Product ID:3# CUT HITE OR ORANGE BULLS EYE SHELLAC SOLUTION.
MSDS Date:01/08/1987
FSC:8010
NIIN:01-070-4550
MSDS Number: BVQBP

ZINSSER WILLIAM AND CO

39 BELMONT DR
SOMERSET, NJ 08873-1218
US

Emergency Phone: 201-469-8100

Info Phone: 201-469-8100

Cage: 3M602

ZINSSER WILLIAM AND CO

SOMERSET, NJ 08873-1218 US

Cage: 3M602

ETHYL ALCOHOL (ETHANOL)

CAS: 64-17-5

RTECS: KQ6300000

Fraction By Weight: 50-60%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM; 9394

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: <10%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM/500STEL;9394

METHYL ALCOHOL (METHANOL) (SARA III)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: <4%

OSHA PEL S,200PPM

ACGIH TLV: S,200PPM/250STEL; 94

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:HIGH CONCEN OF VAP MAY CAUSE
HEADACHE/DROWSINESS/NAUSEA/DIZZINESS AS WELL AS IRRIT OF EYES/RESP
TRACT. PROLONGED CONTACT W/SKIN MAY CAUSE IRRIT. INGESTION CAN
CAUSE NAUSEA & VOMITING
Explanation of Carcinogenicity:PER MSDS:NONE OF CHEM SUBSTANCES IN
PRODUCT IS LISTED AS POT CARCINOGEN IN NTP OR IARC OR OSHA.
Effects of Overexposure:HEADACHE, DROWSINESS, NAUSEA, DIZZINESS,
EYE/RESP TRACT IRRIT.
Medical Cond Aggravated by Exposure:NONE KNOWN.

First Aid:EYE:IRRIGATE W/COPIOUS AMOUNT OF CLEAN WATER FOR 15MINS.
OBTAIN MED ATTN. SKIN:WASH W/COOL WATER. INHAL:MOVE TO FRESH AIR.
MAINTAIN BREATHING. OBTAIN MED ATTN IMMED. INGEST:CALL PHYSICIAN OR
POISON CO NTROL CENTER IMMED.

Flash Point:54.0F,12.2C
Lower Limits:3.3
Extinguishing Media:ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER
FOG, SAND.
Fire Fighting Procedures:NONE PER MSDS. HOWEVER USE APPROPRIATE SAFETY
EQPMT WHEN CONDITIONS WARRANTS.
Unusual Fire/Explosion Hazard:NONE PER MSDS. HOWEVER PRODUCT VERY
FLAMMABLE.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. PROVIDE
ADEQUATE VENTILATION OR USE RESP PROTECTION IN CONFINED AREAS.
CLEAN AREA W/ABSORBENT MATERIALS, SAND OR RAGS.
Neutralizing Agent:NONE SPECIFIED BY MFG.

Handling and Storage Precautions:STORE IN COOL PLACE AWAY FROM HIGH
HEAT, OPEN FLAMES, SPARKS, OXIDIZING AGENTS. USE ONLY W/ADEQUATE
VENTILATION.
Other Precautions:AVOID PROLONGED BREATHING OF VAPOR OR SPRAY MIST AND
PROLONGED CONTACT W/SKIN. DO NOT TAKE INTERNALLY. KEEP OUT OF
DIRECT SUNLIGHT. KEEP CONTAINER CLOSED. DRUM SHOULD BE GROUNDED AND
BONDED WHEN POURI NG.

Respiratory Protection:NONE REQUIRED IN WEEL VENTILATED AREAS. IN
CONFINED AREAS WHERE HIGH VAPOR CONCEN ARE EXPECTED USE NIOSH/MSHA
APPROVED RES PROTECTION IN ACCORDANCE WITH 29CFR1910.134.
Ventilation:USE EXPLO-PROOF EXHA SYS SUITABLE TO MAINTAIN VAP CONCEN IN
WORPLACE ATM BELOW TLV/PEL'S.VENT EXHA VAP TO NON-EXPL AREA.
Protective Gloves:RECOMMENDED.
Eye Protection:SAFETY GLASSES.
Other Protective Equipment:CLOTHING ADEQUATE TO PROTECT SKIN.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health

HCC:F3
Boiling Pt:B.P. Text:173F,78C
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER.
Appearance and Odor:BEIGE OR ORANGE LIQUID WITH ALCOHOL ODOR.
Percent Volatiles by Volume:77

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE ON INCOMPLETE
COMBUSTIN.

Waste Disposal Methods:DRIED SHELLAC CAN BE DIPSOED OF IN TRASH.
DISPOSE OF SOLUTION IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.