Product ID:BONDING ADHESIVE BA-2004A
MSDS Date:04/04/1995
FSC:8040
NIIN:00F047162
MSDS Number: BZCKW

FIRESTONE BUILDING PRODUCTS CO

525 CONGRESSIONAL BLVD
CARMEL, IN 46032-5000
US

Emergency Phone: 615-231-3911/317-575-7190

Info Phone: 615-231-3911/317-575-7190

Cage: FIRES

FIRESTONE BUILDING PRODUCTS CO

CARMEL, IN 46032-5000 US

Telephone: 615-231-3911

Cage: FIRES

CYCLOHEXANE

CAS: 110-82-7

RTECS: GU6300000

Fraction By Weight: <2%

OSHA PEL 1050 MG/CUM

ACGIH TLV: 1030 MG/CUM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

HEXANE, N-HEXANE

CAS: 110-54-3

RTECS: MN9275000

Fraction By Weight: <40%

OSHA PEL 1800 MG/CUM

ACGIH TLV: 176 MG/CUM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-1*

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: <2%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TOLUENE (IARC CARC- GROUP 3) *96-1*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: <55%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

NON-HAZARDOUS INGREDIENTS

Fraction By Weight: >1%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITANT. SKIN: MAY CAUSE
IRRITATION & DERMATITIS. ABSORPTION THROUGH INTACT SKIN MAY
CONTRIBUTE TO OVERALL EXPOSURE. INHALATION: RESPIRATORY SYSTEM
IRRITATION & CNS DEPRESSION. TOLUENE: VAPORS >200 PPM MAY RESULT
IN IMPAIRMENT OF COORDINATION. MAY CAUSE DAMAGE TO KIDNEY, LIVER,
SPLEEN & CNS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, TEARING, BLURRED VISION,
DRYING OF SKIN, NARCOSIS, HEADACHE, DIZZINESS, MUSCULAR WEAKNESS,
FATIGUE. TOLUENE VAPORS >200 PPM: INCOORDINATION, INCREASED
REACTION TIME, BAD TASTE IN THE MOUTH, UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN & RESPIRATORY
DISEASES. EXPOSURE TO HEXANE SHOULD BE AVOIDED BY INDIVIDUALS
W/NEUROLOGICAL DISEASES.

First Aid:EYES: FLUSH IMMEDIATELY W/A GENTLE STREAM OF WATER FOR 15
MINS.. SKIN: CLEAN W/RUBBING ALCOHOL FIRST, FOLLOWED IMMEDIATELY BY
WASHING W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. GIVE
OXYGEN/CPR I F NECESSARY. INGESTION: DON'T INDUCE VOMITING. OBTAIN
MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:TCC
Flash Point:<0F
Lower Limits:1
Upper Limits:7.5
Extinguishing Media:FOAM, WATER SPRAY, FOG, CO2, DRY CHEMICAL &
VAPORIZING TYPE EXTINGUISHING AGENTS.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, BUT MAY BE USED TO
COOL CONTAINERS, DISPERSE VAPORS & PROTECT. WATER SPRAY MAY BE USED
TO FLUSH SPILLS AWAY FROM EXPOSURE. (SUPP)
Unusual Fire/Explosion Hazard:PRODUCT IS VOLATILE & GIVES OFF INVISIBLE
VAPORS. LIQUID/VAPOR MAY SETTLE IN LOW AREAS/TRAVEL A DISTANCE
ALONG THE GROUND TO IGNITION SOURCE & IGNITE/EXPLODE.

Spill Release Procedures:SHUT OFF & ELIMINATE IGNITION SOURCES.
EVACUATE. RECOVER FREE PRODUCT. ADD SAND/EARTH/ABSORBENT TO AREA.
MINIMIZE BREATHING VAPORS/SKIN CONTACT. VENTILATE CONFINED SPACES.
KEEP PRODUCT CLEAR OF SEWERS , WATER/EXTENSIVE LAND AREAS.

Handling and Storage Precautions:KEEP CONTAINERS CLOSED. KEEP AWAY FROM
IGNITION SOURCES. GROUND FIXED EQUIPMENT. BOND & GROUND ALL
TRANSFER CONTAINERS & EQUIPMENT.
Other Precautions:VAPORS ARE >AIR & WILL COLLECT IN LOW/CONFINED AREAS.
CONTAINERS, EVEN WHEN EMPTIED, CAN CONTAIN EXPLOSIVE VAPORS. DON'T
CUT, DRILL, GRIND, WELD/PERFORM SIMILAR OPERATIONS NEAR CONTAINERS.
STATIC ELEC TRICITY MAY ACCUMULATE & CREATE A FIRE.

Respiratory Protection:IF EXPOSURE CONCENTRATIONS CAN'T BE MAINTAINED
ORGANIC VAPOR AIR PURIFYING RESPIRATOR MAY BE APPROPRIATE. AN AIR
SUPPLIED/SCBA RESPIRATORS MAY BE REQUIRED W/UNKNOWN LEVELS.
Ventilation:SUFFICIENT TO PREVENT EXCEEDING EXPOSURE LIMITS/BUILD UP OF
EXPLOSIVE CONCENTRATIONS OF VAPOR IN AIR.
Protective Gloves:POLYVINYL ALCOHOL, NITRILE RUBBER
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS
Other Protective Equipment:NEOPRENE GLOVES TO AVOID PROLONGED SKIN
CONTACT.
Supplemental Safety and Health

Vapor Pres:9-180
Vapor Density:3-4
Spec Gravity:0.86
Evaporation Rate & Reference:(BU ACETATE=1): >1
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID W/STRONG AROMATIC ODOR
Percent Volatiles by Volume:78.3

Stability Indicator/Materials to Avoid:YES
ACIDS, ALKALIES, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, FLAMES, SPARKS/OTHER IGNITION
SOURCES
Hazardous Decomposition Products:COMBUSTION PRODUCTS: CO2, CO,
ALDEHYDES, ACRID SMOKE & IRRITATING FUMES.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. FLAMMABLE LIQUID UN1133.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.