Product ID:CHEMICAL VULCANIZING FLUID 21/22/23,SUPERSOLN 604/608/610
MSDS Date:10/11/1994
FSC:2640
NIIN:00-405-0222
MSDS Number: BWSRW

TRUFLEX RUBBER PRODUCTS CO

1667 N MAIN STREET
LOS ANGELES, CA 90012-1997
US

Emergency Phone: 213-224-6300/800-424-9300(CHEMTREC)

Info Phone: 213-224-6300

Preparer: DERNARD BADOR

Cage: 28954

TRUFLEX/PANG RUBBER PRODUCTS CO

LOS ANGELES, CA 90012 US

Telephone: 213-224-6300

Cage: 28954

TRICHLOROETHYLENE (SARA 313) (CERCLA)

CAS: 79-01-6

RTECS: KX4550000

Fraction By Weight: 93 - 97%

OSHA PEL 100 PPM; Z-2

ACGIH TLV: 50 PPM/100STEL,A5;95

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

NATURAL RUBBER

Fraction By Weight: 2 - 4%

RESIN, SYNTHETIC

Fraction By Weight: <1%

AGENTS, FILLERS AND CURING

Fraction By Weight: <1%

LD50 LC50 Mixture:LD50 (ORAL, RAT) IS 4920 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, CNS,
RESPIRATORY TRACT. ACUTE- MAY CAUSE EYE PAIN. SKIN ABSORPTION,
DRYING, IRRITATION CAN OCCUR. INHALATION/INGESTION MAY CAUSE CNS
DEPRESSION WITH ANESTHETIC EFFECTS. HIGHE R EXPOSURES MAY CAUSE
IRREGULAR HEART BEATS. MAY BE FATAL. ASPIRATION HAZARD. CHRONIC-
MAY CAUSE LIVER DAMAGE, DRY SKIN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, FLAKE SKIN, NUMBNESS OF FINGERS.
DEATH, UNCONSCIOUSNESS, MINIMAL ANESTHETIC EFFECTS, DIZZINESS,
DRUNKENNESS,CENTRAL NERVOUS SYSTEM EFFECTS, LIVER/KIDNEY EFFECTS IN
LAB ANIMALS, PAIN
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES OF THE EYE, SKIN, RESPIRATORY TRACT, LIVER, KIDNEYS, CNS
MAY HAVE INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE
EXPOSURES.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT IN DUCE VOMITING. IF CONSCIOUS, RINSE MOUTH WITH WATER. SEEK
IMMEDIATE MEDICAL ATTENTION. IF SPONTANEOUS VOMITING OCCURS,
MONITOR FOR BREATHING DIFFICULTY.

Flash Point Method:TCC
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:788F
Lower Limits:8.0% @ 212F
Upper Limits:44.8% @ 212F
Extinguishing Media:WATER FOG, CARBON DIOXIDE, SAND, FOAM/DRY CHEMICAL.
WATER SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:CORROSIVE AND TOXIC GASES SUCH AS
HYDROGEN CHLORIDE AND PHOSGENE MAY BE FORMED.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. VENTILATE AREA.
SMALL SPILL: MOP/WIPE/SOAK UP IMMEDIATELY. REMOVE TO OUT DOORS.
LARGE SPILL: EVACUATE AREA. CONTAIN LIQUID. TRANSFER TO CLOSED
METAL CONTAINERS. KEEP OUT OF WATER SUPPLY.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL & VENTILATED PLACE. KEEP
OUT OF REACH OF CHILDREN.
Other Precautions:DO NOT ENTER LOW AREAS WHERE PRODUCT CAN ACCUMULATE
UNLESS SPECIAL BREATHING APPARATUS IS USED & OBSERVER IS PRESENT
FOR ASSISTANCE.

Respiratory Protection:NONE NORMALLY REQUIRED. IF TLV IS EXCEEDED OR
FOR SYMPTOMS OF OVER EXPOSURE, WEAR NIOSH-APPROVED ORGANIC VAPOR
RESPIRATOR OR AIR-PURIFYING RESPIRATOR. IN EMERGENCY, WEAR A
NIOSH-APPROVED POSITIVE-PRES SURE SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Protective Gloves:PVC/PVA FOR PROLONGED/REPEATED CONTACT
Eye Protection:SAFETY GLASSES/CHEMICAL SPLASH GOGGLES
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
NOTE TO PHYSICIAN: ASPIRATION INTO LUNGS MAY CAUSE SYSTEMIC EFFECTS. IF
LAVAGE IS PERFORMED, SUGGEST ENDOTRACHEAL AND/OR ESOPHAGOSCOPIC
CONTROL. DO NOT ADMINISTER SYMPATHOMIMETIC DRUGS UNLESS ABSOLUTE LY
NECESSARY. NO SPECIFIC ANTIDOTE. SUPPORTIVE CARE.

HCC:T4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:189F,87C
Vapor Pres:60 @ 68F
Vapor Density:4.53
Spec Gravity:1.46
Viscosity:NOT RELEVANT
Solubility in Water:0.1G/100G @25C (77F)
Appearance and Odor:CLEAR LIQUID - IRRITATING ODOR @ HIGH
CONCENTRATIONS
Percent Volatiles by Volume:93- 97

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:OPEN FLAMES, WELDING ARCS AND OTHER HIGH
TEMPERATURE SOURCES
Hazardous Decomposition Products:CORROSIVE AND TOXIC GASES SUCH AS
HYDROGEN CHLORIDE, CHLORINE AND PHOSGENE MAY BE FORMED.

Waste Disposal Methods:DISPOSING UNUSED CONTENTS PREFERRED OPTIONS:
SEND TO LICENSED RECLAIMERS, PERMITTED INCINERATORS. DISPOSAL MUST
BE IN ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS. DO
NOT DUMP INTO SEWERS/ ON GROUND/INTO BODY OF WATER.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.