Product ID:SA-1065 SPLICE ADHESIVE
MSDS Date:02/08/1993
FSC:8040
NIIN:00F036303
MSDS Number: BVRLZ

FIRESTONE BUILDING PRODUCTS CO

525 CONGRESSIONAL BLVD
CARMEL, IN 46032-5000
US

Emergency Phone: 615-231-3911

Info Phone: 615-231-3911

Preparer: DEBRA L CRIGGER

Cage: FIRES

FIRESTONE BUILDING PRODUCTS CO

CARMEL, IN 46032-5000 US

Telephone: 615-231-3911

Cage: FIRES

HEXANE, N-HEXANE

CAS: 110-54-3

RTECS: MN9275000

Fraction By Weight: 14%

OSHA PEL 50 PPM

ACGIH TLV: 50 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

ALIPHATIC POLYISOCYANATE, HEXAMETHYLENE DIISOCYANATE

CAS: 28182-81-2

RTECS: NQ9170000

Fraction By Weight: <2%

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 52%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

XYLENE, DIMETHYLBENZENE, XYLOL

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

BUTYL RUBBER, ISOBUTYLENE-ISOPRENE POLYMER *94-3*

CAS: 9010-85-9

Fraction By Weight: >27%

LD50 LC50 Mixture:ORAL/LD50 (RAT): 10 G/KG (SEE SUPP)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE MODERATE IRRITATION.
SKIN: PROLONGED/REPEATED CONTACT MAY CAUSE DERMATITIS. ABSOPTION
MAY CONTRIBUTE TO OVERALL EXPOSURE. INHALATION: MAY CAUSE CNS
DEPRESSION. INGESTION: CAUSES CHEMIC AL PNEUMONITIS IF ASPIRATED
INTO THE LUNGS. (SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DRYING, HEADACHE, DIZZINESS,
MUSCULAR WEAKNESS, FATIGUE, UNCONSCIOUSNESS & NARCOSIS.
Medical Cond Aggravated by Exposure:ASTHMA, BRONCHITIS, EMPHYSEMA,
HYPER-REACTIVITY, SKIN ALLERGIES & ECZEMA.

First Aid:EYES: FLUSH IMMEDIATELY W/GENTLE STREAM OF WATER FOR 15 MINS.
PREFERABLY AT EYEWASH FOUNTAIN. SKIN: CLEAN W/ RUBBING ALCOHOL
FOLLOWED IMMEDIATELY BY WASHING AFFECTED AREA W/SOAP & WATER.
INHALATION: R EMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
INGESTION: DON'T INDUCE VOMITING. ASPIRATION HAZARD. OBTAIN MEDICAL
ATTENTION IN ALL CASES.

Flash Point Method:TCC
Flash Point:0F
Lower Limits:1.2
Upper Limits:7
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:USE WATER TO COOL ADJACENT SURFACES ONLY. WEAR
IMPERMEABLE PROTECTIVE CLOTHING & SELF-CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:HEAT BUILDS UP PRESSURE IN CLOSED
CONTAINERS. COOL W/WATER STREAM. VAPORS ARE >AIR/CAN FLOW ALONG
SURFACES TO INGITION POINTS & FLASH BACK.

Spill Release Procedures:REMOVE IGNITION SOURCES. ABSORB ON INERT
MATERIAL. USE NON-SPARKING TOOLS. PLACE IN SECURE CONTAINERS FOR
DISPOSAL. USE PERSONAL PROTECTIVE EQUIPMENT.

Handling and Storage Precautions:STORE IN COOL DRY AREA AWAY FROM
DIRECT HEAT. USE UNDER WELL VENTILATED CONDITIONS. KEEP CONTAINERS
TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:AVOID BREATHING VAPORS & SKIN/EYE CONTACT. VAPORS ARE
HEAVIER THAN AIR & WILL COLLECT IN LOW/CONFINED AREAS. FLAMMABLE
LIQUID.

Respiratory Protection:WEAR A NIOSH-APPROVED AIR SUPPLY RESPIRATOR IF
WORKPLACE EXPOSURE LIMITS OF PRODUCT/ANY COMPONENTS IS EXCEEDED.
FULL FACE PIECE RESPIRATOR.
Ventilation:LOCAL EXHAUST CAPABLE OF MAINTAING EMISSIONS AT POINT OF
USE BELOW PEL.
Protective Gloves:NITRILE RUBBER
Eye Protection:CHEMICAL GOGGLES
Other Protective Equipment:EYE WASH & SAFETY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
HEALTH HAZARDS CONT'D: INGESTION: MAY CAUSE CNS DEPRESSION. CHRONIC:
MAY CAUSE KIDNEY & SPLEEN DAMAGE. MAY CAUSE IMPAIRMENT OF THE
FUCTIONS OF THE REPRODUCTIVE SYSTEM. (SUPP LD50) HEXAMETHYLENE
DIISOC YANTE.

Boiling Pt:B.P. Text:>151F
Vapor Pres:<125
Vapor Density:3.7
Spec Gravity:0.876
Evaporation Rate & Reference:(ETHER =1): 1.9-9.5
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK VISCOUS LIQUID W/AROMATIC ODOR
Percent Volatiles by Volume:70

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, BASES & AMINES.
Stability Condition to Avoid:HEAT, SPARKS, & OPEN FLAMES.
Hazardous Decomposition Products:NONE

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS REGARDING FLAMMABLE & OXIDIZING AGENTS. UN1133, D001.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.