Product ID:730 SOLVENT RESISTANT SEALANT
MSDS Date:10/22/1992
FSC:5330
NIIN:01-259-0770
MSDS Number: BVFNB

DOW CORNING CORP

SOUTH SAGINAW RD
MIDLAND, MI 48686
US

Emergency Phone: 517-496-5900

Info Phone: 517-496-6000

Preparer: JACK L. SHENEBERGER

Cage: 5D028

DOW CORNING CORP

AUBURN, MI 48611 US

Telephone: 517-496-4388

Cage: 71984

VINYLTRIACETOXYSILANE

CAS: 4130-08-9

Fraction By Weight: 6%

OSHA PEL 10 PPM (MFR)

ACGIH TLV: 10 PPM; 15STEL (MFR)

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 7%

OSHA PEL 10 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

TRIMETHYLATED SILICA

CAS: 68909-20-6

Fraction By Weight: 8%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:DIRECT CONTACT IRRITATES. MAY BE
SERIOUS WITH REDNESS, SWELLING & SOME CORNEAL INJURY LASTING
SEVERAL DAYS TO A WEEK. SKIN:SINGLE SHORT EXPOSURE (< 24 HRS) MAY
IRRITATE. REPEATED PROLONGED CONTAC T (24-48 HRS) MAY IRRITATE
MODERATELY. INHAL:VAPOR OVEREXPOSURE MAY IRRITATE EYES, NOSE &
THROAT. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INGEST:SMALL AMOUNTS TRANSFERRED TO
THE MOUTH BY FINGERS DURING USE, ETC., SHOULD NOT INJURE.
SWALLOWING LARGE AMOUNTS MAY CAUSE DIGESTIVE DISCOMFORT. COMMENT:NO
INJURY FROM DUST SHOULD OCCUR DURING REASONABLE USE. IF USE
CREATES SOME RESPIRABLE PARTICLES, SOME RESPIRATORY SYSTEM INJURY
MAY OCCUR.
Medical Cond Aggravated by Exposure:OVEREXPOSURE TO ANY CHEMICAL MAY
RESULT IN ENHANCEMENT OF PRE-EXISTING ADVERSE MEDICAL CONDITIONS
AND ALLERGIC REACTIONS.

First Aid:INGESTION: CALL MD IMMEDIATELY . EYES: IMMEDIATELY FLUSH WITH
WATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION. SKIN: WIPE
OFF AND FLUSH WITH WATER. GET MEDICAL ATTENTION IF IRRITATION DEVEL
OPS. INHALATION: REMOVE TO FRESH AIR. GET MEDICAL ATTENTION IF ILL
EFFECTS PERSIST.

Flash Point Method:CC
Flash Point:>212F,>100C
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TOXIC FLUORINE GASES FORM. EVACUATE AREA
IN CASE OF OVERHEATING OR FIRE.

Spill Release Procedures:COLLECT & CONTAIN FOR SALVAGE OR DISPOSAL. USE
CHEM WORKER GOGG. WASH @ MEALTIME & END OF SHIFT. REMOVE CONTAMD
CLTHG & SHOES AS SOON AS PRACTICAL & CLEAN THORO BEFORE REUSE. USE
NIOSH/MSHA APPRVD RE SP IF NEEDED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE BELOW 90F/32C. USE REASONABLE
CARE & CAUTION. KEEP CLOSED WHEN NOT IN USE.
Other Precautions:PROD FORMS ACETIC ACID (HOAC) WHEN EXPOS TO
WATER/HUMID AIR. PROVIDE VENT DURING USE TO CONTROL HOAC EXPOS W/IN
10PPM (CURRENT TLV)/USE NIOSH/MSHA APPRVD RESP PROT. THIS MATL MAY
FORM HIGHLY TOX VAP O F TRIFLUOROPROPIONALDEHYDE IF (SUPDAT)

Respiratory Protection:USE NIOSH/MSHA RESPIRATORY PROTECTION UNLESS
LOCAL EXHAUST VENTILATION IS ADEQUATE/AIR SAMPLING DATA SHOW
EXPOSURES ARE W/IN TLV & PEL GUIDELINES. SUITABLE RESP: NIOSH/MSHA
APPROVED ORGANIC VAPOR TYPE .
Ventilation:MECHANICAL & LOCAL EXHAUST ARE RECOMMENDED.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKER GOGGLES.
Other Protective Equipment:REMOVE CONTAMINATED CLOTHING & SHOES AS SOON
AS PRACTICAL & CLEAN THOROUGHLY BEFORE REUSE.
Work Hygienic Practices:WASH @ MEALTIME & @ END OF SHIFT. REMOVE GROSS
AMT OF ANY CHEM FROM SKIN AS SOON AS PRACTICAL, ESP BEFORE
EATING/SMKNG.
Supplemental Safety and Health
OTHER PREC:HEATED IN AIR > 300F/149C. PROVIDE VENT TO CONTROL VAP EXPOS
WHEN HNDLG @ ELEVATED TEMPS. REVIEW OSHA FORMALDEHYDE REGS FOR
DETAILED INFORMATION ON SAFE HNDLG REQUIREMENTS.

HCC:N1
Vapor Density:>1
Spec Gravity:1.41 @ 77F
Solubility in Water:<0.1%
Appearance and Odor:WHITE PASTE, ACETIC ACID-LIKE ODOR.
Percent Volatiles by Volume:<5(WT)

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION.
Stability Condition to Avoid:AVOID EXPOSURE TO AIR OR MOISTURE UNTIL
READY TO USE. CAUSES CURING AND ACETIC ACID VAPORS TO FORM.
Hazardous Decomposition Products:FLUORINE COMPOUNDS, METAL OXIDES,
SILICON DIOXIDE, CARBON DIOXIDE & TRACES OF INCOMPLETLY BURNED
CARBON PRODUCTS.

Waste Disposal Methods:ALL LOCAL, STATE & FEDERAL REGULATIONS
CONCERNING HEALTH & POLLUTION SHOULD BE REVIEWED TO DETERMINE
APPROVED DISPOSAL PROCEDURES. CONTACT MANUFACTURER IF THERE ARE ANY
DISPOSAL QUESTIONS. PROD CONTAI NS NO INGRED SUBJECT TO RELEASE
REPORTING REGS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.