Product ID:MIL-C-2275E #11136 RED ORGANIC COATING F-09P191
MSDS Date:09/29/1993
FSC:8010
NIIN:01-313-8108
Kit Part:Y
MSDS Number: BTTMC

SEAGRAVE COATINGS CORP OF VIRGINIA,SEAGUARD DIV

4030 SEAGUARD AVE
PORTSMOUTH, VA 23705
US

Emergency Phone: 804-488-4411

Info Phone: 804-488-4411

Cage: 60163

SHERWIN-WILLIAMS, SEAGUARD

PORTSMOUTH, VA 23704 US

Telephone: 757-397-2223

Cage: 60163

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 35%

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 0.1 MG/M3 RDUST;9394

HEAVY AROMATIC NAPHTHA

CAS: 64742-94-5

Fraction By Weight: 10-15%

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 20%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM/300STEL 9394

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN:IRRITATION.
INHALATION: NARCOSIS, RESPIRATORY TRACT IRRITATION, CNS DEPRESSION.
INGESTION: GI IRRITION. CHRONIC:CANCER, CNS & BRAIN DAMAGE. TARGET
ORGANS: LUNGS, CNS AND BRAIN.
Explanation of Carcinogenicity:SILICA IS AN ANTICIPATED CARCINOGEN BY
NTP AND A PROBABLE CARCINOGEN BY IARC.
Effects of Overexposure:EYES:REDNESS, BLURRED VISION. SKIN: REDNESS,
DRYNESS. INHALATION: DIZZINESS, DROWZINESS, FATIGUE, CONFUSION,
NUASEA, HEADACHE, UNCONSCIOUSNESS. INGESTION:ABDOMINAL PAIN,
NAUSEA, VOMITING AND DIARRHEA.
Medical Cond Aggravated by Exposure:LUNG, CNS AND BRAIN DISORDERS.

First Aid:INHALATION:REMOVE TO FRESH AIR, PROVIDE CPR/OXYGEN IF NEEDED.
EYE CONTACT:FLUSH WITH WATER FOR 15 MINUTES. GET MEDICAL HELP. SKIN
CONTACT:WASH WITH SOAP AND WATER. GET MED ATTENTION IF SYMPTOMS
PERSIS T. INGESTION:DO NOT INDUCE VOMITING, DRINK 1-2 GLASSES OF
WATER. GET MEDICAL HELP IMMEDIATELY.

Flash Point Method:TCC
Flash Point:24.0F,-4.4C
Lower Limits:1.8
Upper Limits:17.8
Extinguishing Media:WATER FOG, DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR SCBA W/FULL FACEPIECE OPERATED IN POS
PRESSURE MODE & FULL PROTECTIVE CLOTHING. USE WATER TO COOL CLSD
CNTNRS (PREVENT PRESSURE BLDUP/AUTO IGNIT/EXPLOSION.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR, MAY SETTLE
AT LOW AREAS OR TRAVEL SOME DISTANCE ALONG THE GROUND TO IGNITION
SOURCES WHERE THEY MAY IGNITE & FLASH BACK.

Spill Release Procedures:ELIM IGNITION SOURCES. MINIMIZE BREATHING
VAPORS. AVOID SKIN CONTACT. ABSORB W/INERT MATERIAL AND TRANSFER
INTO DRUMS. LRG SPILLS: DIKE AREA, RECLAIM BY PUMPING OR ABSORB
WITH INERT MATERIAL INTO DRUM S FOR DISPOSAL.

Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR FIRE OR OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT
IN USE. AVOID ROUGH HANDLING.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD OR FLAME CUT ON EMPTY DRUMS.

Respiratory Protection:WEAR APPROPRIATE PROPERLY FITTED HALF- MASK OR
FULL FACEPIECE RESPIRATOR (NIOSH/MSHA) FOR ORGANIC VAPORS AND DUST
UNLESS AIR MONITORING LEVELS ARE BELOW TLV. FOLLOW RESPIRATOR
MANUFACTURER'S DIRECTION S FOR USE.
Ventilation:SUFFICIENT VENTILATION IN VOL/PATTERN TO KEEP AIR CONC
BELOW PERMISSIBLE TLV/PEL LIMITS.
Protective Gloves:NITRILE OR VITON GLOVES.
Eye Protection:CHEM GOGGLES, SAFETY GLASSES, FACE SHLD
Other Protective Equipment:WEAR CHEMICAL RESISTANT (NITRILE OR VITON)
GLOVES AND CLOTHING AS NEEDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:REMOVE CLOTHING THAT BECOMES WET (AVOID FLAMM
HZD). WASH BEFORE REUSE. WASH HANDS BEFORE EATING, SMOKING, USING
RESTROOM
Supplemental Safety and Health
USE IN A WELL VENTILATED AREA, AVOID INHALATION. KIT CONSISTS OF 1/2
QUART OF EACH COMPONENT A AND B.

HCC:F2
Boiling Pt:=79.C, 174.2F
B.P. Text:175F,79C
Vapor Density:> AIR
Spec Gravity:WT 10.5 LBS/GAL
Viscosity:100 KU MAX
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:LIQUID, SOLVENT ODOR.
Percent Volatiles by Volume:39.9
Corrosion Rate:MINIMAL

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS AND OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
SILOCONE DIOXIDE.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.