Product ID:ULTRA SET CERAMIC NS 5 GALLON, A19905
MSDS Date:08/10/1994
FSC:8010
NIIN:00N083504
MSDS Number: CGQMK

BOSTIK INC

BOSTON ST
MIDDLETON, MA 01949
US

Emergency Phone: 800-227-0332

Info Phone: 508-777-0100

Cage: EO689

BOSTIK INC.

MIDDLETON, MA 01949 US

Telephone: 978-777-0100/800-227-0332

Cage: 5W425

BENZENE, 2,4-DIISOCYANATO-1-METHYL-; (2,4-TOLUENE

CAS: 584-84-9

RTECS: CZ6300000

Fraction By Weight: 0.6%

OSHA PEL 0.02 PPM, C

ACGIH TLV: 0.005 PPM; 0.02 STEL

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

BENZENE, 2,6-DIISOCYANATO-1-METHYL-; (2,6-TOLUENE

CAS: 91-08-7

RTECS: CZ6310000

Fraction By Weight: 0.2%

OSHA PEL N/K

ACGIH TLV: N/K

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

CALCIUM CARBONATE

CAS: 1317-65-3

RTECS: EV9580000

Fraction By Weight: 32.3%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

SILICA, CRYSTALLINE - QUARTZ; (QUARTZ)

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 0.5%

OSHA PEL N/K

ACGIH TLV: 0.1 MG/M3 RDUST

SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (LIGHT AROMTIC

CAS: 64742-95-6

RTECS: WF3400000

Fraction By Weight: 1.0%

OSHA PEL N/K

ACGIH TLV: N/K

XYLENE (SARA 313) (CERCLA)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 3.08%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM; 150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

BENZENE, ETHYL-; (ETHYL BENZENE) (SARA 313)

CAS: 100-41-4

RTECS: DA0700000

Fraction By Weight: 0.5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM; 125 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

IARC MONOGRAPHS, VOL 68,

RTECS: 9999999ZZ

THAT THIS PRODUCT WOULD NOT BE CLASSIFIED

RTECS: 9999999ZZ

AT THE TIME THIS MSDS WAS CREATED.

RTECS: 9999999ZZ

IMPERVIOUS PLASTIC GLOVES.

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGESTION/ABSORPTION: NO HAZARD KNOWN
AT THIS TIME. INHALATION: MAY BE FATAL IF INHALED. SYMPTOMS OF
OVEREXPOSURE ARE DRY THROAT, SINITUS, BREATHING DIFFICULTIES,
BRONCHITIS, COUGHING, NAUSEA. CONTACT : INGREDIENT CAUSES EYE
AND/OR SKIN IRRITATION. POSSIBLE EYE INJURY. CHRONIC: LONG TERM
OVEREXPOSURE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:TOLUENE DIISOCYANATE(2,4)/(2,6): IARC
MONOGRAPHS, SUPPLEMENT, VOL 7, PG 56, 1987:GROUP 2B. SILICA,
CRYSTALLINE- (ING 8)
Effects of Overexposure:HLTH HAZ: TO THE HAZARDOUS MATERIALS IN THIS
PRODUCT HAVE BEEN ASSOCIATED WITH LUNG IMPAIRMENT, RESPIRATORY
SENSITIZATION. TARGET ORGANS: RESPIRATORY SYSTEM, SKIN, LUNG.
Medical Cond Aggravated by Exposure:RESPIRATORY DISEASE,
CONJUNCTIVITIS.

First Aid:INGEST: CALL MD IMMEDIATELY . SKIN: FLUSH W/COPIOUS AMOUNTS
OF WATER. CALL MD . INHAL: IF INHALED, REMOVE TO FRESH AIR. IF NOT
BREATHING GIVE ARTIFICIAL RESPIRATION, PREFERABLY MOUTH TO MO UTH.
IF BREATHING IS DIFFICULT, GIVE OXYGEN. EYES: IMMEDIATELY FLUSH
EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. CALL MD.

Flash Point Method:CC
Flash Point:145F,63C
Lower Limits:1.03%
Upper Limits:6.73%
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.

Spill Release Procedures:SWEEP UP MATERIAL USING SWEEPING COMPOUND AND
PACKAGE THE SOLID PRODUCT IN STEEL DRUMS WHICH ARE IN GOOD
CONDITION. THOROUGHLY CLEAN AREA WHERE SPILL OCCURRED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN COOL LOCATION (60-80F) AWAY
FROM SUNLIGHT AND ANY SOURCE OF HEAT, SPARKS OR FLAME. KEEP
CONTAINER TIGHTLY CLOSED WHEN NOT BEING USED.
Other Precautions:USE WITH ADEQUATE VENTILATION. AVOID PROLONGED OR
REPEATED BREATHING OF VAPORS. AVOID SKIN CONTACT. USE IN AN AREA
FREE FROM FLAME AND SPARKS.

Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST IS PREFERRED TO KEEP VAPORS/PARTICULATES
BELOW TLV VALUE. MECHANICAL AREAWIDE VENTILATION IS ACCEPTABLE.
Protective Gloves:NEOPRENE RUBBER, NITRILE, (ING 11)
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PRODS: INCLUDE CARBON DIOXIDE, CARBON MONOXIDE, WATER VAPOR,
OXIDES OF NITROGEN OR A WIDE VARIETY OF INNOCUOUS OR TOXIC FUMES.
ALDEHYDES, HYDROGEN CHLORIDE, HYDROGEN CYANIDE, SULFUR DIOXIDE ,
TOLUENE DIISOCYANATE MAY ALSO BE PRODUCED.

Boiling Pt:B.P. Text:>277F,>136C
Vapor Pres:9
Vapor Density:3.81
Spec Gravity:1.35
Solubility in Water:0.0%
Appearance and Odor:AN OFF WHITE PASTE WITH A SOLVENT ODOR.
Percent Volatiles by Volume:7.8

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ALKALIS, ACIDS, ALCOHOLS, AMINES, WATER, TEMPERATURES
>200F.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:UNKNOWN DUE TO COMPLEX NATURE OF THIS
MATL. FUMES FROM COMPLETE OR INCOMPLETE COMBUSTION OF THIS MATL MAY
(SUPDAT)
Conditions to Avoid Polymerization:CAN OCCUR WITH WATER, AMINES,
ALKALIS, ETC.

Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL RULES.
BE AWARE THAT STATE & LOCAL REQS MAY DIFFER WIDELY DEPENDING ON
LOCATION & MAY IN MANY CASES BE DIFFERENT FROM FEDERAL RULES. WHEN
INTENDING TO DISPOSE O F THIS MATERIAL, THE USER IS ADVISED (ING 9)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.