Product ID:VR-514
MSDS Date:03/27/1992
FSC:8010
NIIN:01-057-8458
MSDS Number: CFQXC

Emergency Phone: 414-684-6646;800-424-9300(CHEMTREC)

Info Phone: 414-684-6646

Preparer: D. EDWARD BLAKE

Cage: 0VKU9

Telephone: 414-684-6646

Cage: 73159

SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (MINERAL

CAS: 64742-88-7

Fraction By Weight: 30.8%

OSHA PEL 100 PPM (MFR)

ACGIH TLV: 100 PPM (MFR)

REQUIRED TO USE NONFERROUS TOOLS & TO WEAR

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:CONTACT CAN CAUSE SEVERE
IRRITATION, REDNESS, TEARING, BLURRED VISION. SKIN:CONTACT MAY
CAUSE IRRITATION, DEFATTING AND DERMATITIS. INHALATION:CAN CAUSE
NASAL AND RESPIRATORY IRRITATION, DIZZINES S, WEAKNESS, FATIGUE,
NAUSEA AND HEADACHE. INGESTION:CAN CAUSE GASTROINTESTINAL
IRRITATION, NAUSEA, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:VOMITING AND DIARRHEA. ASPIRATION OF
MATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE
FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES:FLUSH W/LG AMTS OF WATER FOR AT LST 15 MINS, LIFTING
UPPER & LOWER LIDS OCCAS. GET MED ATTN PROMPTLY. SKIN:THORO WASH
EXPOS AREA W/SOAP & WATER. REMOVE & LAUNDER CONTAM CLTHG BEFORE
REUSE. INHAL: REMOVE INDIVIDUAL TO FRESH AIR. IF BRTHG IS DFCLT,
ADMIN OXYG. IF BRTHG HAS STOPPED GIVE ARTF RESP. KEEP PERS WARM,
QUIET & GET MED ATTN. INGEST:DO NOT INDUCE VOMIT. GIVE CONSCIOUS
INDIVIDUAL (SUPDAT)

Flash Point Method:TCC
Flash Point:104F,40C
Lower Limits:SEE ING 1
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE COLD WATER TO COOL FIRE-EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID - FLAMM CLASS:OSHA II.
KEEP CONTAINERS TIGHTLY CLOSED. KEEP AWAY FROM HEAT, SPARKS,
ELECTRICAL EQUIPMENT & OPEN FLAME.

Spill Release Procedures:EVACUATE NON-ESSNTL PERS. ELIM ALL IGNIT
SOURCES. VENT AREA. EQUIP CLEAN-UP CREW W/APPROP PROT EQUIP. STOP
SPILL AT SOURCE, DIKE AREA OF SPILL TO PVNT SPREADING. NOTIFY
APPROP AUTHS IF NEC. PUMP/SCOOP LIQ TO SALVAGE TANK/DRUM.
REMAINING LIQ (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AWAY FROM HEAT & OPEN FLAME.
COATING SHOULD NOT BE STORED LONGER THAN 24 MONTHS. STORAGE AT
ABOVE 80F (20C) MAY SHORTEN SHELF LIFE.
Other Precautions:KEEP CLOSURE TIGHT & CONTAINER UPRIGHT TO PREVENT
LEAKAGE. CAUTION:CONTAINS FLAMMABLE SOLVENTS. KEEP AWAY FROM SPARKS
& OPEN FLAMES. ALL ELECTRIC EQUIPMENT & INSTALLATIONS SHOULD BE
MADE & GROUNDED I/ A/W THE NATIONAL ELECTRIC CODE.

Respiratory Protection:A NIOSH APPROVED RESPIRATOR IF REQUIRED IF TLV
OF ANY INGREDIENT IS EXCEEDED. IN CONFINED AREAS, WORKMEN MUST WEAR
NIOSH APPROVED FRESH AIR LINE RESPIRATORS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV'S.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS &(SUPDAT)
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . COVER AS MUCH EXPOS SKIN AREA AS POSS W/APPROP CLTHG.
(SUPP DATA)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:GLASS OF MILK/WATER. DO NOT GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. GET MED ATTN. SPILL PROC:MAY BE ABSORBED
W/SAND, CLAY, EARTH/FLOOR ABSORB. EYE PROT:FULL LGTH FSHLD . OTHER
PROT EQUIP:HYPERSENSITIVE PERS SHOULD USE PROT CREAM. IN AREAS
WHERE EXPLO HAZS EXIST, WORKMENT SHOULD BE (ING 2)

Boiling Pt:B.P. Text:300F,149C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:1.2
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:51.9

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPARKS, ELECTRICAL
EQUIPMENT & OPEN FLAME.
Hazardous Decomposition Products:BY FIRE: CO*2, CO & VARIOUS
HYDROCARBONS.

Waste Disposal Methods:WASTE MATL MUST BE DISPOSED OF I/A/W FED, STATE
& LOC ENVIRON CONTROL REGS. INCIN IS PREF METHOD. EMPTY CNTNRS MUST
BE HNDLD W/CARE DUE TO PRODUCT RESIDUE. DECONTAMINATE CNTNRS PRIOR
TO DISP. DO NOT H EAT/CUT EMPTY CNTNR W/ELECTRIC OR GAS TORCH.

======================================================================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.