Product ID:MARBLE CLEAR GEL COAT, CG-37011
MSDS Date:01/16/1995
FSC:8030
NIIN:00N062901
MSDS Number: BYSXK

NESTE POLYESTER

5106 WHEELER AVE
FORT SMITH, AR 72901
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 501-646-7865

Cage: JO113

NESTE POLYESTER

FORT SMITH, AR 72901 US

Telephone: 501-646-7865

Cage: JO113

STYRENE; (11 STYRENE) (SARA 313)

CAS: 100-42-5

RTECS: WL3675000

Fraction By Weight: 46.95%

OSHA PEL 100 PPM

ACGIH TLV: S,50PPM/100STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE C ONTENTS MAY BE HARMFUL OR FATAL.
DO NOTBREATH VAPORS OR MIST. VAPORS OF THIS PRODUCT MAY CAUSE IRRIT
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:STYRENE:IARC MONOGRAPHS ON THE EVAL OF
CARCIN RISK OF CHEMS TO MAN VOL 60, PG 233 1994:GROUP 2B
ANIMAL:SKIN, BLOOD.
Effects of Overexposure:HLTH HAZS:OF THE EYES, NOSE, THROAT, UPPER
RESPIRATORY TRACT, MUCOUS MEMBRANES AND SKIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES:FLUSH W/LUKE WARM WATER FOR @ LST 15 MIN. SEEK MD IMMED.
SKIN:FLUSH WASH W/COPIOUS AMTS OF LUKE WARM WATER. REMOVE CONTAM
CLTHG PROMPTLY. WASH THORO W/SOAP & WATER. INHAL:REMOVE TO FRESH
AIR. RES TORE BRTHG IF REQ. CONT MD IMMED. INGEST:RINSE MOUTH
IMMED. GIVE 6-8 OZS OF LIQ. (NEVER GIVE ANYTHING BY MOUTH TO AN
UNCON PERSON). DO NOT INDUCE VOMIT UNLESS ADVISED BY MD. CONT MD
IMMED.

Flash Point Method:TCC
Flash Point:89.0F,31.7C
Lower Limits:1.1%
Upper Limits:6.1%
Extinguishing Media:USE FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . A WATER STREAM CAN SCATTER FLAMES. A SPRAY
OF WATER MAY BE USED TO COOL FIRE-EXPOSED CNTNRS.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. VAPS MAY BE HVR/AIR & MAY
TRAVEL ALONG GROUND BEFORE IGNIT/FLASHING BACK TO VAP SOURCES. KEEP
WELDING/CUTTING EQUIP AWAY FRO M PROD.

Spill Release Procedures:STAY UPWIND & AWAY FROM SPILL UNLESS WEARING
APROP PROT EQUIP. STOP &/OR CNTN DISCHARGE IF IT MAY BE DOSE
SAFELY. KEEP ALL SOURCES OF IGNIT AWAY. VENT AREA OF SPILL. USE
NON-SPKING TOOLS FOR CLEANUP. COVER W/INERT MATL TO REDUCE FUMES.
KEEP OUT OF DRAINS, SEWERS/WATERWAYS. CONT FIRE AUTHS. NOTIFY LOC
HLTH & POLLUTION CTL AGENCIES. CALL SPILL RESPONSE TEAMS IF LG
SPILL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:AVOID UNNEC CONT; STORE IN DRY AREA
AWAY FROM EXCESSIVE HEAT. FOR INDUST USE ONLY. PERS SHOULD AVOID
INHAL OF VAPS.
Other Precautions:PERSONAL CONT W/PROD SHOULD BE AVOIDED. SHOULD CONT
BE MADE, REMOVE SATURATED CLTHG & FLUSH AFFECTED SKIN AREAS
W/WATER. CNTNRS OF MATL MAY BE HAZ WHEN EMPTIED. SINCE EMPTIED
CNTNRS RETAIN PROD RESIDU ES (VAP, LIQ &/OR SOLID), ALL HAZ PRECS
GIVEN IN SHEET MUST BE OBSERVED.

Respiratory Protection:WEAR AN APPROP, PROPERLY FITTED RESP (NIOSH/MSHA
APPRVD) DURING & AFTER APPLICATN UNLESS AIR MONITORING DEMONSTRATES
VAP/MIST LEVELS ARE BELOW APPLIC LIMS. FOLLOW RESP MFR'S DIRECTIONS
FOR RESP USE. I N OUTDOOR/OPEN AREAS USE (NIOSH/MSHA APPRVD) MECH
FILTER RESP TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY DURING
SPRAY APPLICATN. IN RESTRICTED VENT(SUPDAT)
Ventilation:USE VENT AS REQ TO CTL VAP CONCS. AVOID PRLNGD/RPTD BRTHG
OF VAPS. IF EXPOS EXCEEDS TLV, USE NIOSH/MSHA APPRVD RESPIRATOR TO
PREVENT OVEREXPOSURE.
Protective Gloves:WEAR RESIST GLOVES SUCH AS NATURAL RUB, NEOPRENE,
BUNA N/NITRILE.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER WHICH
MEET ANSI DESIGN CRITERIA . AN APRON SHOULD BE WORN TO AVOID SKIN
CONT.
Work Hygienic Practices:USE IN ACCORDANCE WITH GOOD INDUSTRIAL
WORKPLACE PRACTICES. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
RESP PROT: AREAS USE (NIOSH/MSHA APPRVD) CHEM-MECH FILTERS DESIGNED TO
REMOVE COMBINATION OF PARTICULATE & GAS & VAP. IN CONFINED AREAS
USE (NIOSH/MSHA APPRVD) AIR LINE TYPE RESPS/HOODS. RESP PROT MAY
ALSO BE NEC IN ANY LATER MFRING OPERATIONS IN WHICH PROD MAY BECOME
AIRBORNE IN FORM OF VAP/DUST.

Boiling Pt:B.P. Text:295F,146C
Vapor Pres:4.30 @ 68F
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR LIQUID WITH AN AROMATIC ODOR.

Stability Indicator/Materials to Avoid:YES
THIS PRODUCT IS INCOMPATIBLE WITH STRONG ACIDS, PEROXIDES, AND OTHER
OXIDIZING AGENTS, ORGANIC METAL SOAPS.
Stability Condition to Avoid:AVOID EXPOSURE TO SPARKS, OPEN FLAME, HOT
SURFACES, AND ALL SOURCES OF HEAT AND IGNITION.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
TOXIC OXIDES OF CARBON AND/OR NITROGEN.

Waste Disposal Methods:DO NOT FLUSH TO SEWER, WATER SHED OR WATERWAY.
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
DO NOT INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.