Product ID:F0201
MSDS Date:08/30/1993
FSC:8010
NIIN:00-616-7490
MSDS Number: BWSSS

DEL PAINT CORPORATION

3105 EAST RENO
OKLAHOMA CITY, OK 73117
US

Emergency Phone: 800-424-9300 CHEMTREC

Info Phone: 405-672-1431

Preparer: ONEY FLEMING

Cage: EO326

DEL PAINT MFG

OKLAHOMA CITY, OK 73117 US

Telephone: 405-672-1431

Cage: 39934

PETROLEUM DISTILLATES

CAS: 8002-05-9

RTECS: SE7449000

Fraction By Weight: 27.66%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

XYLENE (SARA 313) (CERCLA)

CAS: 1330-20-7

RTECS: ZE2190000

Fraction By Weight: 0.24%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

NON-HAZARDOUS INGREDIENTS

Fraction By Weight: 72.10%

3.25 LB/GL; 390 G/LTR

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: IRRITATION, REDNESS,
TEARING, AND BLURRED VISION. SKIN CONTACT: PROLONGED OR REPEATED
EXPOSURE CAN CAUSE MODERATE IRRITATION, DEFATTING AND DERMATITIS.
INHALATION: NASAL AND RESPIRATORY I RRITATION, DIZZINESS, NAUSEA,
AND HEADACHE. INGESTION: CAN CAUSE GASTROINESTINAL IRRITATION,
NAUSEA, VOMITING & NAUSEA.
Effects of Overexposure:IF TLV'S ARE EXCEEDED SKIN CONTACT PRODUCES
REDNESS. EYE CONTACT PRODUCES REDNESS AND PAIN. INHALATION GIVES
LABORED BREATHING, DULLNESS, DROWSINESS. INGESTION CAN CAUSE
ABDOMINAL PAIN AND NAUSEA.
Medical Cond Aggravated by Exposure:DISEASES OF THE RESPIRATORY SYSTEM.

First Aid:EYE CONTACT: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15
MINUTES, OCCASIONALLY LIFTING EYELIDS. SEEK MEDICAL ATTENTION. SKIN
CONTACT: REMOVE CONTAMINATED CLOTHING. WASH AFFECTED SKIN WITH SOAP
& WATER. I NHALATION: REMOVE TO FRESH AIR, ADMINISTER OXYGEN IF
NECESSARY, SEEK MEDICAL ATTENTION. INGESTION: KEEP WARM, QUIET, AND
GET MEDICAL ATTENTION. DO NOT INDUCE VOMITING.

Flash Point Method:TCC
Flash Point:115F,46C
Autoignition Temp:Autoignition Temp Text:540F
Lower Limits:1
Upper Limits:6
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, OR FOAM. WATER MAY
SPREAD FIRE, USE WATER SPRAY ONLY TO COOL CONTAINERS EXPOSED TO
FIRE.
Fire Fighting Procedures:WEAR SCBA(PRESSURE DEMAND MSHA/NIOSH APPROVED)
& FULL PROTECTIVE GEAR. USE WATER SPRAY TO COOL CONTAINERS TO
PREVENT PRESSURE BLDUP & AUTOIGNIT/EXPLOSION W/HEAT
Unusual Fire/Explosion Hazard:VAPOR HEAVIER THAN AIR & MAY TRAVEL ALONG
GROUND OR BE MOVED BY VENT & IGNITED BY PILOT LIGHT, OTHER FLAMES,
SPARK, HEATER, SMOKING OTHER REMOTE IGNITN SOURCES.

Spill Release Procedures:VENTILATE THE AREA. COVER SPILL WITH INERT
ABSORBENT MATERIAL AND SHOVEL WITH NON-SPARKING TOOL INTO
CONTAINER. REMOVE CONTAINERS TO A SAFE AREA AND SEAL.

Handling and Storage Precautions:STORE IN A CLEAN DRY AREA. KEEP AWAY
FROM SPARKS, FIRE AND REMOTE IGNITION SOURCES.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED. KEEP AWAY FROM
CHILDREN. ALL EQUIPMENT SHOULD BE GROUNDED TO REDUCE STATIC
ELECTRICITY HAZARD. USE NON-SPARKING TOOLS.

Respiratory Protection:IF TLV OF THE PRODUCT OR ANY COMPONENT IS
EXCEEDED, USE A RESPIRATOR WITH APPROPRIATE CARTRIDGES (MIOSH
APPROVED). ENGINEERING OR MANAGEMENT CONTROLS SHOULD BE IMPLEMENTED
TO REDUCE EXPOSURE.
Ventilation:LOCAL EXHAUST MUST BE SUFFICIENT TO KEEP AIRBORNE VAPOR
CONCENTRATIONS BELOW THE TLV LIMIT.
Protective Gloves:CHEMICAL RESISTANT GLOVES
Eye Protection:SAFETY GLASSES WITH SIDE SHIELDS
Other Protective Equipment:SUGGEST THAT SOURCE OF CLEAN WATER BE
AVAILABLE IN WORK AREA FOR FLUSHING EYES & SKIN.WEAR IMPERVIOUS
CLOTHING AS NEEDED
Supplemental Safety and Health

Boiling Pt:B.P. Text:303F,151C
Decomp Temp:Decomp Text:752F,400C
Vapor Pres:2.58
Vapor Density:> AIR
Spec Gravity:1.23 (WATER=1)
Viscosity:77 - 86 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NO
Appearance and Odor:GREEN LIQUID WITH SLIGHT ODOR
Percent Volatiles by Volume:45.97

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT STORE NEAR HEATED SURFACES, OPEN
FLAMES OR IGNITION SOURCES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE

Waste Disposal Methods:WASTE MATERIAL MUST BE DISPOSED OF IN ACCORDANCE
WITH FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATORY CONTROLS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.