Product ID:CUTTING FLUID AEROSOL, 91016
MSDS Date:09/19/1994
FSC:9150
NIIN:00N067014
MSDS Number: CBFGH

PREMIER INDUSTRIAL CORP

4500 EUCLID AVE
CLEVELAND, OH 44103
US

Emergency Phone: 216-391-8300

Info Phone: 216-391-8300

Cage: 18399

PREMIER FARNELL CORPORATION

CLEVELAND, OH 44103-3736 US

Telephone: 216-391-8300

Cage: 18399

OXIRANE, METHYL-, POLYMER WITH OXIRANE, MONOBUTYL ESTER;

CAS: 9038-95-3

RTECS: RR0550000

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: N/K

METHYL ETHER; (DIMETHYL ETHER)

CAS: 115-10-6

RTECS: PM4780000

Fraction By Weight: 30-35%

OSHA PEL N/K

ACGIH TLV: N/K

ETHANOL, 2,2',2"-NITRILOTRI-; (TRIETHANOLAMINE).

CAS: 102-71-6

RTECS: KL9275000

Fraction By Weight: 10-15%

OSHA PEL N/K

ACGIH TLV: 5 MG/M3

BENZENE (SARA 313) (CERCLA)

CAS: 71-43-2

RTECS: CY1400000

Fraction By Weight: TRACE

OSHA PEL SEE 1910.1028

ACGIH TLV: 10 PPM

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

ACRYLIC ACID, ETHYL ESTER; (ETHYL ACRYLATE) (SARA 313)

CAS: 140-88-5

RTECS: AT0700000

Fraction By Weight: TRACE

OSHA PEL 25 PPM, S

ACGIH TLV: 5 PPM;15 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TOLUENE (SARA 313) (CERCLA)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: TRACE

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

NON-HAZARDOUS INGREDIENTS; (OSHA NON-HAZARDOUS)

OSHA PEL N/K

ACGIH TLV: N/K

WATER

CAS: 7732-18-5

RTECS: ZC0110000

OSHA PEL N/K

ACGIH TLV: N/K

30%; 4.05 LBS/GAL (485 G/L).

RTECS: 9999999VO

LD50 LC50 Mixture:SEE INGREDIENT 3.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE & SKIN IRRIT. VAPS IN
HIGH CONC ARE ANESTH & IRRIT UPPER RESP SYS. EXCESS INHAL MAY CAUSE
DIZZ, GIDD & NAUS. EXTREME OVEREXP MAY RSLT IN UNCON & POSS DEATH.
PRLNG & RPTD INHAL MAY BE HAR MFUL TO RESP SYS & CNS. MISUSE/DELIB
INHAL MAY BE HARMFUL/FATAL. INGEST CAUSES NAUS, CRAMPS, VOMIT,
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:DIARR. WARNING:THIS PROD CONTAINS
CHEMS KNOWN TO STATE OF CALIFORNIA TO CAUSE CANCER & BIRTH
DEFECTS/OTHER REPRO HARM. NOTE:TOLUENE APPEARS ON NAVY LIST OF
OCCUP CHEM REPRO HAZS. SEEK CONSULT ATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS
INFO .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYE:IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT LEAST 15
MINUTES & CALL MD. INHAL:REMOVE TO FRESH AIR, ADMINISTER OXYGEN &
CALL MD. SKIN:WASH THOROUGHLY W/PLENTY OF WATER & SOAP. INGEST:SEEK
MD IMMEDIA TELY. SHOW MSDS OR LABEL DO NOT INDUCE VOMITING.

Flash Point Method:TCC
Flash Point:6F,-14C
Lower Limits:1.3%
Upper Limits:27%
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CONT W/FLAME OR HOT SURFS MAY PRDCE TOX
GASES. EXPOS TO FIRE, HEAT/PRLNG SUNLIGHT MAY CAUSE BURSTING. IF
USED IN CONFINED SPACES, HAZ VAPS MAY SPREAD, (SUPDAT)

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE THE
AREA. CLEAN UP W/ABSORBENT MATERIAL. CONTAIN & PICK UP WASTE
MATERIALS. PUT IN A SEALED APPROVED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, FLAMES OR
SOURCES OF IGNITION. USE ONLY IN WELL VENTILATED AREAS. AVOID
PROLONGED BREATHING OF VAPORS OR SPRAY MIST.
Other Precautions:AVOID CONT W/EYES & SKIN. DO NOT TAKE INTERNALLY. IN
CASE OF ACCIDENT/ILLNESS, SEEK MD IMMED, SHOW LBL/MSDS. KEEP OUT OF
REACH OF CHILDREN. ALWAYS READ & FOLLOW DIRECTIONS ON PROD LABEL.
ADDNL TECHNIC AL INFO &/OR MSDS'S ARE AVAIL (SUPDAT)

Respiratory Protection:IF VENTILATION IS INADEQUATE, WEAR NIOSH/MSHA
APPROVED RESPIRATORY EQUIPMENT.
Ventilation:LOCAL &/OR MECHANICAL VENTILATION RECOMMENDED.
Protective Gloves:SOLVENT RESISTANT GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER USING.
Supplemental Safety and Health
EXPLO HAZ:BURN OR BUILD UP IN LOW AREAS. EXPLOSIVE POWER: MEDIUM.
BURNING RATE: HIGH. STATIC SENSITIVE: YES FLAMMABLE. OTHER
PREC:UPON REQUEST. FOR PROFESSIONAL & INDUSTRIAL USE ONLY.

Boiling Pt:B.P. Text:<0F,<-18C
Vapor Density:HVR/AIR
Spec Gravity:0.87
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:AMBER LIQUID; LIGHT ODOR.
Percent Volatiles by Volume:40

Stability Indicator/Materials to Avoid:YES
NO
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO*2.

Waste Disposal Methods:DISPOSE OF WASTES I/A/W FEDERAL, STATE & LOCAL
REGULATIONS. DO NOT PUNCTURE, INCINERATE OR BURN CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.