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: WET CEMENT CAN DRY SKIN AND
CAUSE ALKALI BURNS. EXPOSURE TO DUST MAY RESULT IN BUILD-UP OF
MATERIAL IN EYES, EARS, NOSE AND MOUTH WHICH MAY CAUSE IRRITATION.
CHRONIC: INHAL OF DUST MAY RESULT I N PULMONARY AND RESPIRATORY
DAMAGE.
Explanation of Carcinogenicity:CRYSTALLINE SILICA-QUARTZ: IARC
MONOGRAPHS, SUPPLEMENT VOL 7, PG 341, 1987: GRP 2A. NTP 7TH ANNUAL
REPORT ON (SUPP DATA)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ASTHMATIC CONDITIONS MAY WORSEN
FROM PROLONGED AND REPEATED EXPOSURE.

First Aid:EYE: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. CONTACT A PHYSICIAN IMMEDIATELY. SKIN: WASH WITH SOAP AND
WATER. INHAL: REMOVE TO FRESH AIR. CONTACT PHYSICIAN IMMEDIATELY.
INGEST: DO N OT INDUCE VOMITING. CONTACT PHYSICIAN OR REGIONAL
POISON CONTROL CENTER.

Flash Point:NONE
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER SPRAY TO COOL EXPOSED SURFACES.
Unusual Fire/Explosion Hazard:NONE KNOWN.

Spill Release Procedures:USE ABSORBENT MATERIAL OR SCRAPE UP DRIED
MATERIAL AND PLACE INTO CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:IF 8-HOUR EXPOSURE LIMIT OR VALUE IS EXCEEDED
FOR ANY COMPONENT, USE A NIOSH/MSHA APPROVED RESPIRATOR, CONSULT
YOUR SAFETY EQUIPMENT SUPPLIER AND OSHA REGULATION, 29 CFR 1910.134
FOR RESPIRATORY REQUI REMENTS.
Ventilation:IF DRY-SANDING, PROVIDE SUFFICIENT MECHANICAL VENTILATION
TO MAINTAIN EXPOSURE BELOW PEL AND TLV.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APRV CHEM WORK GOGG .
Other Protective Equipment:PROVIDE EYEWASH AND IMPERVIOUS APRON IF BODY
CONTACT WITH PRODUCT MAY OCCUR.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
SOL IN H2O: FORMS AN ALKALINE DISPERSION WITH WATER. EXPLAN OF CARCIN:
CARCINOGENS, 1991: ANTIC TO BE A CARCIN.

HCC:N1
Spec Gravity:2.3-2.4(H2O=1)
Solubility in Water:SUPP DATA
Appearance and Odor:SANDY GRAY OR WHITE FREE-FLOWING POWDER
Percent Volatiles by Volume:<1

Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:EXCESSIVE HEAT AND FREEZING.
Hazardous Decomposition Products:NONE KNOWN.

Waste Disposal Methods:DISPOSE OF ACCDG TO FEDERAL, STATE AND LOCAL
STANDARDS. DO NOT REUSE EMPTY CONTAINERS. THIS PRODUCT IS
NON-HAZARDOUS ACCORDING TO U.S. EPA'S HAZARDOUS WASTE MANAGEMENT
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.