Product ID:7208
MSDS Date:03/11/1987
FSC:9150
NIIN:00N063054
MSDS Number: BYWKH

VALVOLINE OIL CO

ASHLAND, KY 41114
US

Emergency Phone: 606-324-1133

Info Phone: 606-329-3333

Cage: DO734

VALVOLINE OIL COMPANY

14000 ASHLAND, KY 41114 US

Telephone: 606-324-1133

Cage: DO734

CARBON DIOXIDE; (CARBON DIOXIDE GAS INDUSTRIAL GRADE)

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: 1-10%

OSHA PEL N/K

ACGIH TLV: 5000 PPM (MFR)

HEPTANE; (ALIPHATIC HYDROCARBON)

CAS: 142-82-5

RTECS: MI7700000

Fraction By Weight: 35-70%

OSHA PEL 500 PPM

ACGIH TLV: 400 PPM/500STEL

ETHANE, 1,1'-OXYBIS-; (ETHYL ETHER) (CERCLA)

CAS: 60-29-7

RTECS: KI5775000

Fraction By Weight: 10-25%

OSHA PEL 400 PPM

ACGIH TLV: 400PPM/500STEL

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:SKIN:NONE EXPECTED AS MATERIAL
IS A GAS. EYES:CAN CAUSE SEVERE IRRITATION, REDNESS, TEARING,
BLURRED VISION. INGESTION:BY NATURE OF PRODUCT PROBLEMS NOT
EXPECTED, BUT INDUSTRIAL PRODUCTS ARE NEV ER MEANT TO BE SWALLOWED.
INHALATION:EXCESSIVE INHAL OF VAPS CAN CAUSE NASAL & RESP IRRIT,
CNS EFTS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:INCLUDING DIZZINESS, WEAKNESS,
FATIGUE, NAUSEA, HEADACHE AND POSSIBLE UNCONSCIOUSNESS, AND EVEN
DEATH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INGEST:CALL MD IMMEDIATELY . SKIN:THOROUGHLY WASH EXPOSED
AREA WITH SOAP AND WATER. EYES:FLUSH WITH LARGE AMOUNTS OF WATER
FOR AT LEAST 15 MINUTES, LIFTING UPPER AND LOWER LIDS OCCAS, GET
MED AT TN. INHAL:REMOVE TO FRESH AIR. IF BRTHGIS DFCLT, ADMIN OXYG.
IF BRTHG HAS STOPPED GIVE ARTF RESP. KEEP PERSON WARM, QUIET AND
GET MED ATTN.

Flash Point:-58F,-50C
Lower Limits:1.1%
Extinguishing Media:REGULAR FOAM, OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER/FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT & POSS
ENDANGER LIFE OF FIREFIGHTER, ESP IF (SUPP DATA)
Unusual Fire/Explosion Hazard:MATL IS HIGHLY VOLATILE & READILY GIVES
OFF VAPS WHICH MAY TRAVEL ALONG GROUND/BE MOVED BY VENT & IGNITED
BY PILOT LIGHTS, OTHER FLAMES, SPKS, HEATERS, (SUPDAT)

Spill Release Procedures:SM SPILL:ALLOW TO EVAPORATE. LARGE
SPILL:ELIMINATE ALL IGNITION SOURCES, (FLARES, FLAMES, INCLUDING
PILOT LIGHTS, ELECTRICAL SPARKS). ALLOW TO EVAPORATE. PERSONS NOT
WEARING PROTECTIVE EQUIP SHOULD BE EXCLUDED FROM AREA UNTIL LEAK
HAS BEENREPAIRED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CNTNRS OF MATL MAY BE HAZ WHEN
EMPTIED. SINCE EMPTIED CNTNRS RETAIN PROD RESIDUES (VAP, LIQ &/OR
SOLID), ALL HAZ PREC GIVEN IN MSDS MUST BE OBSERVED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NOT REQUIRED UNDER NORMAL CONDITIONS OF
USE.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER WHICH
MEET ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:SPRAYED INTO CONTAINERS OF HOT, BURNING LIQUID. EXPLO
HAZS:SMOKING, ELECTRIC MOTORS, STATIC DISCHARGE OR OTHER IGNITION
SOURCES AT LOCATIONS DISTANT FROM MATERIAL HANDLING POINT.

Boiling Pt:B.P. Text:SEE ING 1
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:LESS THAN WATER
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:CLEAR LIQUID.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS, TERMPERATURES OVER 100F
(30C.)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS:CARBON
DIOXIDE, AND CARBON MONOXIDE, VARIOUS HYDROCARBONS, ETC.

Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . SMALL SPILL:ALLOW MATERIAL TO EVAPORATE. LARGE
SPILL:VENTILATE AREA OF SPILL. ALLOW MATERIAL TO EVAPORATE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.