Product ID:#902 BLACK PLASTIC RUBBER
MSDS Date:01/23/1992
FSC:8030
NIIN:01-116-5029
MSDS Number: BTSHQ

DYNATRON/BONDO CORP

2160 HILLS AVE
ATLANTA, GA 30318-2217
US

Emergency Phone: 404-696-2730/800-241-3386

Info Phone: 404-696-2730

Preparer: S. ABDUL RAZZAK

Cage: 16522

BONDO/MAR-HYDE CORP

ATLANTA, GA 30331 US

Telephone: 404-696-2730

Cage: 16522

LACOLENE

Fraction By Weight: 20-25%

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 35-40% %

OSHA PEL 200 PPM; Z-2

ACGIH TLV: S, 50 PPM; 9394

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 1-5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM/150STEL;9394

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ACETONE (SARA III)

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 1-5%

OSHA PEL 1000PPM

ACGIH TLV: 750PPM/1000STEL;9394

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: PRODUCT CONTAINS SMALL AMOUNT
OF XYLENE WHICH HAS BEEN FOUND TO CAUSE THE FOLLOWING EFFETCS IN
LABORATORY ANIMALS: ANEMIA, LIVER ABNORMALITIES, KIDNEY & EYE
DAMAGE. CHRONIC: NONE SPECIFIED BY M ANUFACTURER.
Explanation of Carcinogenicity:NONE OF THE COMPONENTS OF THIS MATERIAL
ARE LISTED AS CARCINOGENS NY NTP, IARC, OR OSHA.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN, EYE & LUNG
DISORDERS COULD BE AGGRAVATED BY DIRECT CONTACT.

First Aid:EYES: FLUSH WITH LOTS OF WATER FOR 15 MINUTES, HOLD LIDS
OPEN. GET MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOTHES. INHALED: REMOVE TO FRESH AIR. IF BREATHING
DIFFICULT, GIVE OXYGEN. IF BREATHING STOPPED, GIVE ARTIFICIAL
RESPIRATION. INGESTED: IF CONSCIOUS, IMMEDIATELY DRINK 2 GLASSES OF
WATER & INDUCE VOMITING. GET MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:34.0F,1.1C
Lower Limits:1.2
Upper Limits:7
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, REGULAR FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE
-PRESSURE MODE WHEN FIGHTING FIRES.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL
TO DISTANT SOURCE OF IGNITION/IGNITE/FLASHBACK. NEVER USE WELDING
OR CUTTING TORCH NEAR PRODUCT CONTAINER-MAY EXPLODE.

Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. ABSORB
LIQUID ON PAPER, VERMICULITE, OR OTHER ABSORBENT MATERIAL &
TRANSFER TO HOOD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DANGER-FLAMMABLE! VAPORS MAY CAUSE
FLASH FIRE. VAPORS MAY IGNITE EXPLOSIVELY. VAPORS HARMFUL. AVOID
PROLONGED CONTACT WITH SKIN.
Other Precautions:MAY BE HARMFUL OR FATAL IF SWALLOWED. REMOVE IGNITION
SOURCES DURING USE AND UNTIL ALL VAPORS ARE GONE. KEEP OUT OF REACH
OF CHILDREN. CLOSE CONTAINER AFTER EACH USE.

Respiratory Protection:AVOID BREATHING VAPORS. USE IN WELL VENTILATED
AREA.
Ventilation:LOCAL EXHAUST IN SUFFICIENT VOLUME & PATTERN TO MAINTAIN
TLVS BELOW STATED LIMITS. EXPLOSION-PROOF EQUIPMENT.
Protective Gloves:SOLVENT RESISTANT GLOVES-NITRILE RUBBER
Eye Protection:SAFETY GLASSES WITH SIDESHIELDS
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS: WASH
AHNDS AFTER USE & BEFORE EATING.LAUNDER CONTAMINATED CLOTHES BEFORE
REUSE
Supplemental Safety and Health
WARNING! OUR PRODUCTS MAY CONTAIN TRACE AMOUNTS OF SOME CHEMICALS
CONSIDERED BY THE STATE OF CALIFORNIA TO BE CARCINOGENS OR
REPRODUCTIVE TOXICANTS. [MSDS ENTERED BY DLA-HMIS UNDER PROJECT
WITH GSA]

HCC:F2
Boiling Pt:B.P. Text:217F,103C
Vapor Pres:34MMHG@68F
Vapor Density:HEAVIER
Spec Gravity:1.0
Evaporation Rate & Reference:4.4 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK; TOLUENE ODOR

Stability Indicator/Materials to Avoid:YES
NONE. DLA-HMIS: STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME. DLA-HMIS:
AVOID EXPOSURE TO STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:IF BURNED, CARBON DIOXIDE, CARBON
MONOXIDE, VARIOUS HYDROCARBONS.

Waste Disposal Methods:DESTROY BY LIQUID INCINERATION.DISPOSE OF
CONTAINERS IN ACCORDANCE WITH LOCAL,STATE & FEDERAL
REGULATIONS.DLA-HMIS:EPA/RCRA WASTE NUMBERS D001(IGNITABLE),U002
(ACETONE),U220(TOLUENE),U239(XYLENES) MAY APPLY TO
UNUSED/UNCONTAMINATED PRODUCT.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.