Product ID:LUXLITE BLACK, 43-102
MSDS Date:02/20/1991
FSC:8010
NIIN:00N045878
MSDS Number: BTMMT

PRESERVATIVE PAINT CO

5502 AIRPORT WAY SO
SEATTLE, WA 98108
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 206-763-0300

Cage: 86589

PRESERVATIVE PAINT CO

80387 SEATTLE, WA 98108-1726 US

Cage: 86589

15 @

CAS: 64742-89-8

Fraction By Weight: 25%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

21 @ 100F

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 14%

OSHA PEL 100 PPM; 150 STEL

ACGIH TLV: 100 PPM; 150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

2 @

CAS: 64742-88-7

Fraction By Weight: 5%

OSHA PEL N/K

ACGIH TLV: 100 PPM (MFR)

2

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 10%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 5%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

4.09 LB/GL (490 G/L)

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

STORE OUT OF REACH OF CHILDREN.

RTECS: 9999999ZZ

SPRAY BOOTH CLEAN. AVOID BUILDUP OF SPRAY DUST

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: OVEREXP TO SOLV MAY CAUSE CNS
DEPRESS, CARDIOPULM FAILURE, LIVER & KIDNEY DMG & BIRTH DEFECTS.
INHAL:MAY CAUSE NOSE & THROAT IRRIT. MAY CAUSE CNS DEPRESS CHARACT
BY HDCH, DIZZ, NAUS, STAGGERING GAIT, CONFUSION & UNCON. EYES:MAY
CAUSE IRRIT/BURNING. SKIN:RPTD/PRLNG LIQ CNTCT MAY CAUSE IRRIT
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:W/DISCOMFORT & DERM. ABSORPTION CAUSES
REDNESS W/BURNING SENSATION. INGEST:MAY CAUSE GI DISTRESS. CHRONIC:
RPTS HAVE ASSOC RPTD & PRLNG OVEREXP TO SOLV W/PERM BRAIN & NERVOUS
SYS DMG. UNDER N ORM CONSUMER USE CNDTNS LIKELIHOOD OF ANY ADVERSE
HLTH EFTS ARE LOW. OVERSPRAY & MISTS ARE PRIMARILY CONSIDERED
(SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS INVOLVING
SKIN, LIVER, KIDNEY & PULMONARY DISORDERS.

First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CALL MD.
SKIN: REMOVE CONTAMINATED CLOTHING & WASH EXPOSED AREA WITH SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RE SPIRATION, PREFERABLY MOUTH-TO-MOUTH. IF BREATHING
DIFFICULTY PERSISTS OR OCCURS LATER, CONSULT MD. INGESTION: CALL MD
IMMEDIATELY. DO NOT INDUCE VOMITING.

Flash Point Method:TCC
Flash Point:67.0F,19.4C
Lower Limits:1.0%
Upper Limits:7.0%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG,
OTHER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . COOL CLOSED CONTAINERS WITH WATER FOG TO
PREVENT PRESSURE BUILDUP.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. VAP IS DENSER
THAN AIR & CAN TRAVEL & COLLECT IN LOW SPOTS. ISOLATE FROM HEAT,
ELEC EQUIP, SPK & OPEN FLAME. CLSD CNTNRS MAY (SUPDAT)

Spill Release Procedures:VENTILATE AREA. REMOVE ALL SOURCES OF
IGNITION. PREVENT SKIN CONTACT AND BREATHING OF VAPORS. CONFINE AND
REMOVE WITH INERT ABSORBANT MATERIAL. USE SPARK PROOF TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PREC. KEEP AWAY FROM
EXCESSIVE HEAT, SPK & OPEN FLAME. KEEP CLOSURES TIGHT WHEN NOT IN
USE. STORE IN UPRIGHT POSITION TO PVNT (SUPDAT)
Other Precautions:DO NOT SAND, FLAME CUT, BRAZE/WELD DRY COATING W/OUT
WEARING NIOSH/MSHA APPRVD RESP/APPROP VENT. CNTNRS OF MATL MAY BE
HAZ WHEN EMPTIED. SINCE EMPTY CNTNRS RETAIN RESIDUES, ALL HAZ PREC
MUST BE OBSERV ED. WHEN SPRAYING MATL KEEP (ING 8)

Respiratory Protection:PROPERLY FITTED VAPOR/PARTICULATE RESPIRATOR
APPROVED BY NIOSH/MSHA.
Ventilation:SUFFICIENT IN PATTERN & VOLUME TO KEEP VAP BELOW APPLIC
OSHA REQUIREMENTS. USE EXPLO-PROOF MECHANICAL DEVICE IF REQD.
Protective Gloves:SOLVENT IMPERVIOUS GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKER GOGGLES .
Other Protective Equipment:ANSI APPRVD SFTY SHOWER & EYE BATH.
COVERALLS ARE RECOM. SOLVENT IMPERVIOUS APRON IS RECOM IF BODY
CONTACT MAY OCCUR.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
PERIODIC MONITORING OF EXPOSURE LEVELS/LIMITS IS RECOMMENDED.
Supplemental Safety and Health
EXPLO HAZ:EXPLODE WHEN EXPOS TO EXTREME HEAT. DO NOT APPLY TO HOT SURF.
CAN CAUSE SPONT COMBUST (CONTAMD RAGS, ETC) . EFTS OF
OVEREXP:NUISANCE DUST-NOT NORM CONSIDERED HAZ IN PROD MIX. HNDLG/
STOR PRE C:LEAKAGE. GROUND CNTNR WHEN POURING. WASH THORO AFTER
HNDLG & BEFORE EATING/SMKNG. DO NOT STORE > 100F. KEEP & (ING 7)

HCC:F3
Boiling Pt:B.P. Text:>139F,>59C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:0.9 (H2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR AND PIGMENTED COATINGS WITH CHARACTERISTIC
ODOR.

Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:NONE REASONABLY FORESEEABLE.
Hazardous Decomposition Products:OXIDES OF CARBON.

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. ABSORB LARGE SPILLS WITH INERT ABSORBANT MATERIAL.
DISPOSE OF ABSORBED MATERIAL IN ACCORDANCE WITH FEDERAL, STATE &
LOCAL REGULATORY REQUIREM ENTS. DO NOT INCINERATE IN CLOSED
CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.