Product ID:CATALYST,24-002,Y-415-12 A,PART B
MSDS Date:04/12/1988
FSC:8040
NIIN:00-914-0720
Kit Part:Y
MSDS Number: BWDZJ

NU-BRITE CHEMICAL CO INC, STERLING GROUP

NINE OHIO RIVER BLVD
SEWICKLEY, PA 15143
US

Emergency Phone: 412-766-7600/800-424-9300(CHEMTREC)

Info Phone: 412-766-7600

Preparer: MARK DUBOIS

Cage: 78580

NU-BRITE CHEMICAL CO INC, STERLING GROUP

SEWICKLEY, PA 15143-2199 US

Telephone: CHEMTREC 800-424-9300

Cage: 78580

DIETHYLENETRIAMINE

CAS: 111-40-0

RTECS: IE1225000

Fraction By Weight: 20 - 30%

OSHA PEL 1 PPM

ACGIH TLV: S, 1 PPM; 9495

POLYETHYLENE POLYAMINE ADDUCT

Fraction By Weight: 20 - 30%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- CORROSIVE TO BODY TISSUES. MAY CAUSE ALLERGIC
RESPIRATORY RREACTION. HARMFUL IF SWALLOWED/INHALED/ABSORBED
THROUGH SKIN. SKIN CONTACT CAN CAUSE SEVERE IRRITATION, BURNS. MAY
CAUSE EYEDAMAGE. INGESTION MAY DAMAGE THROAT. CHRONIC- MAY CAUSE
LIVER & KIDNEY DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:HEADACHES, NAUSEA, DIZZINESS, RESPIRATORY
IRRITATION & SENSITIZATION, SEVERE SKIN IRRITATION, DERMATITIS,
CORNEAL BURNS, EYE DAMAGE, THROAT AND ESOPHAGUS DAMAGE
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED LIVER, KIDNEY OR RESPIRATORY
FUNCTION MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.

First Aid:GET MEDICAL ATTENTION AT ONCE. INHALED:REMOVE TO FRESH AIR.
PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15 MINUTES,
HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO NOT
INDUCE VO MITING. NEVER GIVE ANYTIHING BY MOUTH TOAN UNCONSCIOUS
PERSON.

Flash Point Method:SCC
Flash Point:>200F,>93C
Extinguishing Media:WATER FOG, CARBON DIOXIDE, SAND, FOAM/DRY CHEMICAL.
WATER SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING SHOULD BE WORN IN FIGHTING FIRES INVOLVING
CHEMICALS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINER MAY EXPLODE.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN SPILL. PICK UP SPILL WITH
NON-FLAMMABLE ABSORBENT SUCH AS SAND, EARTH/USE PUMP (EXPLOSION
PROOF). GROUND ALL HANDLING EQUIPMENTS. PREVENT LIQUID FROM
ENTERINGSEWERS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
SOURCES OF IGNITION & INCOMPATIBLE MATERIALS. KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:AVOID BREATHING VAPORS. DO NOT GET IN EYES, ON SKIN
OR ON CLOTHING. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
DRINKING. REMOVE CONTAMINATED CLOTHING PROMPTLY. LAUNDER BEFORE
REUSE.

Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, WEAR A
NIOSH-APPROVED MIST/VAPOR RESPIRATOR. WEAR SUPPLIED AIR RESPIRATOR
FOR CLEANING LARGE SPILLS OR UPO N ENTRY INTO TANK.
Ventilation:MECHANICAL (GENERAL) IS RECOMMENDED. LOCAL EXHAUST MAY BE
NEEDED.
Protective Gloves:RUBBER OR PLASTIC REQUIRED
Eye Protection:CHEMICAL TYPE GOGGLES/FACE SHIELD
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
KEY1:B2. THIS PRODUCT IS A KIT CONSISTING OF TWO PARTS. PART A WITH PNI
A AND PART B WITH PNI B, SAME NSN.

HCC:B2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:>100.C, 212.F
Vapor Pres:0.1 @ 68F
Spec Gravity:1.0
Solubility in Water:SLIGHTLY SOLUBLE
Appearance and Odor:AMBER LIQUID, AMINE ODOR
Percent Volatiles by Volume:0

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, ISOCYANATES, BASES AND
EPOXY RESIN UNDER UNCONTROLLED CONDITIONS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN MAY BE FORMED.

Waste Disposal Methods:ALL LOCAL, STATE AND FEDERAL REGULATIONS
CONCERNING HEALTH AND POLLUTION BE REVIEWED TO DETERMINE APPROVED
DISPOSAL PROCEDURES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.