Product ID:F-23 DOD-3-18210B SH, F-20P03
MSDS Date:07/11/1992
FSC:8030
NIIN:00N025381
MSDS Number: CBBNK

SEAGRAVE COATINGS CORP OF VA

4030 SEAGUARD AVE
PORTSMOUTH, VA 23701
US

Emergency Phone: 804-488-4411

Info Phone: 804-488-4411

Cage: 60163

SHERWIN-WILLIAMS, SEAGUARD

PORTSMOUTH, VA 23704 US

Telephone: 757-397-2223

Cage: 60163

0 @ 20C

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 5%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

0 @ 20C

CAS: 1314-13-2

RTECS: ZH4810000

Fraction By Weight: 10%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

0 @ 20C

CAS: 1309-37-1

RTECS: NO7400000

Fraction By Weight: 15%

OSHA PEL 10 MG/M3 (FE)

ACGIH TLV: 5 MG(FE)/M3FUME, B2

0 @ 20C

CAS: 1309-37-1

RTECS: NO7400000

Fraction By Weight: 5%

OSHA PEL 10 MG/M3 (FE)

ACGIH TLV: 5 MG(FE)/M3FUME, B2

0

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 10%

OSHA PEL 2 MG/M3 RDUST

ACGIH TLV: 2 MG/M3 RDUST

0 @ 20C

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 5%

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 0.1 MG/M3 RDUST

STODDARD SOLVENT; (MINERAL SPIRITS (PETROLEUM SOLVENT)).

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 30%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

0 @

CAS: 64741-65-7

Fraction By Weight: 5%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:ACUTE:INHALATION:IRRITATION TO
RESPIRATORY TRACT, HEADACHE, DIZZINESS AND NAUSEA. SKIN:PRIMARY
IRRITATION. EYE:PRIMARY IRRITATION. CHRONIC:NONE LISTED BY
MANUFACTURER.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE QUARTZ:IARC MONO,
SUPP, VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH ANNUAL RPT ON CARCINS,
1994: (SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS CAN CAUSE HEIGHTENED REACTION TO EXPOSURE TO THIS PRODUCT.

First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR,
RESTORE BRTHG. CONSULT PHYS. SKIN:FLUSH WITH WATER. EYE:FLUSH
IMMEDIATELY W/LG AMTS OF WATER FOR @ LEAST 15 MINS. CONSULT PHYS.

Flash Point Method:TCC
Flash Point:100F,38C
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CLSD CNTNRS TO PVNT PRESS
BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, SPKS, & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT.

Spill Release Procedures:AVOID BRTHG SOLVENT VAPOR. ENSURE ADEQUATE
VENTILATION. AVOID SPARKS, FLAMES, AND ANYTHING WHICH COULD CAUSE
FIRE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL DRY AREA WITH
VENTILATION SUITABLE FOR STORING MATERIALS SHOWN IN INGREDIENT
SECTION.
Other Precautions:PROVIDE RESPIRATORY PROTECTION AGAINST FUMES
GENERATED DURING BURNING.

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR TYPES SUITABLE
FOR MATLS IN INGRED SECTION REC. NIOSH/MSHA APPRVD
CHEMICAL/MECHANICAL FILTERS REC WHEN VENT IS RESTRICTED. NIOSH/MSHA
APPRVD AIRLINE TYPE RESPS/HOODS REC IN CONFINED AREAS.
Ventilation:SUFFICIENT VENT, IN VOL & PATTERN, SHOULD BE PROVIDED TO
KEEP AIR CONTM BELOW CURRENT APPLIC OSHA PEL EXPOS LIM (SUPDAT)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORK GOGG & FSHLD
Other Protective Equipment:USE PROT CREAMS WHERE SKIN CONT IS LIKELY.
ANSI APPRVD EMERGENCY EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:REMOVE & WASH CONTAMD CLTHG BEFORE REUSE. WASH
HANDS BEFORE EATING/SMOKING. SMOKE IN DESIGNATED AREAS ONLY.
Supplemental Safety and Health
FIRE FIGHT PROC:EXPOSED TO EXTREME HEAT. EXPLAN OF CARCIN:ANTIC TO BE
CARCIN. VENT:OR ACGIH'S TLV LIMIT.

Boiling Pt:B.P. Text:>302F,>150C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.24
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:RED, MINERAL SPIRITS ODOR.
Percent Volatiles by Volume:52.6

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:AS WITH ANY OTHER ORG MATL, COMBUST WILL
PRODUCE CARBON DIOXIDE & PROBABLY CARBON MONOXIDE.
Hazardous Decomposition Products:OXIDIZING MATERIALS CAN CAUSE A
VIGOROUS REACTION.

Waste Disposal Methods:SOAK LIQUIDS WITH SAWDUST OR RAGS AND REMOVE.
FLUSH WITH WATER IF POSSIBLE. AVOID SKIN CONTACT. DISPOSAL SHOULD
BE IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.