Product ID:CENTARI ACRYLIC ENAMEL, 736
MSDS Date:04/15/1987
FSC:8010
NIIN:00N080579
MSDS Number: CFSFP

EI DUPONT DE NEMOURS & CO INC

CHESTNUT RUN PLAZA
WILMINGTON, DE 19880-0709
US

Emergency Phone: 800-441-3637;800-424-9300(CHEMTREC)

Info Phone: 800-441-7515

Cage: EO716

EI DUPONT DE NEMOURS CO/AUTOMOTIVE PRODS

WILMINGTON, DE 19898 US

Telephone: (800) 441-7515

Cage: EO716

8 @

CAS: 123-86-4

RTECS: AF7350000

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM; 200 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-BUTANONE; (METHYL ETHYL KETONE) (SARA 313) (CERCLA) VP

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM; 300 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

36.7 @ 20C

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (PROPYLENE

CAS: 108-65-6

RTECS: AI8925000

OSHA PEL N/K

ACGIH TLV: N/K

25 @ 20C

CAS: 1330-20-7

RTECS: ZE2100000

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM; 150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC

CAS: 64742-95-6

RTECS: WF3400000

OSHA PEL N/K

ACGIH TLV: N/K

15 @ 20C

CAS: 64742-89-8

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

NONE @ 20C

OSHA PEL N/K

ACGIH TLV: N/K

NONE @ 20C

OSHA PEL N/K

ACGIH TLV: N/K

4.0-6.0 LBS/GAL

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

(IE SHORTEN TIME OF ONSET) PERIPHERAL NEUROPATHY

RTECS: 9999999ZZ

BY ITSELF HAS NOT BEEN SHOWN TO CAUSE PERIPHERAL

RTECS: 9999999ZZ

TOLUENE APPEARS ON THE NAVY LIST OF OCCUP CHEM

RTECS: 9999999ZZ

CONCERNING LATEST HAZ LIST & SAFE HNDLG & EXPOS

RTECS: 9999999ZZ

INJURY. HIGH AIRBORNE LEVELS PRDCED IRREGULAR

RTECS: 9999999ZZ

MAY CAUSE

RTECS: 9999999ZZ

HIGH CONCS HAVE CAUSED

RTECS: 9999999ZZ

LIVER & KIDNEY INJURY. CAN BE ABSORBED THRU SKIN IN

RTECS: 9999999ZZ

WORKERS HAVE NOT SHOWN SIGNIFICANT INCRS OF KIDNEY

RTECS: 9999999ZZ

DEACTIVATE ISOCYANATE CONTAINING SPILLS WITH

RTECS: 9999999ZZ

0-10% AMMONIA; 2-5% DETERGENT; BALANCE WATER.

RTECS: 9999999ZZ

TYPICAL OR IF PROPER RESP FIT IS NOT POSSIBLE,

RTECS: 9999999ZZ

RESP (TC-19C). REFER TO HARDENER LABEL AND MSDS FOR

RTECS: 9999999ZZ

DIRECTIONS FOR RESP USE; DO NOT PERMIT ANYONE W/OUT

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:GEN EFTS: INGEST:GI DISTRESS.
INHAL:MAY CAUSE NOSE & THROAT IRRIT. RPTD & PRLNGD OVEREXP TO SOLVS
MAY LEAD TO PERM BRAIN & NERVOUS SYS DMG. EYE WATERING, HDCHS,
NAUS, DIZZ & LOSS OF COORD ARE SIGNS TH AT SOLV LEVELS ARE TOO
HIGH. THESE PRODS MAY BE USED IN COMBINATION W/HARDENER WHICH CNTNS
ISOCYANATE. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CARBON BLACK: IARC MONOGRAPHS, VOL 65,
PG 24-27, 1995:GROUP 2B.
Effects of Overexposure:HLTH HAZ: EXPOS TO ISOCYANATES MAY CAUSE
ASTHMA-LIKE RXNS W/SHORTNESS OF BRTH, WHEEZ, COUGH/LUNG SENSIT.
THIS EFT MAY BE DELAYED SEVERAL HRS AFTER EXPOS. INDIVIDUALS W/LUNG
OR BRTHG PROBS OR PRIOR RXN TO ISOCYANATES MUST NOT BE EXPOSED TO
VAPS/SPRAY MIST OF PROD. SKIN/EYE CNTCT:MAY CAUSE IRRIT/BURNING OF
EYES. (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INGEST: IN THE UNLIKELY EVENT OF INGESTION, CALL MD
IMMEDIATELY AND HAVE NAMES OF INGREDIENTS AVAILABLE. INHAL: IF
AFFECTED BY INHALATION OF VAPOR OR SPRAY MIST, REMOVE TO FRESH AIR.
IF BREATHING DIFF ICULTY PERSISTS OR OCCURS LATER, CONSULT MD.
EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES; CALL MD. SKIN: WASH WITH SOAP AND WATER. IF IRRITATION
OCCURS, CONTACT MD.

Flash Point Method:CC
Flash Point:>73F,>23C
Lower Limits:0.8%
Upper Limits:13.1%
Extinguishing Media:WATER SPRAY, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER FROM FOG NOZZLES MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE FL PT, EMITS FLAMMABLE
VAPS WHICH, WHEN MIXED W/AIR, CAN BURN OR BE EXPLOSIVE. FINE MISTS
OR SPRAYS MAY BE FLAMMABLE AT TEMPS BELOW FL PT.

Spill Release Procedures:VENT AREA. REMOVE IGNIT SOURCES. PVNT SKIN
CNTCT & BRTHG VAP. WEAR PROPERLY FITTED VAP/PARTICULATE RESP(NIOSH
TC-23C). IF MATL HAS BEEN ACTIVATED W/ISOCYANATE, WEAR POS PRESS,
SUPPLIED-AIR RESP (NIOSH TC-19C). CONFINE & REMOVE W/INERT
ABSORB.(ING 21)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, SPKS & FLAME. CLOSE CONTAINER AFTER EACH USE. GROUND
CONTAINERS WHEN POURING. DO NOT STORE ABOVE 120F.
Other Precautions:DO NOT SAND, FLAME CUT, BRAZE OR WELD DRY COATING
WITHOUT A NIOSH APPROVED RESPIRATOR OR APPROPRIATE VENTILATION.
WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR SMOKING.

Respiratory Protection:DO NOT BREATHE VAPS/MISTS. WEAR PROPERLY FITTED
NIOSH APPRVD PAINT SPRAY RESP (TC-23C) DURING APPLICATION & UNTIL
ALL VAP & SPRAY MIST ARE EXHAUSTED. IN CONFINED SPACES OR IN
SITUATIONS WHERE CONTINUO US SPRAY OPERATIONS ARE (ING 23)
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME AND PATTERN TO
KEEP CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
COVERALLS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT: 48.2-67.2. EFTS OF OVEREXP: RPTD/PRLNGD LIQ CNTCT MAY CAUSE
SKIN IRRIT W/DISCOMFORT & DERM. SPECIFIC EFTS: BUTYL
ACETATE:EXTREMELY HIGH CONCS HAVE CAUSED BLOOD CHGS & WEAK IN LAB
ANIMALS. MET HYL ETHYL KETONE (MEK):HIGH CONCS HAVE CAUSED
EMBRYOTOXIC EFTS IN LAB ANIMALS. MEK HAS BEEN SHOWN TO POTENTIATE
(ING 12)

Boiling Pt:B.P. Text:>54F,>12C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.94-1.31
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORSEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SMOKE, OXIDES OF HEAVY METALS LISTED IN INGREDIENT SECTION.

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED
CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.