Product ID:MIL-E-24635A #27038 BLACK L8-009
MSDS Date:05/25/1994
FSC:8010
NIIN:01-344-5320
MSDS Number: BVYLS

CRAWFORD LABS, INC

4165 S EMERALD AVE
CHICAGO, IL 60609
US

Emergency Phone: 312-433-1307

Info Phone: 312-376-7132

Preparer: DAVID SCHMETTERER

Cage: 5V430

CRAWFORD LABORATORIES, INC

CHICAGO, IL 60609 US

Telephone: 312-376-7132

Cage: 5V430

100 SOLVENT (VAPOR PRESSURE 9. MM HG)

CAS: 64742-95-6

Fraction By Weight: 7.4%

OSHA PEL 50 PPM

ACGIH TLV: 50 PPM

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 3.3%

MINERAL SPIRITS/66 (VAPOR PRESSURE 3.4 MM HG)

CAS: 8032-32-4

RTECS: OI6180000

Fraction By Weight: 17%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

MAGNESIUM SILICATE HYDRATE (CONTAINS CRYSTALLINE SILICA AT

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 5.2%

ACGIH TLV: 2 MG/M3

SILICON DIOXIDE (CRYSTALLINE) (MAY BE RELEASED BY SANDING

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 33%

OSHA PEL 0.1 MG/M3

ACGIH TLV: 0.1 MG/M3

Health Hazards Acute and Chronic:OVEREXPOSURE MAY PRODUCE VARIOUS
EFFECTS, INCLUDING: ACUTE TOXICITY (HEADACHE, DIZZINESS, NAUSEA,
AND UNCONSCIOUSNESS). SEVERE EYE IRRITATION (POSSIBLY PERMANENT
DAMAGE). IRRITATED MUCOUS MEMBRANES. V OMITING DUE TO INGESTION.
DEFATTING & DRYING OF SKIN. SENSITIZATION AFTER REPEATED CONTACT.

First Aid:EYE:FLUSH W/LUKEWRM LOW PRESSR H2O 15 MIN,LIFT EYELID.GET MED
AID.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN IF BREATH DIFFICLT.GIVE
ARTIF RESP,IF NO BREATH.GET MED AID.KEEP WARM/COMFRTBL.NEVER GIVE
UNCONS CIOUS LIQ.INGEST:CALL DR IMMED.INDUCE VOMIT ON DR'S
INSTRCTN.IF VOMIT,KEEP HEAD BELOW HIP.NEVER GIVE ANYTHING TO
UNCONSCIOUS.SKIN:FLUSH W/H2O REMOVING CONTAM CLOTH.WASH
W/SOAP&H2O.GET MED AID IF IRRIT

Flash Point Method:SCC
Flash Point:108F,42C
Lower Limits:0.9
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL
Fire Fighting Procedures:WATER MAY BE USED TO COOL EXPOSED CONTAINER, &
TO KEEP FLAMMABLE STRUCTURES WET. DON'T ENTER FIRE AREA WITHOUT
PROTECTION BECAUSE DECOMP PRODUCT MAY BE PRESENT.
Unusual Fire/Explosion Hazard:WATER PRESSURE MAY SPREAD A FLAMMABLE
LIQUID FIRE. SEALED CONTAINERS MAY EXPLODE IF OVERHEATED.

Spill Release Procedures:WARNING-COMBUSTIBLE. ELIMINATE ALL IGNITION
SOURCES. HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING.
WEAR PROTECTIVE CLOTHING (SEE CONTROL MEASURES). SOAK UP WITH
ABSORBENT & PLACE IN NON-LEA KING CONTAINERS. SEAL TIGHTLY FOR
PROPER DISPOSAL.

Handling and Storage Precautions:FLAMMABLE. KNOW DOT REGS BEFORE
TRANSPORTING.WARNING:HOT ORGANIC CHEMICAL VAPOR OR MIST SUSCEPTIBLE
TO SUDDEN SPONTANEOUS COMBUSTION WHEN MIXED W/AIR.
Other Precautions:IGNIT MAY OCCUR AT TEMP BELOW AUTOIGNIT/IGNIT
TEMPS.IGNIT TEMPS DECREASE W/INCREASING VAPOR VOLUME & VAPOR/AIR
CONTACT TIME & INFLUENCED BY PRESSR CHANGE.IGNIT MAY OCCUR AT
ELEVATED TEMP,ESPECIALLY IN VACUUM IF SUDDEN INGRESS AIR OR *

Respiratory Protection:USE NIOSH APPROVED ORGANIC VAPOR RESPIRATORS
WHERE VENTILATION IS INADEQUATE.
Ventilation:MUST PROVIDE ADEQUATE VENTILATION.
Protective Gloves:USE RUBBER GLOVES.
Eye Protection:WEAR APPROVED SAFETY GOGGLES
Other Protective Equipment:HAVE EYE BATH AND SAFETY SHOWER AVAILABLE.
Work Hygienic Practices:DO NOT REUSE CONTAMINATED CLOTHING OR SHOES.
Supplemental Safety and Health
* OTHER PRECAUTIONS CONT'D: OUTSIDE PROCESS EQUIPMENT OPERATING UNDER
ELEVATED PRESSURE IF SUDDEN ESCAPE OF VAPOR OR MIST TO THE
ATMOSPHERE OCCURS. ANY PROPOSED USE SHOULD BE THOROUGHLY EVALUATED
TO A SSURE THAT SAFE OPERATING CONDITIONS ARE ESTABLISHED AND
MAINTAINED.

HCC:F4
Boiling Pt:B.P. Text:308 TO 396F
Vapor Density:> AIR
Spec Gravity:1.29
Viscosity:90 KU
Evaporation Rate & Reference:0.11 X N-BU AC
Solubility in Water:SLIGHT
Appearance and Odor:BLACK / SOLVENT ODOR
Percent Volatiles by Volume:40.3
Corrosion Rate:NOT CORR

Stability Indicator/Materials to Avoid:YES
MAY BE INCOMPATIBLE WITH STRONG OXIDIZING AGENTS AND STRONG ALKALIES.
Stability Condition to Avoid:AVOID HEAT, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:INCOMPLETE COMBUSTION FOR PRODUCTS
LIKE THIS MAY GENERATE HIGHLY POISONOUS CARBON MONOXIDE AND OTHER
TOXIC GASES.

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH CURRENT
LOCAL, STATE, AND FEDERAL REGULATIONS. CONTACT AN APPROVED DISPOSAL
FACILITY. EPA HAZARDOUS WASTE CODE: D001, IGNITABLE. DISPOSAL
METHOD: FUEL CONSUMPTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.