Product ID:214 PIPE CLEANER
MSDS Date:02/07/1995
FSC:6850
NIIN:01-298-3770
MSDS Number: BXZHP

PCI INDUSTRIES INC

RIVIERA BEACH, FL 33404
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 407-844-0241

Preparer: N. JOHNSON

Cage: FO174

PCI INDUSTRIES INC

9845 RIVIERA BEACH, FL 33419 US

Telephone: (407) 844-0241

Cage: FO174

ACETONE (SARA 313) (CERCLA)

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: >50%

OSHA PEL 1000 PPM

ACGIH TLV: 750PPM/1000STEL;9495

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA 313) (CERCLA)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: <50%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM/300STEL;9495

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL:CAN CAUSE RESP
IRRIT,HEAD.SKIN/EYE:CAN CAUSE IRRIT,REDNESS,TEARING,BLURRED
VISION,DEFATTING(DRYNESS).SKIN ABSORPTION:SEVERE IRRIT &
DEFATTING.CAN CAUSE RASH.INGEST:CAUSES NAU,VOMIT,HEAD,DIZZ, ST
UPOR,DIARR.POTENTIAL LOCAL/SYSTEMATIC EFFECTS DUE TO REPEATED/LONG
TERM EXPO TO EYE/SKINS/THRU INHAL/INGEST.
Explanation of Carcinogenicity:PER MSDS:NTP/IARC/OSHA:NO.NONE HAZ
INGREDS CONSIDERED TO BE CARCINGENITIC BY NTP/IARC/OSHA.
Effects of Overexposure:RESP IRRIT, HEADACHE, SKIN/EYE IRRIT, REDNESS,
TEARING, BLURRED VISION, DEFATTING, DRYNESS, RASH, NAUSEA,
VOMITING, STUPOR, DIARRHEA.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:EYE:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST 15MINS.CALL
PHYSICIAN. INGEST:IF CONSC DILUTE BY GIVING 2 GLASSES OF WATER.CALL
PHYSICIAN/POIS CNTRL CNTR/HOSPITAL/EMERG RM IMMED.KEEP
WARM/QUIET.DO NOT IN DUCE VOMIT. SKIN:REMOVE CONTAMIN CLOTH PRIOR
TO FLUSHING W/WATER. INHAL:SEEK FRESH AIR.BREATH STOPPED GIVE ART
RESP.GET MED ATTN.

Flash Point Method:TCC
Flash Point:24.0F,-4.4C
Lower Limits:1.8
Upper Limits:13.2
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR 800-424-9300(CHEMTREC) W/FULL FACEPIECE
OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE PRESSURE MODE WHEN
FIGHTING FIRES.
Unusual Fire/Explosion Hazard:VAP HEAVIER THAN AIR;MAY TRAVEL ALONG
GROUND/MOVE BY VENTI & IGN BY PILOT
LIGHTS/FLAMES/SPARKS/HEATER/SMOKING/ELECT MOTORS/STATIC
DISCHARGE/OTHER IGN (SUPPLEME)

Spill Release Procedures:EXTINGUISH & DO NOT TURN ON ANY IGN SOURCE TIL
AREA DETERMINED TO BE FREE OF EXPLO/FIRE HAZ.ABSORB W/SAND/INERT
MATL.DISPOSE OF AS SOLID WASTE ACCORDING TO LOCAL, STATE AND
FEDERAL REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:IMPACT MAY PUNCTURE CNTNR OR LOOSEN
CAP CAUSING LEAK.GROUND/BOND CNTNRS WHEN POURING TO AVOID
POSSIBILITY OF STATIC DISCHARGE SPARK.
Other Precautions:KEEP AWAY FRM HEAT/SPARK/FLAME.AVOID BREATH VAP.AVOID
CONTACT W/EYE/CLOTH.KEEP CNTNR CLSD.USE W/ADEQUATE VENTI.CNTNR OF
MATL MAY BE HAZ WHEN EMPTY SINCE EMPTIED CNTNR RETAIN
RESIDUES(VAP/LIQ/&/OR SOLI D).ALL HAZ PRECAUT GIVEN MUST BE OBSERVE

Respiratory Protection:IF TLV OF PRODUCT OR ANY COMPONENT OF IT IS
EXCEEDED NIOSH/MSHA APPROVED AIR SUPPLIED RESP IS ADVISED IN
ABSENCE OF PROPER ENVIRON CNTRL. OSHA REGS ALSO PERMIT OTHER
NIOSH/MSHA RESP UNDER SPECIFIED CO NDITIONS.
Ventilation:PRODUCT USED IN CONFINED AREA PROVIDE SUFFI MECHANICAL(GEN
&/OR LOC EXHAU)VENTI TO MAINTAIN EXPO BELOW TLV.EXPLO-PROOF.
Protective Gloves:RUBBER,BUTYL,OTHER IMPERVIOUS MATL.
Eye Protection:CHEMICAL SAFETY SPLASH GLASSES.
Other Protective Equipment:EYEBATH, SAFETY SHOWER, FACE SHIELD, RUBBER
SAFETY BOOTS.
Work Hygienic Practices:WASH CONTAMIN CLOTHING BEFORE RE-USE.WASH
THOROUGHLY AFTER USING.AVOID SKIN/EYE CONTACT.
Supplemental Safety and Health
FIRE/EXPLO HAZ:SOURCES @LOCATION DISTANT FRM MATL HNDLG PT.

HCC:F2
Boiling Pt:=56.C, 132.8F
Vapor Pres:>AIR
Spec Gravity:0.8
Evaporation Rate & Reference:FASTER THAN BUTYL ACETATE
Solubility in Water:SOLUBLE.
Appearance and Odor:CLEAR LIQUID W/STRONG SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME, &
OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:MAY FORM TOXIC MATLS, CARBON DIOXIDE,
CARBON MONOXIDE, & VARIOUS HYDROCARBONS.

Waste Disposal Methods:COMPLY W/FED/STATE/LOCAL REGS.IF PERMITS & REGS
ALLOW MAY BE INCINERATED.ALLOWED TO EVAPORATE OR SOLIDIFIED W/INERT
MATL & DISPOSE OF.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.