BWPCL - TURCO 6825
- MSDS: BWPCL
- Manufacturer: TURCO PRODUCTS INC
- Product Name: TURCO 6825
- National Stock Number: 6850-00N057172
Product Identification
Product ID:TURCO 6825
MSDS Date:03/24/1993
FSC:6850
NIIN:00N057172
MSDS Number: BWPCL
Responsible Party
WESTMINISTER, CA 92684
US
Emergency Phone: 202-483-7616
Info Phone: 714-890-3600
Cage: 61102
Contractor
Telephone: 215-419-7890
Cage: 61102
Ingredients
DISTILLATES (PETROLEUM), HYDROTREATED MIDDLE; (HYDROTREATED
CAS: 64742-46-7
RTECS: JN9379645
OSHA PEL N/K
ACGIH TLV: N/K
820 G/L (CALCULATED FROM NOMINAL
RTECS: 9999999VO
OSHA PEL N/K
ACGIH TLV: N/K
APPRVD DRUMS FOR DISP. WASH AREA W/WATER. COLLECT
RTECS: 9999999ZZ
CONCENTRATE & WASH WATER FROM ENTERING SEWERS OR
RTECS: 9999999ZZ
SPENT SOLN & RINSES CAN BE NEUTRALIZED, AND
RTECS: 9999999ZZ
RESIDUAL ORG MATTER MAY BE REMOVED BY OXIDATION
RTECS: 9999999ZZ
TO SEWER IF LOCAL, STATE AND FEDERAL REGULATIONS
RTECS: 9999999ZZ
W/ORG VAP CARTRIDE/CANISTER MAY BE USED. THESE
RTECS: 9999999ZZ
DEFICIENCY EXISTS, SUCH AS PARTLY ENCLOSED/LOW LYING
RTECS: 9999999ZZ
TRAINING & SCREENING PROGRAM MUST BE INITIATED. SEE
RTECS: 9999999ZZ
BEFORE REUSE. DISCARD SHOES THAT BECOME
RTECS: 9999999ZZ
Hazards
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:MAY CAUSE MODERATE TO
SEVERE IRRITATION. SKIN:MAY CAUSE MODERATE TO SEVERE IRRITATION,
DRYING, DEFATTING, INHALATION:VAPORS:MODERATE IRRITATION,
DIZZINESS, HEADACHE, MISTS:SEVERE RESPIRATOR Y IRRITATION, NAUSEA.
INGESTION:MODERATE TO SEVERE IRRITATION OF GASTROINTESTINAL TRACT,
NAUSEA. (EFTS OF OVEREXP).
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NO KNOWN CHRONIC EFFECTS THAT
DIFFER FROM ACUTE EFFECTS.
First Aid
First Aid:EYES:FLUSH W/LG VOLUMES OF WATER FOR @ LEAST 15 MINS. IF
IRRIT PERSISTS, OBTAIN MED ATTN. SKIN:FLUSH AFFECTED AREA W/LG
VOLUMES OF WATER. WASH W/SOAP & WATER. RINSE THORO. IF IRRIT IS
EVIDENT/BLISTERI NG OCCURS, OBTAIN MED ATTN. INHAL:REMOVE TO FRESH
AIR. IF BRTHG IS DFCLT, ADMIN OXYG. IF BRTHG HAS STOPPED, APPLY
ARTF RESP. OBTAIN MED ATTN. INGEST:DO NOT INDUCE VOMIT EXCEPT ON
ADVICE OF (SUPDAT)
Fire Fighting
Flash Point Method:TCC
Flash Point:225F,107C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
Accidental Release
Spill Release Procedures:CONCENTRATE. CONTAIN SPILLAGE. STOP LEAK @
SOURCE IF THIS CAN BE DONE SAFELY. VENTILATE AREA. NONESSENTIAL
PERS SHOULD LEAVE AREA UNTIL CLEANUP IS COMPLETE. PUMP LIQ INTO
DOT-APPRVD DRUMS FOR DISP. AB SORB REMAINING LIQ ONTO INERT ABSORB
& (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
Handling
Handling and Storage Precautions:STORE IN DRY PROTECTED AREA AWAY FROM
STRONG OXIDIZING AGENTS. MIXING:USE CARE TO AVOID SPLASHING. USE
APPROPRIATE PROTECTIVE EQUIPMENT.
Other Precautions:REPAIR & MAINTENANCE OF CONTAMD EQUIP:RELIEVE ANY
PRESS. COVER OPENINGS TO AVOID SPURTING. CLEAN EXTERIOR & INTERIOR
BY FLUSHING W/WATER. COLLECT FLUSHING FOR DISP. USE PROT EQUIP FOR
EYES, SKIN AND I NHALATION.
Exposure Controls
Respiratory Protection:IF TLV IS EXCEEDED, NIOSH/MSHA APPRVD SCBA, POS
PRESS HOSE MASK/AIR LINE MASK IS ADVISED. THESE SHOULD HAVE FULL
FACE PIECE & BE OPERATED IN POS PRESS MODE. FOR LIMITED EXPOS TIME,
IN AREAS OF GOOD VE NTL, NIOSH/MSHA FULL FACE MASK (ING 8)
Ventilation:MAINTAIN SUFFICIENT MECHANICAL VENTL TO KEEP CONCENTRATION
BELOW TLV.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:BOOTS & APRON MADE OF SOLV RESISTANT
MATERIAL (E.G. NEOPRENE, VITON, ETC.). ANSI APPROVED EYEWASH
FNTN/DELUGE SHWR
Work Hygienic Practices:WASH HANDS & FACE W/SOP & WATER BEFORE SMOKING/
EATING. IMMED REMOVE ALL CONTAMD CLTHG. LAUNDER SEPARATELY (ING
11)
Supplemental Safety and Health
FIRST AID PROC:COMPENTENT MED PERS. IF VOMIT OCCURS SPONT, KEEP HEAD
BELOW HIP LEV TO REDUCE POSSIBILITY OF ASPIR PNEUM. IF VICTIM IS
CONSCIOUS, DILUTE BY GIVING LG VOLUMES OF MILK/WATER. OBTAIN IMMED
MED ATTN. NEVER ATTEMPT TO INDUCE VOMIT/GIVE ANYTHING BY MOUTH TO
UNCON PERSON. SPILL RELEASE:PLACE IN DOT- (ING 3)
Chemical Properties
Boiling Pt:B.P. Text:485F,252C
Vapor Pres:0.2 HG
Vapor Density:6.2
Spec Gravity:0.82
Evaporation Rate & Reference:<1 (BUAC =1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, WATER-WHITE, MOBILE LIQUID
Percent Volatiles by Volume:100
Stability
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:CONTACT WITH STRONG OXIDIZING MATERIALS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON MONOXIDE, DIOXIDE AND OTHER TOXIC VOLATILE ORGANIC
COMPOUNDS.
Disposal
Waste Disposal Methods:CONCENTRATE:(1) TRANSFER TO RECLAIMING CENTER
FOR RECYCLING/REUSE, IF POSS. (2) TRANSFER TO LICENSED WASTE
TREATMENT/DISP SITE FOR DISPOSITION UNDER APPLIC LOCAL, STATE &
REGIONAL REGS. SPENT SOLN & R INSES:DISPOSE PER (1) OR (2) ABOVE,
OR (ING 5)
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.