Product ID:REPLENISHER BLACK, RP55, 22534-0058
MSDS Date:02/27/1995
FSC:6750
NIIN:00N063514
MSDS Number: BYZJP

CALCOMP

2411 WEST LA PALMA AVENUE
ANAHEIM, CA 92803
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 714-821-2556

Cage: IO122

CALIFORNIA COMPUTER PRODUCTS SUB OF SANDERS ASSOC

3250 ANAHEIM, CA 92803 US

Telephone: 714-821-2290

Cage: 14668

ACRYLIC POLYMER/RESIN; (ACRYLIC COPOLYMER/RESIN)

CAS: 28430-58-2

Fraction By Weight: <10.0%

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK; (PIGMENT)

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: <10.0%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

VM&P NAPHTHA; (ISOPARAFFINIC SOLVENT)

CAS: 64475-85-0

RTECS: PY8240000

Fraction By Weight: >80.00%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:LD50(ORAL,RAT):5 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:IRRITANT. MAY CAUSE
CONJUNCTIVITIS. SKIN:PROLONGED CONTACT CAUSES DEFATTING, DRYING,
CRACKING, DERMATITIS. INHALATION:NOT NORMALLY AN INHALATION HAZARD.
OVEREXPOSURE MAY CAUSE HEADACHE, NAUSEA AN D RESPIRATORY
IRRITATION. REPEATED INHALATION EXPOSURE TO RATE OF SIMILAR
HYDROCARBON AT CONCENTRATIONS(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:GREATER THAN OR EQUAL TO 300 PPM IN
AIR CAUSED LOW GRADE (MILD) ANEMIA AND KIDNEY EFFECTS.
INGESTION:NAUSEA AND POSSIBLE GASTRO-INTESTINAL IRRITATION.
Medical Cond Aggravated by Exposure:PERS W/PRE-EXISTING HLTH CNDTNS OF
DERM & RESP AILMENTS MAY NOTICE PHYSICAL RXNS WHEN EXPOSED TO SM
AMTS OF PROD OR VAP. CONSULT THEIR TREATING MD FOR PROPER ACTION
AFTER EXPOSURE.

First Aid:EYES:FLUSH W/LG AMTS OF WATER FOR @ LST 15 MIN/UNTIL IRRIT
SUBSIDES, INCLUDING UNDER EYELIDS. IF IRRIT PERSISTS, CONT MD.
SKIN:REMOVE CONTAM CLTHG & DO NOT REUSE UNTIL SOLVS HAVE BEEN
REMOVED. WASH SK IN THORO W/SOAP & WATER. INHAL:MOVE TO FRESH AIR.
CALL MD IMMED. IF BRTHG IS IRREG/STOPPED, START RESUSCITATION IF
TRAINED. ADMIN OXYG IF AVAIL. INGEST:DO NOT INDUCE VOMIT DUE TO
ASPIR HAZ. CALL MD.

Flash Point Method:TCC
Flash Point:>103F,>39C
Lower Limits:0.8%
Upper Limits:7.0%
Extinguishing Media:FOAM, DRY CHEMICAL, CO*2 (CARBON DIOXIDE), WATER
FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . AVOID WATER, IT TENDS TO SPREAD HYDROCARBON
FIRES.
Unusual Fire/Explosion Hazard:NONE. GENERAL HAZARD:COMBUSTIBLE LIQUID,
CAN FORM COMBUSTIBLE MIXTURES AT OR ABOVE THE FLASH POINT.

Spill Release Procedures:REMOVE IGNITION SOURCES. COLLECT ON INERT
ABSORBENT MATERIAL. PLACE IN WASTE CONTAINER APPROVED FOR
COMBUSTIBLE WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:"EMPTY" CNTNRS RETAIN RESIDUE (LIQ
&/OR VAP) & CAN BE DANGEROUS. DISP OF PROPERLY. BLACK LIQ WHICH IS
COMBUSTIBLE.
Other Precautions:MFRD & BOTTLED FOR USE IN CALCOMP PLOTTERS. EXPOS TO
VAPS & FIRE HAZ SHOULD BE MIN WHEN STORED PROPERLY & USED AS
DIRECTED W/CALCOMP EQUIP. PROD WILL STAIN CLTHG & SKIN, PRECS
SHOULD BE TAKEN BY USERS TO PVNT CONT. PROPER VENT OF ROOM WHERE
PLOTTERS ARE OPERATING WILL PVNT VAP ACCUM. PROD IS TO BE S TORED
IN (SUPDAT)

Respiratory Protection:NOT REQUIRED WHEN USED AS INTENTDED. IN
CONCENTRATIONS EXCEEDING THE RECOMMENDED SAFE EXPOSURE LIMIT, SUCH
AS DURING A MAJOR SPILL, USE A NIOSH/MSHA APPROVED CHEMICAL
CARTRIDGE RESPIRATOR EFFECTIVE FO R ORGANIC VAPORS.
Ventilation:LOC EXHST; TO MAINTAIN BELOW TLV. NORMAL OFFICE VENT
CONFORMING TO AMERICAN SOCIETY OF HEATING, AIR CONDITIONING, &
REFRIGERATING ENGINEERS (ASHRAE) (SUPDAT)
Protective Gloves:LATEX, NITRILE/NEOPRENE GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
WEAR CHEM RESIST APRON WHEN CLEANING MACHINES AS PROD MAY STAIN
CLTHG.
Work Hygienic Practices:WHENEVER HANDLING CHEMICALS, ALWAYS USE GOOD
PERSONAL HYGIENE PRACTICES, SUCH AS WASHING YOUR HANDS AFTER USING
PRODUCT.
Supplemental Safety and Health
OTHER PREC: COOL, DRY PLACE TO PVNT DETERIORATION. DURING FIRE, PROD
CAN ESCAPE & PRESENT ADDNL FIRE HAZ. KEEP CNTNRS CLSD WHEN NOT IN
USE. DO NOT SMK WHEN USING PROD. MIN BRTHG VAP/MIST. USE W/ADEQ V
ENT. AVOID PRLNGD/RPTD SKIN CONT. VENT: 1980 STDS IS ADEQ UNDER
NORMAL CNDTNS OF USE. UNDER SOME CONDITIONS(OTHER INFO)

Boiling Pt:B.P. Text:>320F,>160C
Vapor Pres:1@20C(68F)
Vapor Density:5
Spec Gravity:0.76 (H*2O=1)
Evaporation Rate & Reference:0.25-0.45 (N-BUAC=1)
Solubility in Water:IMMISCIBLE
Appearance and Odor:BLACK LIQUID WITH SLIGHT PETROLEUM HYDROCARBON
ODOR.
Percent Volatiles by Volume:80-100

Stability Indicator/Materials to Avoid:YES
VERY STRONG OXIDANTS LIKE CHROMIC ACID OR LIQUID CHLORINE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.

Waste Disposal Methods:RCRA HAZ WASTE #:D001. WASTE TONERS &
REPLENISHERS ARE HAZ WASTES AS DEFINED BY 40 CFR CHAPTER 1 (FLAM).
TREAT AS HAZ WASTE & DISP IN ACCORD W/ALL APPLIC FED, STATE & LOC
DISP REGS. DO NOT POUR DOWN C OMMON DRAIN. CONT LICENSED HAZ WASTE
DISP COMPANY/ENVIRON CTL AGENCY FOR ASSISTANCE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.