Product ID:TT-L-32A BLACK, 17038
MSDS Date:01/25/1994
FSC:8010
NIIN:00-171-1509
MSDS Number: BTZVZ

GARDCO DIVERSIFIED INC

228-B PATTERSON AVE
HAMPTON, VA 23669
US

Emergency Phone: 804-722-9155

Info Phone: 804-722-9155

Preparer: BJG

Cage: DO292

GARDCO DIVERSIFIED, INC

HAMPTON, VA 23669

Telephone: 804-722-9155

Cage: DO292

TOLUENE (SARA III) (VAPOR PRESSURE 4.2 MM HG @ 68F)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 14%

OSHA PEL 50 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYL ETHYL KETONE (SARA III) (VAPOR PRESSURE 70 MM HG @

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 12%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ISOPROPYL ALCOHOL (VAPOR PRESSURE 33 MM HG @ 68F)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 9%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

XYLENE (SARA III) (VAPOR PRESSURE 4.2 MM HG @ 68F)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 3%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ETHYL ACETATE

CAS: 141-78-6

RTECS: AH5425000

Fraction By Weight: 5%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LAMP BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 3%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

537 GRAMS/LITER (4.47 LBS/GAL)

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL:NASAL & RESPIRATORY IRRIT,
DIZZINESS, FATIGUE, NAUSEA, HEADACHE, UNCONSCIOUSNESS,
ASPHYXIATION. SKIN:PROLONGED/REPEATED CONTACT:IRRIT.
ABSORPTION:POTENTIAL HAZARD. EYE:SEVERE IRRIT, REDNESS, TEA RING,
BLURRED VISION. INGEST:GI IRRIT, NAUSEA, VOMITING, DIARRHEA,
ASPIRATION INTO LUNG:CHEM PNEUMONITIS-CAN BE FATAL.
Effects of Overexposure:ACUTE: IRRITATION OF SKIN, EYES, MUCOUS
MEMBRANES, DRYING, DEFATTING OF SKIN. AVOID INGESTION AND BREATHING
OF VAPORS. CHRONIC: EYE, LIVER, KIDNEY, AND CENTRAL NERVOUS SYSTEM
DAMAGE MAY OCCUR.
Medical Cond Aggravated by Exposure:MAY PROVOKE ASTHMATIC RESPONSE IN
PERSON WITH ASTHMA WHO ARE SENSITIVE TO AIRWAY IRRITANT.

First Aid:IF SPILLED ON SKIN OR IN EYE, WASH WITH COPIOUS QUANTITIES OF
WATER, CONTACT PHYSICIAN IF SPILLED IN EYE. IF INGESTED, DO NOT
INDUCE VOMITING, KEEP PERSON WARM, QUIET AND CONTACT PHYSICIAN.
BREATHING: REMOVE PERSON TO FRESH AIR GIVE OXYGENIF BREATHING
DIFFICULT; GIVE ARTIFICIAL RESPIRATION IF BREATHING STOPS. KEEP
PERSON WARM AND GET MEDICAL HELP.

Flash Point Method:PMCC
Flash Point:>24F,>-4C
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS W/FULL
FACE PIECE OPERATED IN PRESSURE DEMAND OR OTHER POSITIVE PRESSURE
MODE WHEN FIGHTING FIRES.
Unusual Fire/Explosion Hazard:VAPORS HEAVIER THAN AIR MAY TRAVEL ALONG
GROUND OR MOVED BY VENT & IGNITED BY HEAT, PILOT LIGHTS, FLAMES, &
IGNITION SOURCES AT LOCATIONS DISTANT FROM SOURCE.

Spill Release Procedures:DIKE UP AND CONTAIN SPILL WITH INERT MATERIAL,
MOP UP AND PLACE MATERIAL INTO CONTAINERS. PREVENT RUN-OFF TO
SEWER, STREAMS. NOTIFY AUTHORITIES.

Handling and Storage Precautions:DO NOT STORE/USE IN HIGH TEMP AREAS OR
NEAR HEAT, SPARK, FLAME. KEEP CLOSURE TIGHT & CONTAINER UPRIGHT TO
PREVENT LEAK. STORE IN VENTED AREA.
Other Precautions:AVOID CONTACT WITH OR BREATHING OF VAPORS RELEASED
DURING CURING PROCESS. DO NOT TAKE INTERNALLY. AVOID CONTACT WITH
SKIN AND EYES. AVOID BREATHING OF VAPORS OR SPRAY MIST. ALL HAZARD
PRECAUTIONS GIVE N IN MSDS MUST BE OBSERVED.

Respiratory Protection:IF ABOVE TLV,NIOSH/MSHA AIR SUPPLD RESPIRATION
ADVISED IN ABSENCE OF ENVIRONMENTAL CONTROL. OSHA REGS ALSO PERMIT
OTHER NIOSH/MSHA RESPIRATOR UNDER SPECIFIED CONDITIONS (SEE SFTY
EQUIP SUPPLIER).IMPLE MENT ENGINEERING/ADMINISTRATIVE CONTROL.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:WEAR RESISTANT GLOVES (NITRILE RUBBER)
Eye Protection:CHEM SPLASH GOGGLES.CHECK OTHER PERMITD.
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM.
Supplemental Safety and Health

HCC:F2
Boiling Pt:B.P. Text:175 TO 314F
Vapor Density:> AIR
Spec Gravity:0.97 (WATER=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT SOLUBLE
Appearance and Odor:GREEN VISCOUS LIQUIDS WITH LACQUER SOLVENT ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NEVER USE WELDING OR CUTTING TORCH ON/NEAR
DRUMS (EVEN EMPTY) BECAUSE PRODUCT (EVEN RESIDUE) CAN IGNITE
EXPLOSIVELY.

Waste Disposal Methods:SMALL:ALLOW VOLATILE PRT TO EVAPORATE IN HOOD.
ALLOW TIME FOR VAPOR TO CLEAR HOOD DUCT. DISPOSE OF REMAINING MAT'L
IN ACCORD W/REGS. LRG:DESTROY BY LIQ INCINERATION. CONTAM ABSORBENT
MAY BE DEPOSITED IN LANDFILL IN ACCORD W/LOCAL, STATE, &FED REGS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.