Product ID:TURCO 6759
MSDS Date:11/19/1993
FSC:6850
NIIN:00N055757
MSDS Number: BWBST

TURCO PRODUCTS INC

7320 BOLSA AVE
WESTMINSTER, CA 92684
US

Emergency Phone: 202-483-7616

Info Phone: 714-890-3600

Preparer: JOHN F. GRAINGER

Cage: 61102

TURCO PRODUCTS, INC. DIVISON OF ELF ATOCHEM NORTH AMERICA

PHILADELPHIA, PA 19103-3222 US

Telephone: 215-419-7890

Cage: 61102

ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (SARA III)

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 20%

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM;200 PPM STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-PENTANONE, 4-METHYL-; (METHYL ISOBUTYL KETONE) (SARA III)

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 40%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM;75 PPM STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ISOPROPYL ALCOHOL; (ISOPROPANOL) (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 10%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM;500 PPM STEL

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 30%

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

833 G/L

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

DOT-APPRVD DRUMS FOR DISP. WASH AREA W/WATER.

RTECS: 9999999ZZ

KEEP CONCENTRATE AND WASH WATER FROM ENTERING SEWERS

RTECS: 9999999ZZ

IS & EVAPS AS IT IS USED. WIPE CLOTHS

RTECS: 9999999ZZ

MINIMIZE POSSIBILITY OF SPONTANEOUS COMBUSTION.

RTECS: 9999999ZZ

DOES NOT APPLY. REPAIR & MAINTENANCE OF CONTAMD

RTECS: 9999999ZZ

SPURTING. CLEAN EXTERIOR & INTERIOR BY FLUSHING

RTECS: 9999999ZZ

EYES, SKIN AND INHALATION.

RTECS: 9999999ZZ

MASK W/AN ORG VAP CARTRIDGE/CANISTER MAY BE

RTECS: 9999999ZZ

OXYGEN DEFICIENCY EXISTS, SUCH AS PARTLY

RTECS: 9999999ZZ

FORMAL TRAINING AND SCREENING PROGRAM MUST BE

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:CONT W/EYES MAY CAUSE MOD TO SEV
IRRIT. SKIN: CONT W/SKIN MAY CAUSE MOD TO SEV IRRIT, DRYING, DEFAT,
READILY ABSORBED THRU SKIN IN TOX AMTS. INHAL: VAPS: MOD IRRIT,
DIZZ, HDCH, POSS NARC. MIST: S EV RESP IRRIT, NAUS, POSS LUNG DMG.
INGEST: MOD TO SEV IRRIT OF GI TRACT, NAUS. PRLNGD/RPTD OVEREXP TO
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: AROMATIC HYDROCARBONS MAY CAUSE
KIDNEY & LIVER DMG. RPTD OVEREXP MAY AGGRAVATE ANY PREEXISTING
DYSFUNCTION OF THESE SYS. OVEREXP MAY LEAD TO CNS DEPRESS. TOLUENE
APPEARS ON NAVY LISTING OF O CCUP CHEM REPROD HAZS. SEEK
CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ
LIST INFO & SAFE (SUPDAT)
Medical Cond Aggravated by Exposure:PROLONGED OR REPEATED OVEREXPOSURE
TO AROMATIC HYDROCARBONS MAY CAUSE KIDNEY AND LIVER DAMAGE.
REPEATED OVEREXPOSURE MAY AGGRAVATE ANY PREEXISTING DYSFUNCTION OF
THESE SYMPTOMS.

First Aid:EYES: FLUSH W/LRG VOLS OF WATER FOR AT LST 15 MINS. IF IRRIT
PERSISTS, OBTAIN MED ATTN. SKIN: FLUSH AFFECTED AREA W/LRG VOLS OF
WATER. CONTINUE FLUSHING AT LST 15 MINS. IF IRRIT IS
EVIDENT/BLISTERING OCCURS, OBTAIN MED ATTN. INHAL: REMOVE TO FRESH
AIR. IF BRTHG IS DFCLT, ADMIN OXYGEN. IF BRTHG HAS STOPPED, APPLY
ARTF RESP. OBTAIN MED ATTN. INGEST: DO NOT INDUCE VOMIT EXCEPT ON
ADVICE OF (SUPDAT)

Flash Point Method:TCC
Flash Point:51F,10.6C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS FROM PRODUCT ARE HEAVIER THAN AIR
AND MAY TRAVEL ALONG GROUND TO BE IGNITED AT POINT REMOTE FROM
MATERIAL HANDLING AREA.

Spill Release Procedures:CONC: CONTAIN SPILLAGE. STOP LEAK AT SOURCE IF
THIS CAN BE DONE SAFELY. VENT AREA. NONESSENTIAL PERS SHOULD LEAVE
AREA UNTIL CLEANUP IS COMPLETED. PUMP LIQ INTO DOT-APPRVD DRUMS FOR
DISP. ABSORB REMAI NING LIQ ONTO INERT ABSORB & PLACE IN (ING 6)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN DRY PROTECTED AREA AWAY FROM
STRONG OXIDIZING AGENTS, STRONG ACIDS AND STRONG ALKALIES.
Other Precautions:METAL CNTNRS SHOULD BE FITTED W/BONDED GROUND WIRE
WHEN MATL IS TRANSFERRED. EMPTY CNTNRS MAY CONTAIN FLAMM VAPS IN
DANGEROUS AMTS.CONTAMD WIPE CLOTHS SHOULD BE COLLECTED IN COVERED
METAL CNTNRS TO MI N POSS OF SPONT COMBUST. MIXING:(ING 10)

Respiratory Protection:IF TLV IS EXCEEDED, NIOSH/MSHA APPRVD SCBA, POS
PRESS HOSE MASK/AN AIR LINE MASK IS ADVISED. THESE SHOULD HAVE FULL
FACE PIECE & BE OPER IN POS PRESS MODE. FOR LIMITED EXPOS TIME, IN
AREAS OF GOOD VEN T, NIOSH/MSHA APPRVD FULL FACE (ING 13)
Ventilation:MAINTAIN SUFFICIENT MECHANICAL VENTILATION TO KEEP
CONCENTRATION BELOW TLV.
Protective Gloves:NEOPRENE, VITON GLOVES.
Eye Protection:FACE SHIELD OR GOGGLES.
Other Protective Equipment:BOOT AND APRON MADE OF SOLVENT RESISTANT
MATERIAL (E.G. NEOPRENE, VITON, ETC.). PROTECTIVE SUIT NOT NORMALLY
REQUIRED.
Work Hygienic Practices:WASH HANDS & FACE W/SOAP & WATER BEFORE
SMOKING/EATING. IMMED REMOVE ALL CONTAMD CLTHG. LAUNDER SEPARATELY
BEFORE REUSE.
Supplemental Safety and Health
EFTS OF OVEREXP: HNDLG & EXPOS INFO .FIRST AID PROC: COMPETENT MED
PERS. IF VOMIT OCCURS SPONT, KEEP HEAD BELOW HIP LEV TO REDUCE POSS
OF ASPIR PNEUM. IF VICTIM IS CONSCIOUS, DILUTE BY GIVING LR G VOLS
OF MILK/WATER. OBTAIN IMMED MED ATTN. NEVER ATTEMPT TO INDUCE
VOMIT/GIVE ANYTHING BY MOUTH TO AN UNCON PERSON.

Boiling Pt:B.P. Text:180F,82C
Vapor Pres:19
Vapor Density:>1
Spec Gravity:0.83
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:SLIGHT
Appearance and Odor:WATER WHITE LIQUID, FRUITY ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG ALKALIES, STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON MONOXIDE, DIOXIDE AND OTHER TOXIC VOLATILE ORGANIC
COMPOUNDS.

Waste Disposal Methods:(1)TRANSFER TO RECLAIMING CENTER FOR
RECYCLING/REUSE, IF POSS. (2)TRANSFER TO LICENSED HAZ WASTE
TREATMENT/DISP SITE FOR DISPOSITION UNDER APPLIC LOC, ST, FED &
REGIONAL REGS AS HAZ WASTE. SPENT SOLN & RINSES: NOT APPLICABLE.
PROD IS USED AS (ING 8)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.