Product ID:SOLVENT CEMENT
MSDS Date:06/01/1990
FSC:8040
NIIN:00N043655
MSDS Number: BTLMD

NIBCO INC

2929 WEST MAGAZINE ST
LOUISVILLE, KY 40211
US

Emergency Phone: 303-623-5716

Info Phone: 303-623-5716

Cage: 61623

NIBCO INC

LOUISVILLE, KY 40211 US

Telephone: 303-623-5716

Cage: 61623

2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 65-75%

OSHA PEL 200 PPM;300 PPM STEL

ACGIH TLV: 200 PPM;300 PPM STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ACRYLONITRILE, POLYMER WITH 1,3 BUTADIENE AND STYRENE; (ABS

CAS: 9003-56-9

RTECS: AT6970000

Fraction By Weight: 23-33%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:SEV OVEREXP MAY RSLT IN
NAUS, DIZZ, HDCH. CAN CAUSE DROW, IRRIT OF EYES & NASAL PASSAGES.
HAS CAUSED CNS DEPRESS, LIVER/KIDNEY DMG IN ANIMALS & HIGH CONC
HAVE CAUSED RETARDATION OF FETAL D EVEL IN RATS. SKIN:IRRIT. LIQ
CONT MAY REMOVE NATRL SKIN OILS RESULTING IN IRRIT. DERM MAY OCCUR
W/ (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:PRLNG CONT. PRLNG/WIDESPREAD EXPOS MAY
RSLT IN ABSORPTION OF HARMFUL AMTS OF MATL. EYE:OVEREXP MAY RSLT IN
SEV INJURY W/CORNEAL/CONJ INFLAMM ON CONT W/LIQ. VAPS SLIGHTLY
UNCOMFORTABLE. INGEST :MOD TOX. MAY CAUSE NAUS, VOMIT, DIARR.MAY
CAUSE MENTAL SLUGGISHNESS. CHRONIC:NONE CURRENTLY KNOWN. REPRO/NERV
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE CURRENTLY KNOWN.

First Aid:INHAL:REMOVE TO FRESH AIR & IF BRTHG STOPPED, GIVE ARTF RESP
- PREFERABLY MOUTH-TO-MOUTH. IF BRTHG IS DFCLT, GIVE OXYGEN. CALL
MD. EYE:FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS & CALL MD.
SKIN:REMOVE CONTAM CLTHG & SHOES. WASH SKIN W/PLENTY OF SOAP &
WATER FOR AT LST 15 MINS. IF IRRIT DEVELOPS, GET MED ATTN.
INGEST:GIVE 1-2 GLASSES OF WATER/MILK. DO NOT INDUCE VOMIT. CALL
MD/POIS CTL CTR IMMED.

Flash Point Method:TOC
Flash Point:24.0F,-4.4C
Lower Limits:2%
Upper Limits:10%
Extinguishing Media:FOR SMALL FIRES:USE DRY CHEM, CO2, WATER/FOAM
EXTING.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . FOR LARGE FIRES:EVACUATE AREA & CALL FIRE DEPARTMENT
IMMEDIATELY.
Unusual Fire/Explosion Hazard:FIRE HAZARD BECAUSE OF LOW FLASH POINT &
HIGH VOLATILITY. VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL TO SOURCE
OF IGNITION.

Spill Release Procedures:VENTILATE AREA, STOP LEAK IF IT CAN BE DONE
W/OUT RISK. TAKE UP W/SAND, EARTH OR OTHER ABSORBING MATERIAL.
PREVENT LIQUID FROM ENTERING DRAINS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:CONTAINERS, EVEN THOSE THAT HAVE BEEN EMPTIED, WILL
RETAIN RESIDUE & VAPORS. HANDLE EMPTY CONTAINERS AS IF THEY WERE
FULL.

Respiratory Protection:IN SITUATIONS WHERE VAPOR CONCENTRATIONS EXCEED
RECOMMENDED EXPOSURE LIMITS, USE NIOSH/MSHA APPROVED ORGANIC VAPOR
CARTRIDGE RESPIRATOR W/FULL FACE-PIECE IS RECOMMENDED. USE ONLY
NIOSH/MSHA APPROVED S CBA FOR EMERGENCIES.
Ventilation:EXPLOSION-PROOF GENERAL MECHANICAL VENT/LOCAL EXHAUST IS
REC TO MAINTAIN VAPOR CONCS BELOW REC EXPOS LIMITS.
Protective Gloves:PVA COATED GLOVES.
Eye Protection:ANSI APRV CHEM WORK GOGG W/ SUPDAT)
Other Protective Equipment:IMPERVIOUS APRON & A SOURCE OF RUNNING
WATER.
Work Hygienic Practices:FLUSH OR WASH EYES & SKIN IN CASE OF CONTACT.
Supplemental Safety and Health
% VOLAT:74 +/- 4%. EFTS OF OVEREXP:SYSTEM TOXIN, LUNG/LIVER/KIDNEY
TOXIN. EYE PROT: FULL LENGTH FACESHIELD .

HCC:F3
Boiling Pt:B.P. Text:176F,80C
Vapor Pres:100 @ 25C
Vapor Density:2.5
Spec Gravity:0.85 +/- 0.02
Evaporation Rate & Reference:2.7 (ETHER=1)
Solubility in Water:SOLUBLE
Appearance and Odor:MILKY OPAQUE LIQUID; SHARP SWEETISH ODOR.
Percent Volatiles by Volume:SUPDAT

Stability Indicator/Materials to Avoid:YES
CAUSTICS, AMMONIA, INORGANIC ACIDS, CHLORINATED COMPOUNDS, STRONG
OXIDIZERS & ISOCYANATES.
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME &
OTHER SOURCES OF IGNITION. ALL HANDLING EQUIP SHOULD BE
ELECTRICALLY GROUNDED.
Hazardous Decomposition Products:WHEN FORCED TO BURN, THIS PRODUCT
GIVES OUT CARBON MONOXIDE, CARBON DIOXIDE & BLACK SMOKE.
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT, SPARKS, OPEN
FLAME & OTHER SOURCES OF IGNITION.

Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE & FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.