Product ID:PEPTIZER 66
MSDS Date:10/08/1993
FSC:9620
NIIN:00N064459
MSDS Number: BZQBL

AKROCHEM CORP

255 FOUNTAIN ST
AKRON, OH 44304
US

Emergency Phone: 216-535-2108

Info Phone: 216-535-2108

Preparer: R S BRUST

Cage: 0E7C2

AKROCHEM CORPORATION

AKRON, OH 44304-1991 US

Telephone: 330-535-2100

Cage: 0E7C2

CLAY (KAOLIN); (KAOLIN)

CAS: 1332-58-7

RTECS: GF1670500

Fraction By Weight: 50-60%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 2 MG/M3 TDUST

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 0.05%

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 0.1 MG/M3 RDUST

MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED

CAS: 64742-65-0

RTECS: PY8038501

Fraction By Weight: <10%

OSHA PEL 5 MG/M3 (MFR)

ACGIH TLV: 5 MG/M3 (MFR)

(ORAL,RAT)

CAS: 135-57-9

RTECS: CV8700000

Fraction By Weight: 35-45%

OSHA PEL N/K

ACGIH TLV: N/K

CAPACITY & COUGH. IARC VOL 42 HAS RPTD STUDIES WHICH

RTECS: 9999999ZZ

BELIEVES THESE STUDIES HAVE DEMONSTRATED LUNG CANCER

RTECS: 9999999ZZ

POPULATION. THIS INCREASE HAS BEEN SEEN AMONG MINERS,

RTECS: 9999999ZZ

GRANITE WORKERS & STONE CUTTERS. SIMILAR PROD HAVE

RTECS: 9999999ZZ

CRYSTALLINE SILICA PRESENT IN <0.1 PERCENT.

RTECS: 9999999ZZ

LD50 LC50 Mixture:SEE INGREDIENT 4
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:THIS PROD CNTNS MINERAL OIL OF
VERY LOW VAP PRESS. VAP INHAL UNDER AMBIENT CNDTNS IS NORMALLY
NON-HAZ. INHAL OF VAP FROM HEATED PROD MAY CAUSE RESP IRRIT W/SYMP
OF COUGHING AND/OR BRTHG DFCLTY. PROD CNTNS QUARTZ (CRYSTALLINE
SILICA) AS COMPONENT OF KAOLIN. MINERAL OIL COMPONENT OF PROD FUNCT
AS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC MONO,
SUPP, VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH ANNUAL RPT ON CARCINS,
1994: (SUPDAT)
Effects of Overexposure:HLTH HAZ:DUST SUPPRESSANT. HOWEVER, IF DUSTING
SHOULD OCCUR, EXCESS INHAL CAN CAUSE RESP IRRIT W/SYMP OF COUGHING.
EFTS OCCUR PRIMARILY FROM RESPIRABLE PORTION OF QUARTZ DUST. PROD
HAS VERY LOW QUARTZ DUST CONTENT. RESP IRRIT HAS NOT BEEN RPTD IN
SIMILAR PROD. CHRONIC:QUARTZ IN LUNG CAN PRDCE PNEUMOCONIOSIS,
(SUPDAT)
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING IMPAIRED
PULMONARY FUNCTION MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS
PRODUCT.

First Aid:EYES:FLUSH WITH WATER FOR @ LEAST 15 MINUTES. CONSULT PHYS.
SKIN:WASH W/SOAP & WATER. TREAT SYMPTOMATICALLY. INHAL:REMOVE TO
FRESH AIR. INGEST:CALL PHYSICIAN.

Extinguishing Media:WATER, DRY CHEMICAL, FOAM, CO*2.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.

Spill Release Procedures:SPILLS SHOULD BE SWEPT UP AND PLACED IN
CONTAINERS. AVOID FORMATION OF DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:AVOID BRTHG DUST. AVOID GETTING IN
EYES/ON SKIN. STORE IN DRY PLACE AWAY FROM EXCESSIVE HEAT, IN
ORIGINAL OR SIMILAR CONTAINER.
Other Precautions:RESEAL CONTAINER IMMED AFTER USE. STORE AWAY FROM
FOOD & BEVERAGES. IT IS RECOMMENDED THAT THIS PROD BE STORED IN
AREA EQUIPPED W/FIRE PROT (SPRINKLER SYS, PARTITION WALLS, ETC.).

Respiratory Protection:NIOSH/MSHA APPROVED DUST MASK.
Ventilation:LOCAL EXHAUST:(DESIRABLE).
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EXPLAN OF CARCIN:ANTIC TO BE CARCIN. EFTS OF OVEREXP:COMMONLY CALLED
SILICOSIS WHICH IS A CHRONIC, SLOWLY DEVELOPING DISEASE. SYMP OCCUR
AFTER PERIOD OF TIME RANGING FROM 8 MONTHS TO MORE THAN 10 YRS.
SYMP INCL BRTHG DFCLTY (CAUSED BY LUNGSCARS THAT DEVELOP FROM
SILICA DUST) PAIN IN CHEST, DECREASED VITAL (ING 5)

Melt/Freeze Pt:M.P/F.P Text:286F,141C
Spec Gravity:1.83
Solubility in Water:INSOLUBLE
Appearance and Odor:GRAYISH POWDER; SLIGHT ODOR.

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:CO*X, SO*X, HCL, OTHER UNDETERMINED.

Waste Disposal Methods:LANDFILL OR INCINERATION, IN ACCORDANCE WITH
FEDERAL, STATE OR LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.