Product ID:70-60A10 RUST KILL ENAMEL NAVY GRAY
MSDS Date:04/13/1989
FSC:8010
NIIN:00D006926
MSDS Number: CFFBN

YENKIN-MAJESTIC PAINT CORPORATION

1920 LEONARD AVE
COLUMBUS, OH 43236-9004
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 614-253-8511

Cage: EO325

YENKIN-MAJESTIC PAINT CORPORATION

369004 COLUMBUS, OH 43236-9004 US

Telephone: 614-253-8511

Cage: EO325

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 20-25%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9596

BARIUM METABORATE

CAS: 13701-59-2

RTECS: CQ9570000

Fraction By Weight: 2.1%

ALIPHATIC HYDROCARBON

Fraction By Weight: 35-40%

VOLITILE ORGANIC CONTENT AS LISTED ON MSDS, 3.36 #/GAL.

RTECS: 9999999VC

Fraction By Weight: NA

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:ANESTHETIC.IRRIT RESP
TRACT,ACUTE NERV SYS DEPRESS CHARACTERIZED BY FOLLOWING PROGRESSIVE
STEPS:HEAD,DIZZ,STAGGERING GAIT,CONFUSION,UNCONSC,COMA.SKIN/EYE
CONTACT:PRIMARY IRRIT.CHRONIC:NONE RECOGNIZED.
Explanation of Carcinogenicity:PER
MSDS:CARCINOGENICITY:NTP/IARC/OSHA:NO.
Effects of Overexposure:ANESTHETIC,IRRIT RESP TRACT,NERVOUS SYS
DEPRESSION-HEADACHE,DIZZ,STAGGERING GAIT,CONFUSION,UNCONSC,COMA.
Medical Cond Aggravated by Exposure:NONE KNOWN.

First Aid:INHAL:REMOVE TO FRESH AIR.RESTORE BREATHING.TREAT
SYMPTOM.CONSULT DR.SPLASH(EYE):FLUSH IMMED W/LG ATMS OF WATER FOR
@LEAST 15MINS.IRRIT PERSISTS TAKE TO DR FOR MED
TREAT.SPLASH(SKIN):WASH W/SOAP/WATER .REMOVE CONTAMIN CLOTH.CONSULT
DR IF IRRIT PERSISTS.INGEST:DRINK 1 OR 2 GLASSES OF WATER TO
DILUTE.DONT INDUCE VOMIT.CONSULT DR/POISON CNTRL CNTR IMMED.TREAT
SYMPTOMATICALLY.

Flash Point Method:SCC
Flash Point:105F,41C
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:1.0
Upper Limits:NP
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
OSHA:CLASS II, DOT COMBUSTIBLE LIQUID.
Fire Fighting Procedures:H2O MAY BE INEFFECTIVE;IF USE,FOG NOZZ
PREFER.H2O MAY BE USED TO COOL CLSD CNTNR-PREVENT PRESSURE
BUILDUP/AUTO-IGN WHEN EXPO TO EXTREME HEAT.FULL PROTECT(SUPPL)
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT/ELECTR EQPMT/SPARKS/OPN
FLAME.APPLICATION TO HOT SURFACES REQUIRE SPEC PRECAUT.CLSD CNTNR
MAY EXPLO WHEN EXPO TO EXTREME HEAT.DURING (SUPPLE)

Spill Release Procedures:LIMIT SPREAD OF SPILL/LEAK.REMOVE ALL SOURCES
OF IGNITION.SOAK UP W/INERT ABSORBANT MATL.USE NON-SPARKING TOOLS
WHEN REMOVING WET ABSORBENT.SEE OTHER MSDS SECTION FOR REQUIRED
PROTECTIVE MEASURES.KEEP MATL OUT OF SEWERS &/OR DRAINS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AWAY FROM EXTREME HEAT/FIRE/OPEN
FLAME.STORE IAW OSHA 1910.106.DONT STORE >100F(38C).STORE LG QUANT
ONLY IN BLDG DESIGNED TO COMPLY W/1910.106.
Other Precautions:KEEP DR OUT OF DIRECT SUN.STORE IN WELL VENTI
AREA,UPRIGHT,CLOSURE TIGHT.DONT STORE/USE NEAR HEAT/SPARK/OPN
FLAME.DONT FLAME CUT/WELD/BRAZE/ABRADE SURFACES W/MATL CURED ON
THEM W/O APPROVED RESP/ADEQU A VENTI.AVOID BREATH SAND DUST.

Respiratory Protection:THIS MATL NOT SUITED FOR SPRAY
APPLICATION.HOWEVER SINCE VAPORS MAY BE ENCOUNTERED USE RESPIRATOR
W/CHEMICAL FILTER.
Ventilation:VENTILATION OF SUFFICIENT VOL/PATTERN SHOULD BE PROVIDED TO
KEEP AIR CONTAMIN CONCEN BELOW VALUES.
Protective Gloves:FOR PROL/REP CONTACT,RUBB,POLYETHYLENE
Eye Protection:SAF EYEWEAR INCLUDE SPLASH GUARD,SIDESHI
Other Protective Equipment:NONE USUALLY REQUIRED.
Work Hygienic Practices:WASH HANDS BEF EAT/WASHRM USE.SMOKE IN
DESIGNATED SMOKING AREAS ONLY.AVOID PROL/REP SKIN CONTACT.
Supplemental Safety and Health
FIREFIGHT:EQPTM +SCBA SHOULD BE USED TO PROTECT FIGHTERS FROM ANY HAZ
COMBUST PROD. FIRE/EXPLO:EMERG CONDITIONS/OVEREXPO MAY CAUSE HEALTH
HAZ.SYMPT MAY NOT BE IMMED APPARENT.GET MED ATTN.VAP MAY IGNIT E BY
STAT ELECT/FRIC SPARKS.KEEP CNTNR TIGHTLY CLS.

HCC:F4
Boiling Pt:B.P. Text:320F,160C
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:NP
Vapor Density:>AIR
Spec Gravity:NP
pH:NP
Viscosity:NP
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NP
Appearance and Odor:NAVY GRAY
Percent Volatiles by Volume:52.2
Corrosion Rate:NP

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:HEAT,SPARKS,OPEN FLAME.
Hazardous Decomposition Products:MAY PRODUCE FUMES WHEN HEAT TO
DECOMPO,AS IN WELD OR FIRE.FUMES MAY CONTAIN:CO,CO2,OXIDES OF
NITROGEN,OTHER COMBUST PROD

Waste Disposal Methods:DISPO OF IAW ALL LOC,STATE,& FED REGS.APPROVED
LAND FILL,APPROVED HAZ WASTE SITE OR INCINERATION.CHEM SUBJ TO
REPORTING REQMTS OF SEC 313 SARA TITLE III:BARIUM METABORATE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.