Product ID:METHYLENE CHLORIDE, DEGREASING GRADE
MSDS Date:09/01/1993
FSC:6850
NIIN:00N074890
MSDS Number: CDLCJ

VULCAN MATERIALS

BIRMINGHAM, AL 35253-0390
US

Emergency Phone: 316-524-5751

Info Phone: 800-873-4898

Cage: 1B637

VULCAN MATERIALS CO

530390 BIRMINGHAM, AL 35253 US

Telephone: 316-524-5751

Cage: 1B637

METHANE, DICHLORO-; (DICHLOROMETHANE) (SARA 313) (CERCLA)

CAS: 75-09-2

RTECS: PA8050000

Fraction By Weight: >98%

OSHA PEL 500 PPM

ACGIH TLV: 50 PPM, A2

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

PROPANE, 1,2-EPOXY-; (PROPYLENE OXIDE) (SARA 302/313)

CAS: 75-56-9

RTECS: TZ2975000

OSHA PEL 100 PPM

ACGIH TLV: 20 PPM

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

TEMP IRRIT W/TEMP CORNEAL INJURY. VAPS MAY IRRITATE

RTECS: 9999999ZZ

OCCURS, METHYLENE CHLORIDE CAN BE ASPIRATED INTO

RTECS: 9999999ZZ

FINDINGS OF CHRONIC EFTS IN LAB ANIMALS

RTECS: 9999999ZZ

FAILURE TO DO SO COULD RSLT IN INJURY, ILLNESS/EVEN

RTECS: 9999999ZZ

CAUSED LIVER & KIDNEY TOX EFTS IN EXPT ANIMALS.

RTECS: 9999999ZZ

IN RATS EXPOSED BY INHAL, FORESTOMACH TUMORS IN RATS

RTECS: 9999999ZZ

TUMORS WHEN INJECTED UNDER SKIN OF RATS. EPIDEMIOLOGY

RTECS: 9999999ZZ

METHYLENE CHLORIDE IN WORKPLACE OF WHICH 252 WERE

RTECS: 9999999ZZ

IN DEATH CAUSED BY CANCER/CARD PROBLEMS. SECOND

RTECS: 9999999ZZ

MATLS HAVE PRDCED SENSIT OF MYOCARDIUM TO

RTECS: 9999999ZZ

ADRENOMIMETICS (E.G., EPINEPHRINE) MAY BE

RTECS: 9999999ZZ

ACUTELY OR CHRONICALLY EXPOSED TO CHLOROCARBONS .

RTECS: 9999999ZZ

CLSD CONTRS FOR DISP. AVOID CONTAM OF GROUND &

RTECS: 9999999ZZ

(RQ) IS 1000 LBS. NOTIFY NATL RESPONSE CTR

RTECS: 9999999ZZ

IN LOW AREAS. DO NOT ENTER CONFINED SPACES SUCH

RTECS: 9999999ZZ

REQUIRED BY 29 CFR 1910.146. DO NOT REMOVE/DEFACE

RTECS: 9999999ZZ

I/A/W ANY APPLIC FED, STATE/LOC LAWS. NO SMKNG IN

RTECS: 9999999ZZ

OPEN FLAMES/HOT SURFACES. HEAT AND/OR UV RADIATION

RTECS: 9999999ZZ

ABOVE 1,000 PPM & FOR SPILLS AND/OR EMERGENCIES.

RTECS: 9999999ZZ

WASH HANDS PRIOR TO EATING, DRINKING, OR

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:MAJOR RTE OF POTENTIAL
EXPOS. METHYLENE CHLORIDE DEPRESSES CNS. CONCS BETWEEN 900-1,000
PPM MAY CAUSE DIZZ. NAUS, HDCH & VOMIT CAN OCCUR AT CONCS >2,000
PPM. AT 7,000 PPM NUMBNESS & TINGLI NG IN ARMS & LEGS & RAPID
HEARTBEAT HAVE OCCURRED. LOSS OF CONSCIOUSNESS & DEATH HAVE
OCCURRED AT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE:IARC MONO, SUPP, VOL
7, PG 194, 1987: GROUP 2B. NTP 7TH ANNUAL RPT ON CARCINS,
1994:ANTIC TO(SUP DAT)
Effects of Overexposure:HLTH HAZ:LEVELS >9,000 PPM IF EXPOS IS PRLNG.
CARBOXYHEMOGLOBIN LEVELS CAN BE ELEVATED IN PERS EXPOSED TO
METHYLENE CHLORIDE & CAN CAUSE SUBSTANTIAL STRESS ON CARDIOVASCULAR
SYS. THIS ELEVATION CAN BE ADDITIVE TO INCR CAUSED BY SMKNG &
OTHER CARBON MONOXIDE SOURCES. SKIN:LIQ METHYLENE CHLORIDE IS
PAINFUL & (SUP DAT)
Medical Cond Aggravated by Exposure:ALCOHOLISM, ACUTE AND CHRONIC LIVER
AND KIDNEY DISEASE, CHRONIC LUNG DISEASE, ANEMIA, CORONARY DISEASE
OR RHYTHM DISORDERS OF THE HEART.

First Aid:INHAL:REMOVE TO FRESH AIR. IF BRTHG HAS STOPPED, ADMIN ARTF
RESP. CALL MD. SKIN:REMOVE CONTAM CLTHG & SHOES. WASH EXPOSED AREA
THORO W/SOAP & WATER FOR AT LEAST 15 MIN. WASH CONTAM CLTHG BEFORE
REUSE. EYE:FLUSH IMMED W/WATER FOR AT LEAST 15 MIN. IF IRRIT
PERSISTS, CALL MD. INGEST:DO NOT INDUCE VOMIT. CONT MD/EMER MED
FACILITY IMMED. NOTE TO MD:NEVER GIVE ADRENALIN IF OVEREXP TO
METHYLENE CHLORIDE.

Flash Point Method:TCC
Flash Point:NONE
Lower Limits:12%
Upper Limits:19%
Extinguishing Media:WATER FOG, DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH APPROVED PRESSURE DEMAND SCBA &
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONCENTRATED VAPORS CAN BE IGNITED BY
HIGH INTENSITY IGNITION SOURCE. THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE HCL AND PHOSGENE .

Spill Release Procedures:EVACUATE AREA, VENT & AVOID BRTHG VAPS. DIKE
AREA TO CONTAIN SPILL. IF SPILL OCCURS INDOORS, TURN OFF AIR
CONDITIONING &/HEATING SYS, TO PVNT VAPS FROM CONTAM ENTIRE BLDG.
CLEAN UP AREA (WEAR PROT EQU IP) BY MOPPING OR W/ABSORB MATL &
PLACEIN(ING 15)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE LABELED SEALED CONTRS IN COOL,
DRY, WELL-VENTD AREA OUT OF SUNLIGHT. PVNT WATER/MIST AIR FROM
ENTERING STOR TANKS/CONTRS.
Other Precautions:DO NOT CUT/WELD ON EMPTY/FULL DRUMS. ALUMINUM EQUIP
SHOULD NOT BE USED FOR STOR &/TRANSFER. CONT W/ALUMINUM PARTS IN
PRESSURIZED FLUID SYS MAY CAUSE VIOLENT RXNS. CONSULT EQUIP SUPP
FOR FURTHER INFO. VAPS ARE HVR/AIR & WILL COLLECT (ING 17)

Respiratory Protection:WHERE VAP CONC EXCEEDS/IS LIKELY TO EXCEED 50
PPM METHYLENE CHLORIDE, A NIOSH APPRVD FULL FACE RESP W/ORG VAP
CANISTER IS ACCEPTABLE. NIOSH APPRVD SCBA/AIR LINE RESP, W/FULL
FACEPIECE, IS REQUIRED FOR METHYLENE CHLORIDE CONCS (ING 21)
Ventilation:DO NOT USE IN CLSD/CONFINED SPACE. OPEN DOORS &/WINDOWS.
USE VENT TO MAINTAIN EXPOS LEVELS OF METHYLENE CHLORIDE <50PPM.
Protective Gloves:VITON, POLYVINYL ALCOHOL/EQUIVALENT.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
WEAR SOLV-RESIST BOOTS, APRON, HEADGEAR &/FSHLD WHEN SPLASHING
POSS.
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN. AVOID CONT
W/SKIN & BRTHG VAPS. DO NOT EAT, DRINK/SMOKE IN WORK AREA. (ING 22)
Supplemental Safety and Health
EXPLAN OF CARCIN:BE CARCIN. ANIMAL:LUNG. EFTS OF OVEREXP:IRRIT IF
CONFINED TO SKIN BY GLOVES, CLTHG, ETC. PRLNG/RPTD CONT MAY CAUSE
IRRIT, DEFAT & DERM. ABSORPTION THRU INTACT SKIN IS POSS IF CONT
W/L IQ IS PRLNG. PROPYLENE OXIDE AS PURE SUBSTANCE HAS CAUSED
ALLERGIC RXN IF RPTD CONT OCCURS. EYE:LIQ MAY CAUSE (ING 3)

Boiling Pt:B.P. Text:103F,39C
Vapor Pres:352
Vapor Density:2.9
Spec Gravity:1.31
Evaporation Rate & Reference:0.7 (ETHER=1)
Solubility in Water:1.32 G/100 G @ 25C
Appearance and Odor:CLEAR, COLORLESS LIQUID; MILDLY SWEET ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, OXYGEN, NITROGEN PEROXIDE, SODIUM, POTASSIUM, AND
OTHER OXIDIZERS AND REACTIVE METALS.
Stability Condition to Avoid:AVOID CONTACT WITH OPEN FLAME, ELECTRIC
ARCS, OR OTHER HOT SURFACES WHICH CAN CAUSE THERMAL DECOMPOSITION.
Hazardous Decomposition Products:HYDROGEN CHLORIDE, PHOSGENE, CHLORINE.

Waste Disposal Methods:RECOVERED LIQUIDS MAY BE SENT TO A LICENSED
RECLAIMER OR INCINERATION FACILITY. CONTAMINATED MATERIAL MUST BE
DISPOSED OF IN A PERMITTED WASTE MANAGEMENT FACILITY. CONSULT
FEDERAL, STATE, OR LOCAL DIS POSAL AUTHORITIES FOR APPROVED
PROCEDURES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.