Product ID:FIXMASTER URETHANE SEALANT, 97183
MSDS Date:03/12/1997
FSC:8030
NIIN:00N068501
MSDS Number: CHJCW

FEL-PRO CHEMICAL PRODUCTS LP

6120 EAST 58TH AVE
COMMERCE CITY, CO 80022
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 303-289-5651

Preparer: CATHY GRIFFITH

Cage: GO402

FEL-PRO CHEMICAL PRODUCTS LP

COMMERCE CITY, CO 80022 US

Telephone: 303-289-5651

Cage: FELPR

STODDARD SOLVENT; (MINERAL SPIRITS)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 10-30%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

CALCIUM OXIDE

CAS: 1305-78-8

RTECS: EW3100000

Fraction By Weight: 5-10%

OSHA PEL 5 MG/M3

ACGIH TLV: 2 MG/M3

SILICA, CRYSTALLINE - QUARTZ; (SILICON DIOXIDE (QUARTZ))

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 0.1-1.0%

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 0.1 MG/M3 RDUST

TALC

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 5-10%

OSHA PEL 20 MPPCF

ACGIH TLV: 2 MG/M3 RDUST

FILLERS (NON-HAZARDOUS)

OSHA PEL N/K

ACGIH TLV: N/K

CALCIUM CARBONATE

CAS: 1317-65-3

RTECS: EV9580000

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

TUBERCULOSIS, SCLERODERMA, &/OR INCRD INCIDENCE OF

RTECS: 9999999ZZ

DMG. THIS PROD CONTAINS ENCAPSULATED TALC. NO EXPOS

RTECS: 9999999ZZ

IT SHOULD BE NOTED, HOWEVER, THAT RPTD & PRLNG OCCUP

RTECS: 9999999ZZ

PNEUMOCONIOSIS. THESE CONDITIONS MAY EXIST WITH OR

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: SEV IRRIT. CONT MAY CAUSE
INJURY TO EYE TISS IF NOT REMOVED PROMPTLY. SKIN: FREQUENT/PRLNG
CONT MAY IRRITATE SKIN & CAUSE SKIN RASH (DERM). INHAL: VAPS MAY
HAVE STRONG OFFENSIVE ODOR WHIC H MAY CAUSE HDCH, NAUS & VOMIT.
PRLNG INHAL MAY BE HARMFUL. CAN CAUSE SEV RESP IRRIT. (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC MONO,
VOL 68, 1997: GROUP 1. NTP 7TH ANNUAL RPT ON CARCINS, 1994: ANTIC
TO BE CARCIN.
Effects of Overexposure:HLTH HAZ: INGEST: MAY CAUSE NAUS & VOMIT.
IRRITATING TO MOUTH, THROAT & STOM, W/NAUS. CHRONIC: CONTAINS
ENCAPSULATED SILICON DIOXIDE (QUARTZ, SILICA). NO EXPOS TO FREE
RESPIRABLE SILICA IS ANTIC DURIN G NORM USE OF THIS PROD. IT SHOULD
BE NOTED, HOWEVER, THAT FREE RESPIRABLE SILICA MAY BE RELEASED BY
GRINDING (SUP DAT)
Medical Cond Aggravated by Exposure:PREEXISTING PULMONARY AND
DERMATOLOGICAL DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO HAZARDOUS
COMPONENTS.

First Aid:EYES: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN. GET
IMMED MED ATTN. SKIN: REMOVE CONTAM CLTHG. WASH SKIN W/SOAP &
WATER. GET MED ATTN. INHAL: REMOVE TO FRESH AIR. MED PERS MAY ADMIN
OXYGEN IF BRTHG IS DFCLT. SEEK MED ATTN IF SYMPSPERSIST. INGEST:
SWALLOWING <1 OZ WILL NOT CAUSE SIGNIFICANT HARM. FOR LARGER AMTS,
DO NOT INDUCE VOMIT, BUT GIVE 1-2 GLASSES OF WATER TO DRINK & GET
MED ATTN.

Flash Point Method:SCC
Flash Point:200F,93C
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP . USE
WATER TO COOL EXPOS CONTRS. WATER STEAM DIRECTED INTO FIRE MAY
CAUSE FROTHING W/SUBSEQUENT SPREAD OF FLAME.
Unusual Fire/Explosion Hazard:CLSD CONTRS MAY RUPTURE/EXPLODE (DUE TO
PRESS BUILD-UP) WHEN EXPOS TO EXTREME HEAT. IRRITATING &/OR TOX
GASES/FLAMES MAY BE GENERATED BY THERMAL DECOMP/COMBUST.

Spill Release Procedures:RECLAIM CLEAN MATL. WEAR APPROP PROT EQUIP
DURING CLEANUP. ABSORB W/INERT MATL, SUCH AS CLAY. SWEEP/SHOVEL
INTO LOOSELY-COVERED WASTE CONTR & REMOVE TO APPROP WASTE AREA.
DISP OF I/A/W FED, STATE, & L OC REGS. DECONTAM/DISP OF CONTAM
CLTHG & ARTICLES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:FOLLOW ALL MSDS/LABEL PRECAUTIONS EVEN
AFTER CONTAINER IS EMPTIED BECAUSE IT MAY RETAIN PRODUCT RESIDUES.
AVOID BREATHING DUST, VAPOR, MIST OR GAS.
Other Precautions:AVOID CONT W/SKIN & EYES. FOR INDUSTRIAL USE ONLY.
KEEP AWAY FROM SOURCES OF IGNITION. KEEP OUT OF REACH OF CHILDREN.
DO NOT REUSE EMPTY CONTAINERS W/OUT COMMERCIAL CLEAN/RECONDITION.
FOLLOW ALL MSDS/ LABEL PREC EVEN AFTER CONTR IS EMPTIED.

Respiratory Protection:NONE NORM REQUIRED UNDER GEN VENT. IF TLV/PEL IS
EXCEEDED, IF USE IS PERFORMED IN POORLY-VENTILATED SPACE, OR IF
INHAL EFTS OCCUR, USE NIOSH APPROVED VAP CARTRIDGE RESP I/A/W
APPLIC HEALTH & SAFETY RE GS & MANUFACTURER'S RECOMMENDATIONS.
Ventilation:GENERAL VENT USUALLY ADEQUATE. LOCAL EXHAUST AS NEEDED TO
CONTROL VAPOR/DUST LEVELS TO BELOW LOWEST COMPONENT TLV.
Protective Gloves:NITRILE, PVA, VITON GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . WEAR CLEAN CLOTHING TO COVER SKIN.
Work Hygienic Practices:FOLLOD GOOD GENERAL INDUSTRIAL SAFETY PRACTICES
DURING USE. DO NOT SMOKE OR EAT DURING USE.
Supplemental Safety and Health
MATLS TO AVOID: CNDTNS RELEASES CONSIDERABLE HEAT & MAY RELEASE ACRID
FUMES. WATER. EFTS OF OVEREXP: OR MACHINING OF CURED CMPD. INHAL OF
FREE RESPIRABLE SILICA MAY CAUSE SILICOSIS/OTHER SERIOUS DELAY ED
LUNG INJURY. RECENT STUDIES HAVE ALSO SUGGESTED THAT PERS
W/SILICOSIS ARE AT INCRD RISK OF DEVELOPING (ING 8)

Boiling Pt:B.P. Text:>318F,>159C
Vapor Pres:<2 @ 20C
Vapor Density:HVR/AIR
Spec Gravity:1.8969
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:REACTS SLOWLY
Appearance and Odor:GRAY LIQUID WITH MILD SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG LEWIS/MINERAL ACIDS. STRONG BASES/OXIDANTS. RXN W/AMINES &
MERCAPTANS IN LGE AMTS/UNDER UNCONTROLLED (SUP DAT)
Stability Condition to Avoid:EXPOSURE TO MOISTURE.
Hazardous Decomposition Products:OXIDES OF CARBON. VARIOUS
HYDROCARBONS. IRRITATING ALDEHYDES AND KETONES.

Waste Disposal Methods:REVIEW ALL CURRENT FEDERAL, STATE, AND LOCAL
REGULATIONS REGARDING HEALTH AND DISPOSAL FOR APPROPRIATE DISPOSAL
PROCEDURES. INCINERATION PREFERRED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.