Product ID:F-111 T1 CL2 26307 MIL-E-15090 ORGANIC COATING F-06P13
MSDS Date:08/17/1993
FSC:8010
NIIN:00-225-4650
MSDS Number: BVZDR

SEAGRAVE COATINGS CORP OF VA

4030 SEAGUARD AVENUE
PORTSMOUTH, VA 23701
US

Emergency Phone: 804-488-4411/800-424-9300 CHERMTREC

Info Phone: 804-488-4411

Cage: 60163

SHERWIN-WILLIAMS, SEAGUARD

PORTSMOUTH, VA 23704 US

Telephone: 757-397-2223

Cage: 60163

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 15% %

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9394

ZINC OXIDE

CAS: 1314-13-2

RTECS: ZH4810000

Fraction By Weight: 10%K

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9394

CALCIUM CARBONATE (MARBLE) (LIMESTONE)

CAS: 1317-65-3

RTECS: EV9580000

Fraction By Weight: 25%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9394

MAGNESIUM SILICATE (MN-500)

CAS: 14807-96-6

RTECS: MW2700000

Fraction By Weight: 5%

OSHA PEL 0.2 FIBERS/CC

ACGIH TLV: 0.2 FIBER/CC,A1;9394

STODDARD SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 30%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9394

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION- HIGH VAPOR CONCENTRATIONS
MAY PRODUCE NARCOSIS. REPEATED AND PROLONGED OVEREXPOSURE TO
SOLVENTS COULD CAUSE PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
SKIN- LIQUID MAY CAUSE MINOR IRRITAT ION. EYES- DEFINITE
IRRITATION.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES: FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE LIFTING
EYELIDS. SKIN: FLUSH WITH WATER. REMOVE CONTAMINATED CLOTHING.
INHALATION: REMOVE VICTIM TO FRESH AIR. GIVE OXYGEN OR ARTIFICIAL
RESPIRATIO N AS REQUIRED. GET MEDICAL ATTENTION. INGESTION- SEEK
MEDICAL ATTENTION.

Flash Point Method:SCC
Flash Point:100F,38C
Lower Limits:2.3
Upper Limits:14.4
Extinguishing Media:DRY CHEMICAL, FOAM, WATER FOG, CARBON DIOXIDE.
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACE W/O
PROTECTIVE EQUIPMENT, INCLUDING NIOSH/MSHA APPROVED GAS MASK. COOL
CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. VAPORS
MAY MIGRATE TO IGNITION SOURCE AND CAUSE FLASH FIRE. ISOLATE FROM
HEAT, SPARKS, ELECTRICAL EQUIPMENT, ETC.

Spill Release Procedures:ABSORB WITH INERT MATERIAL AND DISPOSE.

Handling and Storage Precautions:STORE IN A COOL, DRY WELL-VENTILATED
SPACE, SEPARATE FROM ACIDS, ALKALIS AND OXIDIZING AGENTS. PROTECT
FROM PHYSICAL DAMAGE. AVOID HIGH TEMPERATURES.
Other Precautions:GROUND CONTAINERS WHILE POURING. EMPTY CONTAINERS MAY
RETAIN HAZARDOUS PROPERTIES AND CAN BE DANGEROUS.

Respiratory Protection:WEAR A NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE
RESPIRATOR WITH FULL FACEPIECE AND ORGANIC VAPOR CARTRIDGES IN
COMBINATION WITH A HIGH-EFFICIENCY PARTICULATE FILTER.
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION IN SUFFICIENT VOLUME AND
PATTERN SO AS TO MAINTAIN EXPOSURE BELOW TLV'S.
Protective Gloves:CHEMICAL RESISTANT PLASTIC OR RUBBER
Eye Protection:CHEMICAL GOGGLES WITH SIDE SHIELDS
Other Protective Equipment:AS REQUIRED TO AVOID WETTING CLOTHING. USE
PROTECTIVE CREAMS FOR SKIN. EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING THIS
MATERIAL.
Supplemental Safety and Health
NONE

HCC:F4
Boiling Pt:B.P. Text:147-397F
Vapor Density:> AIR
Spec Gravity:11.2 LB/GL
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:LIQUID WITH SOLVENT ODOR.
Percent Volatiles by Volume:29.1

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS OR OPEN FLAMES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
IN ACCORDANCE WITH LOCAL, COUNTY, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.