Product ID:G8019 MCDONNELL DOUGLAS PRIMER & ALUMNI-GUARD
MSDS Date:11/15/1990
FSC:8010
NIIN:00F051843
MSDS Number: CCHCR

US PAINT CORPORATION (FORMERLY GROU GROUP INC)

831 S 21ST ST
ST LOUIS, MO 63103-3043
US

Emergency Phone: 314-621-0525/202-483-7616

Info Phone: 314-621-0525/202-483-7616

Cage: EO831

US PAINT CORPORATION

ST LOUIS, MO 63103-3092 US

Telephone: 314-621-0525

Cage: EO831

XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-3*

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 65%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ALIPHATIC POLYISOCYANATE, HEXAMETHYLENE DIISOCYANATE

CAS: 28182-81-2

RTECS: NQ9170000

Fraction By Weight: 35%

615 GMS/L

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: LIQUID AEROSOLS/VAPORS ARE
IRRITATING. SKIN: IRRITATION, SENSITIZATION IN SOME INDIVIDUALS.
INHALATION: IRRITATION OF THE MUCOUS MEMBRANES IN THE RESPIRATORY
TRACT, NOSE, THROAT & LUNGS. BRONCHI TIS, PULMONARY EDEMA,
HYPERSENSITIVE PNEUMONITIS. INGESTION: HARMFUL, IRRITATION,
CORROSIVE TO MOUTH/STOMACH/GI TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, TEARING, REDDENING, SWELLING,
STINGING SENSATION, RASH, SCALING/BLISTERING, RUNNY NOSE, SORE
THROAT, COUGHING, CHEST DISCOMFORT, SHORTNESS OF BREATH, REDUCED
LUNG FUNCTION, ASTHMA ATTACKS, FEVER, CHILLS, NAUSEA, VOMITING,
DIARRHEA
Medical Cond Aggravated by Exposure:ASTHMA & ANY OTHER RESPIRATORY
DISORDERS, BRONCHITIS, EMPHYSEMA) SKIN ALLERGIES, ECZEMA.

First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/LARGE AMOUNTS OF
WATER FOR 15 MINS. INGESTION: DON'T INDUCE VOMITING. ASPIRATION OF
MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE
FATAL. INHA LATION: GO INTO FRESH AIR. IF NOT BREATHING GIVE CPR.
IF BREATHING IS DIFFICULT GIVE OXYGEN. OBTAIN MEDICAL ATTENTION IN
ALL CASES.

Flash Point Method:TCC
Flash Point:82F
Lower Limits:1.1
Upper Limits:7
Extinguishing Media:DRY CHEMICAL/FOAM, CO2
Fire Fighting Procedures:WEAR SCBA W/A FULL FACEPIECE OPERATED IN
PRESSURE-DEMAND/OTHER POSITIVE PRESSURE MODE. KEEP AWAY FROM HEAT,
SPARKS & FLAME. VAPORS MAY IGNITE EXPLOSIVELY.
Unusual Fire/Explosion Hazard:ISOCYANATE VAPORS MAY BE GENERATED.
CLOSED CONTAINER MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT/BURST
WHEN CONTAMINATED W/WATER (CO2 EVOLVED).

Spill Release Procedures:SMALL: ABSORB LIQUID ON INERT MATERIAL SUCH AS
PAPER, VERMICULITE, FLOOR ABSORBENT & TRANSFER TO HOOD. LARGE:
ELIMINATE IGNITION SOURCES. STOP SPILL, CONTAIN & PUMP LIQUID TO
SALVAGE TANK. REMAINING L IQUID CAN BE ABSORBED W/INERT
MATERIAL.(SEE SUPP)

Handling and Storage Precautions:KEEP CLOSURE TIGHT & UPRIGHT TO
PREVENT LEAKAGE. KEEP CONTAINER CLOSED WHEN NOT IN USE. DON'T STORE
>120F.DON'T TRANSFER CONTENTS TO BOTTLES UNLABLED.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTIED, THEY CONTAIN PRODUCT RESIDUES. DON'T BREATHE VAPORS, SPRAY
MISTS/SANDING DUSTS. DON'T GET IN EYES/SKIN/CLOTHING. CONTACT
LENSES SHOULDN'T BE WORN.

Respiratory Protection:USE NIOSH/MSHA RESPIRATOR.
Ventilation:USE ONLY W/ADEQUATE VENTILATION. MAINTAIN CONTINUOUS FLOW
OF FRESH AIR.
Protective Gloves:SOLVENT IMPERMEABLE
Eye Protection:SOLVENT RESISTANT GLASSES W/SPLASH GUARD
Other Protective Equipment:SOLVENT IMPERMEABLE GLOVES & BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
MATERIAL SPILL CONT'D: PREVENT RUN-OFF TO SEWERS/OTHER BODIES OF WATER.

Boiling Pt:B.P. Text:278-382F
Vapor Density:>1
Spec Gravity:0.95
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIQUID W/SOLVENT ODOR

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS, WATAER, ALCOHOLS, AMINES, STRONG BASES, METAL
COMPOUNDS, SURFACE ACTIVE MATERIALS
Stability Condition to Avoid:HEAT, SPARKS, IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN, TRACES OF
HYDROGEN CYANIDE & HYDROGEN DIISOCYANATE

Waste Disposal Methods:ALLOW VOLATILE PORTION TO EVAPORATE IN HOOD
BEING SURE TO ALLOW SUFFICIENT TIME FOR VAPORS TO COMPLETELY CLEAR
HOOD DUCT WORK. DON'T INCINERATE CLOSED CONTAINERS. DISPOSE OF
IAW/LOCAL, STATE & FEDERAL REGULATIONS. UN1263

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.