Product ID:N-5544S BLUE GRAY SILICONE ENAMEL
MSDS Date:11/23/1993
FSC:8010
NIIN:01-374-8954
MSDS Number: BTCQF

NILES CHEMICAL PAINT CO

225 FORT STREET
NILES, MI 49120
US

Emergency Phone: 219-236-5856

Info Phone: 616-683-3377

Preparer: MICHAEL LICHATOWICH

Cage: 02388

NILES CHEMICAL PAINT

307 NILES, MI 49120 US

Telephone: 616-683-3377/219-236-5856

Cage: 02388

HIGH SOLIDS SILICONE (VAPOR PRESSURE 1.5 MM HG @ 20C)

Fraction By Weight: 33%

GROUND LIMESTONE

CAS: 1317-65-3

RTECS: EV9580000

Fraction By Weight: 30%

MINERAL SPIRITS (VAPOR PRESSURE 0 MM HG)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 16%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

VM&P NAPHTHA HI FLASH (VAPOR PRESSURE 15 MM HG @ 37.7C)

Fraction By Weight: 8%

OSHA PEL 500 PPM

ACGIH TLV: 350 PPM

COBALT COMPOUNDS (AS CO) (SARA III)

CAS: 7440-48-4

RTECS: GF8750000

Fraction By Weight: <1%

OSHA PEL 0.1 MG/M3

ACGIH TLV: 2 MG/M3

PROPRIETARY INGREDIENTS (MFR STATES UNIDENTIFIED

Fraction By Weight: BALANCE

2.81 LBS/GAL

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRIT, TEARING, REDNESS,
BLURRED VISION. SKIN: REDNESS & IRRIT, DEFATTING LEADING TO
DERMATITIS. INHAL: NASAL & RESPIRATORY IRRIT, CNS DEPRESSION
(DIZZINESS,DROWSINESS,WEAKNESS,FATIGUE,CO NFUSION) NAUSEA,
HEADACHE, VERTIGO, UNCONSCIOUS, ASPHYXIATION. INGEST: GI IRRIT,
ABDOM PAIN, NAUSEA, VOMITING, DIARRHEA.
Effects of Overexposure:TARGET ORGANS: SKIN, EYES, RESPIRATORY SYSTEM,
CNS
Medical Cond Aggravated by Exposure:NONE KNOWN

First Aid:INHAL:MOVE TO FRESH AIR IMMED.IF BREATH STOPS,GIVE ARTIF
RESP.GET MED AID ASAP. SKIN:IMMED FLUSH W/WATER.IF PENETRATES
CLOTHING,REMOVE CONTAM CLOTHES.FLUSH SKIN W/WATER.GET MED AID.WASH
CLOTHES & DECO NTAM SHOES BEFORE REUSE. EYE:IMMED FLUSH W/WATER 15
MIN,LIFT EYELIDS.GET MED AID IMMED.DON'T WEAR CONTACTS.
INGEST:DRINK 1-2 GLASSES WATER.DON'T INDUCE VOMITING.SEE DR/POISON
CNTRL CTR.TREAT SYMPTOMS.

Flash Point Method:TCC
Flash Point:107F,42C
Lower Limits:0.0
Upper Limits:0.8
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR SCBA W/FULL FACEPIECE IN POSITIVE
PRESSURE MODE & PR0TECT CLOTHING. USE WATER TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BLDUP, AUTOIGNITION, EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD.VAPOR HEAVY,TRAVEL ON
GRND TO IGNIT.KEEP FROM HEAT/IGNIT.CLSD CNTNR EXPLODE W/HEAT.APPLIC
TO HOT SRFCS REQ SPCL CAUTN.DECOMP PRODUCT-HEALTH HZD.

Spill Release Procedures:ELIMINATE IGNIT SOURCE. MINIMIZE BREATHING OF
VAPOR. AVOID SKIN CONTACT. ABSORB W/INERT MAT'L (CLAY,SOIL,COMMRCL
ABSORBENT). SHOVEL RECLAIMED LIQ & ABSORBENT INTO RECOVERY/SALVAGE
DRUMS FOR DISPOSAL. DIKE LRG SPILLS, & RECLAIM INTO DRUMS/TANK
TRUCK.

Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR FIRE OR OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT
IN USE. AVOID ROUGH HANDLING.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD OR FLAME CUT ON EMPTY DRUMS.

Respiratory Protection:WEAR APPROPRIATE (TC-23C-75) FITTED HALF-MASK OR
FULL FACEPIECE RESPIRATOR (NIOSH/MSHA) DURING & AFTER APPLICATION
UNLESS AIR MONITORING DEMONSTRATES VAPOR LEVELS BELOW APPLICABLE
LIMITS. FOLLOW RESPI RATOR MANUFACTURER'S DIRECTIONS FOR USE.
Ventilation:PROVIDE VENT TO KEEP AIR CONCENTRATION BELOW PEL/TLV.
REMOVE DECOMP PRODUCTS. VENT VAPOR FORMED WHEN BAKING FINISHED.
Protective Gloves:CHEMICAL RESISTANT (NITRILE OR VITON)
Eye Protection:GOGGLES, SAFETY GLASSES, FACE SHIELD
Other Protective Equipment:WEAR CHEM RESISTANT (NITRILE OR VITON)
CLOTHING AS NEEDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
RESTROOM.
Supplemental Safety and Health
EMPLOYEES SHOULD WASH PROMPTLY WHEN SKIN BECOMES CONTAMINATED. REMOVE
ANY CLOTHING THAT BECOMES WET (TO AVOID FLAMMIBILITY HAZARD) AND
WASH BEFORE REUSE.

Boiling Pt:B.P. Text:285 TO 398F
Vapor Density:> AIR
Spec Gravity:1.286
Viscosity:100 KU MAX
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Percent Volatiles by Volume:41.93
Corrosion Rate:MINIMAL

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZERS
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND CARBON
DIOXIDE
Conditions to Avoid Polymerization:HIGH TEMPERATURES, SHOCK FROM
DROPPING

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE, AND FEDERAL REGULATIONS. EPA HAZARDOUS WASTE CODE: D001,
IGNITABLE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.