Product ID:TURCO 6776 LO, 5387363
MSDS Date:08/21/1995
FSC:6850
NIIN:00N077437
MSDS Number: CDNYR

TURCO PRODUCTS INC

2375 STATE RD
CORNWELLS HEIGHTS, PA 19020
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 215-245-3128

Preparer: JOHN DISTASO

Cage: 0BYL8

TURCO PRODUCTS INC

WESTMINSTER, CA 92684-3600 US

Telephone: 714-890-3600

Cage: 0BYL8

BENZYL ALCOHOL

CAS: 100-51-6

RTECS: DN3150000

Fraction By Weight: 15-30%

OSHA PEL N/K

ACGIH TLV: N/K

LINEAR ALKYL BENZENE; (LINEAR ALKYLATED ARYL HYDROCARBON)

CAS: 68648-87-3

Fraction By Weight: <5%

OSHA PEL N/K

ACGIH TLV: N/K

FORMIC ACID (SARA 313) (CERCLA)

CAS: 64-18-6

RTECS: LQ4900000

Fraction By Weight: 5-10%

OSHA PEL 5 PPM

ACGIH TLV: 5 PPM; 10 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

FORMIC ACID, BENZYL ESTER; (BENZYL FORMATE)

CAS: 104-57-4

RTECS: LQ5400000

Fraction By Weight: 10%

OSHA PEL N/K

ACGIH TLV: N/K

WATER

CAS: 7732-18-5

RTECS: ZC0110000

OSHA PEL N/K

ACGIH TLV: N/K

SCAQMD VOC 395 G/L (CALCULATED FROM NOMINAL COMPOSITION);

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

DOT-APPRVD DRUMS FOR DISP. WASH AREA W/WATER,

RTECS: 9999999ZZ

RESIDUAL AMOUNTS OF PROD MAY BE FLUSHED TO SEWER IF

RTECS: 9999999ZZ

IN WATER & TREATED AS DESCRIBED BELOW.

RTECS: 9999999ZZ

DISPOSE PER (1) OR (2)

RTECS: 9999999ZZ

BY PH ADJUSTMENT TO 9.5-10.5; PH OF THE SEPARATED

RTECS: 9999999ZZ

CLARIFIED WATER MAY BE RELEASED TO SEWER IF LOCAL,

RTECS: 9999999ZZ

& FULL LENGTH FACESHIELD .

RTECS: 9999999ZZ

SUIT NOT NORMALLY REQUIRED BUT ADVISED IF

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CONTACT WITH EYES MAY CAUSE
SLIGHT TO MODERATE IRRITATION. SKIN: CONTACT WITH SKIN MAY CAUSE
SLIGHT IRRITATION. INHALATION: INHALATION OF MIST FROM SOLUTION MAY
CAUSE MODERATE TO SEVERE IRRITATI ON OF RESPIRATORY TRACT.
INGESTION: MODERATE TO SEVERE IRRITATION OF GASTROINTESTINAL TRACT,
NAUSEA. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: NO KNOWN CHRONIC EFFECTS THAT DIFFER
FROM ACUTE EFFECTS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES: IMMED BEGIN FLUSHING EYES W/LARGE VOLUMES OF WATER.
CONTINUE FOR AT LEAST 15 MIN. HOLD LIDS APART TO ASSURE CONTACT
W/ALL SURFACES. OBTAIN MED ATTN. SKIN: FLUSH AFFECTED AREA W/LARGE
VOLUMES OF WATER. CONTINUE FLUSHING AT LEAST 15 MIN. IF IRRIT IS
EVIDENT OR BLISTERING OCCURS, OBTAIN MED ATTN. INHAL: REMOVE TO
FRESH AIR. ADMIN OXYGEN IF BRTHG IS DFCLT. OBTAIN MED ATTN IF IRRIT
(SUPDAT)

Flash Point Method:SCC
Flash Point:>212F,>100C
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:CONCENTRATE: CONFINE SPILL. STOP LEAK AT
SOURCE IF THIS CAN BE DONE SAFELY. VENT AREA. NONESSNTL PERS SHOULD
LEAVE AREA UNTIL CLEANUP IS COMPLETED. PUMP LIQ INTO DOT-APPRVD
DRUMS FOR DISP. ABSORB REMA INING LIQ ONTO INERT ABSORB & PLACE IN
(ING 7)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN DRY PROTECTED AREA. OPEN
DRUMS CAREFULLY TO AVOID SPURTING.
Other Precautions:REPAIR & MAINTENANCE OF CONTAMINATED EQUIPMENT:
RELIEVE ANY PRESSURE. COVER OPENINGS TO AVOID SPURTING. CLEAN
EXTERIOR & INTERIOR BY FLUSHING WITH WATER. COLLECT FLUSHINGS FOR
DISPOSAL. USE PROTECTIVE EQUIPMENT FOR EYES, SKIN & INHALATION.

Respiratory Protection:FOR MIST CONDITIONS, A NIOSH APPROVED RESPIRATOR
FOR ACID GASES AND MISTS IS ADVISED. IF RESPIRATORS ARE USED, A
FORMAL TRAINING AND SCREENING PROGRAM MUST BE INITIATED. SEE 29 CFR
1910.134.
Ventilation:MAINTAIN SUFFICIENT MECHANICAL VENTILATION TO KEEP VAPOR
CONCENTRATION BELOW TLV.
Protective Gloves:ACID RESISTANT (VITON, PVC, ETC) GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS (ING 13)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . BOOTS
& APRON MADE OF ACID RESIST MATL (EG VITON, PVC, ETC). PROT (ING
14)
Work Hygienic Practices:WASH HANDS & FACE W/SOAP & WATER BEFORE
SMKNG/EATING. IMMED REMOVE ALL CONTAMD CLTHG. LAUNDER SEPARATELY
BEFORE REUSE.
Supplemental Safety and Health
PH: AS IS 2.0. FIRST AID PROC: PERSISTS. INGEST: DO NOT INDUCE VOMITING
EXCEPT ON ADVICE OF COMPETENT MED PERS. IF CONSCIOUS, DILUTE BY
GIVING LARGE VOLUMES OF MILK OR WATER. OBTAIN IMMED MED ATTN. NE
VER ATTEMPT TO INDUCE VOMITING OR GIVE ANYTHING BY MOUTH TO AN
UNCON PERSON.

Boiling Pt:B.P. Text:212F,100C
Vapor Pres:15
Vapor Density:<1
Spec Gravity:1.04
pH:SUPDAT
Evaporation Rate & Reference:<1 (BUAC=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:VISCOUS LIGHT GREEN EMULSION; SHARP ODOR.
Percent Volatiles by Volume:98

Stability Indicator/Materials to Avoid:YES
CONTACT WITH STRONG ALKALIS, REACTIVE METALS SUCH AS MAGNESIUM OR TIN
(NOT INCLUDING ALUMINUM).
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON MONOXIDE, DIOXIDE AND OTHER TOXIC VOLATILE ORGANIC
COMPOUNDS.

Waste Disposal Methods:CONCENTRATE: (1) TRANSFER TO RECLAIMING CENTER
FOR RECYCLING/REUSE, IF POSS. (2) TRANSFER TO LICENSED HAZ WASTE
TREATMENT/DISP SITE FOR DISPOSITION UNDER APPLIC FEDERAL, LOCAL,
STATE & REGIONAL REGS A S HAZ WASTE. (3) SM AMTS MAY BE DISSOLVED
(ING 9)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.