Product ID:N-5352 GRAY SI ALKYD 26173
MSDS Date:10/13/1994
FSC:8010
NIIN:01-356-8767
MSDS Number: BWRYM

NILES CHEMICAL PAINT CO

225 FORT STREET
NILES, MI 49120
US

Emergency Phone: 219-236-5856

Info Phone: 616-683-3377

Preparer: MIKE LICHATOWICH

Cage: 02388

NILES CHEMICAL PAINT

307 NILES, MI 49120 US

Telephone: 616-683-3377/219-236-5856

Cage: 02388

HIGH SOLIDS SILICONE (VAPOR PRESSURE 1.5 MM HG @ 20C)

Fraction By Weight: 28%

MINERAL SPIRITS (VAPOR PRESSURE 0.0 MM HG @ 20C)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 16%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

#100 SOLVENT (VAPOR PRESSURE 4.4 MM HG @ 20C)

CAS: 64742-95-6

Fraction By Weight: 7%

ACGIH TLV: 100 PPM

ZINC OXIDE (SARA 313) (CERCLA)

CAS: 1314-13-2

RTECS: ZH4810000

Fraction By Weight: 3%

COBALT COMPOUNDS (AS CO) (SARA 313)

CAS: 7440-48-4

RTECS: GF8750000

Fraction By Weight: <1%

OSHA PEL 0.1 MG/M3

ACGIH TLV: 2 MG/M3

PROPRIETARY INGREDIENTS (MFR STATES UNIDENTIFIED

Fraction By Weight: BALANCE

2.82 LBS/GAL

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE:SEVERE
IRRITATION.TEARING,REDNESS,BLURRED VISION.
SKIN:REDNESS,IRRITATION.DEFATTING LEADING TO DERMATITIS.
INHAL:NASAL & RESPIRATORY IRRITATION,CNS DEPRESSION
(DIZZINESS,DROWSINESS,WEAKNESS,FATIGU E,CONFUSION)
NAUSEA,VERTIGO,UNCONSCIOUSNESS,ASPHYXIATION. INGEST:GI
IRRITATION,ABDOMINAL PAIN,NAUSEA,VOMITING,DIARRHEA.
Effects of Overexposure:CHRONIC: LIVER, KIDNEY, NS. PROLONGED EXPOSURE
TO SOLVENTS MAY CAUSE CHRONIC HEALTH EFFECTS. TARGET ORGANS: LIVER,
KIDNEYS, NS, SKIN, EYES, RESPIRATORY SYSTEM, CNS.
Medical Cond Aggravated by Exposure:NONE KNOWN

First Aid:INHAL:MOVE TO FRESH AIR IMMED.IF BREATH STOPPED,GIVE ARTIF
RESP.GET MED AID ASAP. SKIN:IMMED FLUSH W/PLENTY OF WATER.IF MAT'L
PENETRATES CLOTH,IMMED REMOVE CONTAM CLOTH & FLUSH SKIN W/WATER.GET
MED AI D.WASH CLOTH & DECONTAM SHOES BEFORE REUSE. EYE:IMMED FLUSH
W/WATER 15 MIN,LIFT EYELIDS.GET MED AID IMMED. INGEST:DRINK 1-2
GLASSES WATER.DON'T INDUCE VOMITING.SEE DR/POISON CTR IMMED. TREAT
SYMPTOMS.

Flash Point Method:TCC
Flash Point:107F,42C
Lower Limits:0.8
Upper Limits:0.0
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR SCBA W/FULL FACPIECE (POSITIVE PRESSURE
MODE) & FULL PROTECT CLOTH. USE WATER TO COOL CLOSED CNTNR TO
PREVENT PRESSURE BLDUP/AUTO IGNIT/EXPLOSION W/HEAT.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. VAPOR HEAVIER THAN AIR,
TRAVEL ON GRND TO IGNIT SOURCE. NO HEAT/IGNIT. CLSD CNTNRS MAY
EXPLODE W/HEAT. APP TO HOT SRFC REQUIRE SPCL PRECAUTIONS

Spill Release Procedures:ELIMINATE IGNITION SOURCES. MINIMIZE BREATHING
VAPORS. AVOID SKIN CONTACT. SMALL: ABSORB W/INERT MAT'L
(CLAY,SOIL,COMMERCL ABSORBNT) SHOVEL RECLAIMED LIQ & ABSORBENT INTO
RECOVERY DRUMS. LRG: DIKE. RE CLAIM INTO RECOVERY/SALVAGE DRUMS OR
TANK TRUCK.

Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR FIRE OR OPEN FLAME. KEEP CONTAINER CLOSED WHEN NOT IN
USE. AVOID ROUGH HANDLING
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD OR FLAME CUT ON EMPTY DRUMS. SHOCK FROM DROPPING
MAY SPLIT CONTAINER. CONTACT LENSES SHOULD NOT BE WORN WHEN WORKING
WITH THIS MATE RIAL.

Respiratory Protection:WEAR APPROPRIATE (TYPE TC-23C-75) PROPERLY
FITTED HALF-MASK OR FULL FACEPIECE RESPIRATOR (NIOSH/MSHA) DURING &
AFTER APPLICATION UNLESS AIR MONITORING DEMONSTRATES VAPOR/MIST
LEVELS BELOW APPLICABLE L IMITS. FOLLOW RESPRTR MFR USE DIRECTIONS
Ventilation:KEEP AIR CONCEN BELOW PEL/TLV.REMOVE DECOMP FORMED DURING
WELD/FLAME CUT COATED SURFACES.VENT VAPOR FROM BAKING FINISHES
Protective Gloves:CHEM RESISTANT (NITRILE/VITON) GLOVES
Eye Protection:CHEM GOGGLES,SAFETY GLASSES,FACE SHIELDS
Other Protective Equipment:EMPLOYEES SHOULD WASH PROMPTLY WHEN SKIN
BECOMES CONTAMINATED. REMOVE CLOTHING THAT BECOMES WET (TO AVOID
FLAMMABILITY).
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE. WASH
HANDS BEFORE EATING, SMOKING, OR USING RESTROOM.
Supplemental Safety and Health

Boiling Pt:B.P. Text:285 TO 398F
Vapor Density:>AIR
Spec Gravity:1.375
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Percent Volatiles by Volume:42.00
Corrosion Rate:MINIMAL

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ACIDS
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND/OR
CARBON DIOXIDE.
Conditions to Avoid Polymerization:HIGH TEMPERATURES

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE, & FEDERAL REGULATIONS. EPA HAZARDOUS WASTE CODE: D001
(IGNITABLE).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.