Product ID:2-C, "A" SIDE
MSDS Date:04/01/1994
FSC:8040
NIIN:00N059938
MSDS Number: BXQYQ

VAGABOND CORP

WARNER SPRINGS, CA 92086
US

Emergency Phone: 800-255-3924

Info Phone: 619-782-3136

Cage: 5X169

VAGABOND CORP

RANCHITA, CA 92066 US

Telephone: 619-782-3136

Cage: 5X169

ISOCYANIC ACID, METHYLENEDI-P-PHENYLENE ESTER; (MDI)

CAS: 101-68-8

RTECS: NQ9350000

Fraction By Weight: 64%

OSHA PEL C 0.02 PPM

ACGIH TLV: 0.005 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

FUEL OIL, #2; (FUEL OIL #2)

CAS: 68476-30-2

RTECS: LS8930000

Fraction By Weight: 31%

OSHA PEL N/K

ACGIH TLV: 10 MG/M3 (MFR)

WATER ACT, RESOURCE CONSERVATION &

RTECS: 9999999ZZ

THAT ALL ENGINEERING AND PERSONAL PROTECTIVE

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:GEN: NO TOX INFO AVAIL FOR THIS
SPECIFIC PREPARATION. HLTH HAZ BASED ON INFO AVAIL FOR COMPONENTS.
ACUTE: INHAL CAN IRRIT EYES, NOSE & RESP PASSAGES. MAY CAUSE
CHRONIC COUGH, TIGHTNESS IN CHEST W/DIFF ICULTY IN BREATHING. SKIN
CONT MAY CAUSE IRRIT. EYE CONT WILL CAUSE IRRIT. INGEST PRACTICALLY
NON TOX. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: IRRIT MAY FOLLOW. MAY CAUSE IRRIT TO
MOUTH ON DOWN TO STOMACH. CHRONIC: AS A RESULT OF PREVIOUS REPEATED
OVEREXPOSURES OR A LARGE SINGLE DOSE, CERTAIN INDIVIDUALS DEVELOP A
SENSITIZATION WHI CH WILL CAUSE THEM TO REACT TO A LATER EXPOSURE
WELL BELOW THE TLV.
Medical Cond Aggravated by Exposure:NONE DETERMINED.

First Aid:EYES: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN,
LIFTING LOWER & UPPER EYELIDS OCCASNLY. GET MD ATTN IMMED. SKIN:
IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN WHILE REMOVING
CONTAM CLTHG & SHOES. WASH CLTHG BEFORE REUSE. THOROCLEAN SHOES
BEFORE REUSE. GET MD ATTN IF IRRIT PERSISTS. INHAL: REMOVE TO FRESH
AIR. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYGEN.
GET (SUP DAT)

Flash Point Method:COC
Flash Point:>212F,>100C
Extinguishing Media:WATER SPRAY, FOAM, CARBON DIOXIDE/DRY CHEM. IF
WATER USED, USE LGE QTYS. RXN BETWEEN WATER & HOT ISOCYANATE (SUP
DAT)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:A WATER CONTAMINATION WILL PRODUCE CARBON
DIOXIDE. DO NOT RESEAL CONTAMINATED CONTAINERS AS PRESSURE BUILD-UP
MAY RUPTURE THEM.

Spill Release Procedures:LEAKS SHOULD BE STOPPED. SPILLS SHOULD BE
CONTAINED AND CLEANED UP IMMEDIATELY. VENTILATE AREA. DO NOT ALLOW
SPILL TO GET IN THE WATER SYSTEM. WOULD RECOMMEND ABSORBING THE
SPILL WITH SAWDUST OR OTHER ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP IN ORIGINAL CONTAINER, STORED IN
A COOL, DRY, VENTILATED AREA. PROTECT FROM PHYSICAL DAMAGE. KEEP
TOP CLOSED TIGHTLY WHEN NOT IN USE.
Other Precautions:WHEN HNDLG, WEAR SFTY GOGG, RUB GLOVES. NEVER TOUCH
EYES/FACE W/HANDS/GLOVES THAT MAY BE CONTAM W/PROD. DO NOT EAT,
DRINK/SMOKE DURING HNDLG. CAREFULLY READ ALL INSTRUCTIONS ON LABEL
& PROD BULLETIN B EFORE HNDLG THIS PROD. MAKE SURE (ING 4)

Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:EMERG EYE WASH AND DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR CLOTHING & SHOES TO PROTECT SKIN.
Work Hygienic Practices:WASH AT THE END OF EACH WORKING PERIOD AND
BEFORE EATING, SMOKING OR USING THE TOILET.
Supplemental Safety and Health
EXTING MEDIA: MAY BE VIGOROUS. MATLS TO AVOID: RXN VERY SLOW UNDER 50C,
BUT ACCELERATED AT HIGHER TEMPS. FIRST AID PROC: MD ATTN. INGEST:
DO NOT INDUCE VOMIT! GIVE LGE QTYS OF WATER/MILK. DO NOT ATTEM PT
TO INDUCE VOMIT/GIVE ANYTHING BY MOUTH TO UNCON PERS. IF VOMIT
OCCURS, ADMIN WATER. GET MD ATTN IMMED.

Boiling Pt:B.P. Text:>500F,>260C
Spec Gravity:1.08 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, DARK LIQUID, WITH MILD TO MILD FRUITY

Stability Indicator/Materials to Avoid:YES
PROD WILL REACT W/ANY MATLS CONTAINING ACTIVE HYDROGEN, SUCH AS WATER,
ALCOHOL, AMMONIA, ALKALIES & ACIDS. (SUP DAT)
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
NITROGEN OXIDES, AMMONIA AND TRACE AMOUNTS OF HYDROGEN CYANIDE.
Conditions to Avoid Polymerization:MAY OCCUR AT VERY HIGH TEMPERATURES.
AVOID HIGH TEMPERATURES IN THE PRESENCE OF ALKALIES.

Waste Disposal Methods:DISP OF NEUTRALIZED MATL IN INDUSTRIAL SEWAGE
TREATMENT FACILITY. CARE MUST BE TAKEN WHEN USING/DISP OF CHEM
MATLS &/THEIR CONTRS TO PREVENT ENVIRONMENTAL CONTAM. IT IS YOUR
DUTY TO DISP OF CHEM MATLS &/THEIR CONTRS W/CLEAN AIR ACT, CLEAN
(ING 3)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.