Product ID:5962C
MSDS Date:11/01/1995
FSC:8040
NIIN:00-518-3455
Kit Part:Y
MSDS Number: CCGFW

ENGINEERED FABRICS CORP

669 GOODYEAR ST
ROCKMART, GA 30153
US

Emergency Phone: 800-424-9300 OR 216-379-8562

Info Phone: 404-684-7855 OR 202-483-7616

Preparer: WILLIAM R RITTER

Cage: 0KEA0

ENGINEERED FABRICS CORP

ROCKMART, GA 30153 US

Telephone: 404-684-7855/FAX -7438

Cage: 0KEA0

DIETHYLTOLUENEDIAMINE

CAS: 68479-98-1

Fraction By Weight: 10-15%

2-BUTANONE (METHYL ETHYL KETONE) (MEK)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 85-90%

OSHA PEL 200 PPM

ACGIH TLV: 590 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION. SKIN:
IRRITATION, SENSITIZATION TO DIETHYLTOLUENEDIAMINE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, TEARING, BLURRED VISION
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN &
RESPIRATORY CONDITIONS.

First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT,
GIVE OXYGEN/CPR. KEEP WARM & QUIET. EYES: FLUSH W/PLENTY OF WATER.
SKIN: THROUGHLY WASH W/SOAP & WATER. INGESTION: GIVE 2 GLASSES OF
WATER & INDUCE VOMITING BY STICKING FINGER DOWN THROAT. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. OBTAIN MEDICAL
ATTENTION IN ALL CASES.

Flash Point Method:CC
Flash Point:16F
Lower Limits:1.4
Upper Limits:11.4
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:USE SCBA W/FULL FACEPIECE UNDER POSITIVE
PRESSURE.
Unusual Fire/Explosion Hazard:VAPORS ARE >AIR & MAY TRAVEL ALONG THE
GROUND/MAY BE MOVED BY VENTILATION & BE IGNITED AT LOCATIONS
DISTANT FROM THE MATERIAL HANDLING POINT. FLAMMABLE LIQUID.

Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE AREA. WEAR
PROTECTIVE EQUIPMENT. DIKE/CONTAIN W/ABSORBANT/AVAILABLE MATERIALS.
DON'T ALLOW TO DISCHARGE INTO STORM/SANITARY SEWER. PUMP/BAIL
MATERIAL BACK INTO CONTA INER/CLEAN EMPTY CONTAINER OF DOT.

Handling and Storage Precautions:STORAGE SHOULD BE WELL VENTILATED.
STORE AWAY FROM SOURCES OF HEAT & OPEN FLAMES. KEEP CONTAINER
CLOSED WHEN NOT IN USE.
Other Precautions:CONTACT LENSES SHOULDN'T BE WORN.

Respiratory Protection:IF WORKPLACE CONCENTRATIONS EXCEED THE
RECOMMENDED TLV'S, USE A NIOSH/MSHA APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE. USE AN ATMOSPHERE SUPPLYING RESPIRATOR/AN AIR
PURIFYING RESPIRATOR FOR ORGANIC V APORS.
Ventilation:ADEQUATE EXPLOSION PROOF TO MAINTAIN VAPORS BELOW THE
TLV'S.
Protective Gloves:BUTYL
Eye Protection:CHEMICAL GOGGLES
Other Protective Equipment:IMPERVIOUS PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
LOWER & UPPER EXPLOSIVE LIMIT IS FOR METHYL ETHYL KETONE.

Spec Gravity:0.83
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID W/AMINE ODOR.
Percent Volatiles by Volume:91

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, OPEN FLAMES
Hazardous Decomposition Products:CO, CO2, NITROGEN OXIDES.

Waste Disposal Methods:INCINERATE AT A FACILITY LICENSED FOR DISPOSAL
OF IGNITABLE HAZARDOUS WASTE & IAW/FEDERAL, STATE & LOCAL
REGULATIONS. FLAMMABLE LIQUID UN1993. F005, D001.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.