Product ID:JP-4
MSDS Date:05/07/1993
FSC:9130
NIIN:00-273-2380
MSDS Number: BVFXF

SHELL OIL COMPANY

HEALTH, SAFETY AND ENVIRONMENT
HOUSTON, TX 77210
US

Emergency Phone: 713-473-9461/800-424-9300(CHEMTREC)

Info Phone: 713-241-4819/4141/2252 FAX -6511

Cage: 54527

SHELL OIL COMPANY

2463 HOUSTON, TX 77210 US

Telephone: 800-231-6950

Cage: 54527

MINERAL SPIRITS

CAS: 64475-85-0

RTECS: PY8240000

Fraction By Weight: 88-95% %

NAPHTHA,LIGHT

CAS: 64741-46-4

RTECS: QK8000300

Fraction By Weight: 5-12% %

ADDITIVES

Fraction By Weight: < 0.5% %

BENZENE (SARA III)

CAS: 71-43-2

RTECS: CY1400000

Fraction By Weight: < 2.5% %

OSHA PEL SEE 1910.1028

ACGIH TLV: 10 PPM; A2; 9394

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

NAPHTHALENE (SARA III)

CAS: 91-20-3

RTECS: QJ0525000

Fraction By Weight: 0-3% %

OSHA PEL 10 PPM

ACGIH TLV: 10 PPM/15 STEL; 9394

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:MAY BE MILDLY IRRITATING TO THE EYES.
PROLONGED OR REPEATED CONTACT MAY CAUSE DERMATITIS. VAPORS MAY
IRRITATE THE NOSE, THROAT AND UPPER RESPIRATORY TRACT. MAY CAUSE
CNS DEPRESSION. INGESTION MAY CAUS E GI DISTURBANCES. ASPIRATION
HAZARD. MAY CAUSE LIVER AND KIDNEY DAMAGE.
Explanation of Carcinogenicity:CONTAINS B [71-43-2] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, DERMATITIS,
UPPER RESPIRATORY TRACT IRRITATION, NAUSEA, VOMITING, DIARRHEA,
GIDDINESS, HEADACHE, DIZZINESS, UNCONSCIOUSNESS, ASPIRATION
PNEUMONIA, KIDNEY DAMAGE, LIVER DAMAGE.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN, EYE,
KIDNEY/LIVER DISORDERS AND/OR RESPIRATORY DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION. IN HALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL
ATTENTION. IF VOMITING OCCURS, KEEP HEAD BELOW HIPS.

Flash Point:-10 TO 30F
Lower Limits:1.3 %
Upper Limits:8.0 %
Extinguishing Media:WATER FOG, DRY CHEMICAL, CARBON DIOXIDE, FOAM. DO
NOT USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND REIGNITE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR ACCUMULATING
IN LOW AREAS AND TRAVELLING ALONG THE GROUND AWAY FROM THE HANDLING
SITE. DO NOT WELD, HEAT OR DRILL NEAR CONTAINER.

Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. EVACUATE AREA.
WEAR PROPER PERSONAL PROTECTIVE EQUIPMENT. CONTAIN SPILL. STOP LEAK
IF CAN DO SO WITHOUT RISK. ABSORB LIQUID WITH SUITABLE ABSORBENT
MATERIAL. COLLECT FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES. USE EXPLOSION-PROOF VENTILATION.
Other Precautions:DO NOT SIPHON BY MOUTH. LAUNDER CONTAMINATED CLOTHING
BEFORE REUSE. FOR USE AS A FUEL ONLY. DO NOT USE AS A CLEANING
SOLVENT OR FOR OTHER NON-MOTOR FUEL USES. ALL HANDLING EQUIPMENT
MUST BE GROUNDED T O PREVENT SPARKING.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS PER
CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND NIOSH RESPIRATOR
SELECTION.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION TO
MAINTAIN EXPOSURE LEVELS. USE EXPLOSION-PROOF VENTILATION.
Protective Gloves:CHMEICAL RESISTANT
Eye Protection:SAFETY GLASSES OR GOGGLES
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO AVOID
SKIN CONTACT. AN EMERGENCY EYE WASH STATION AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
PROLONGED AND REPEATED BENZENE EXPOSURE MAY CAUSE SERIOUS INJURY TO
BLOOD FORMING ORGANS.

HCC:F1
Boiling Pt:B.P. Text:>100F,>38C
Melt/Freeze Pt:M.P/F.P Text:-72F,-58C
Vapor Pres:14-21 PSI
Vapor Density:3.5
Spec Gravity:0.7796
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT AMBER COLOR, CLEAR AND BRIGHT LIQUID,
HYDROCARBON ODOR
Percent Volatiles by Volume:100 %

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, OPEN FLAME, SPARKS
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
UNIDENTIFIED ORGANIC COMPOUNDS.

Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.