Product ID:ABLEBOND 8175, 83-4012
MSDS Date:10/23/1996
FSC:8040
NIIN:00N088132
MSDS Number: CHNXR

ABLESTIK LABORATORIES

20021 SUSANA ROAD
RANCHO DOMINGUEZ, CA 90221
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 310-764-4600

Cage: 9V874

ABLESTIK LABS SUB OF NATIONAL STARCH AND CHEMICAL

COMPTON, CA 90221 US

Telephone: 310-764-4600

Cage: 21109

EPOXY/RUBBER COPOLYMER

CAS: 68610-73-1

Fraction By Weight: 1-10%

OSHA PEL 0.01 MG/M3

ACGIH TLV: 0.1 MG/M3

1,4-BIS(2,3-EPOXYPROPOXY)BUTANE

CAS: 2425-79-8

RTECS: EJ5100000

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: N/K

EPOXY RESIN; (DICLYCIDYLETHER OF BISPHENOL-F)

CAS: 54208-63-8

Fraction By Weight: 1-15%

OSHA PEL N/K

ACGIH TLV: N/K

SILVER (SARA 313) (CERCLA)

CAS: 7440-22-4

RTECS: VW3500000

Fraction By Weight: 75-90%

OSHA PEL 0.01 MG/M3

ACGIH TLV: 0.1 MG/M3

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

<140 G/L.

RTECS: 9999999VO

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE IRRITANT. HARMFUL IF
SWALLOWED. EYE:IRRITATING AND WILL INJURE TISSUE IF NOT REMOVED
PROMPTLY. SKIN CONTACT:IRRITATING. MAY BE ABSORBED THROUGH SKIN.
INHALATION:IRRITATING AND/OR TOXIC VAPOR S MAY BE RELEASED AT
ELEVATED TEMPERATURES. VAPORS MAY BE IRRITATING TO RESPIRATORY
SYSTEM AND NASAL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:PASSAGES. IF CURED PRODUCT IS TO BE
SANDED OR GROUND, WET SANDING IS RECOMMENDED TO ELIMINATE AIRBORNE
DUST. APPROPRIATE NIOSH APPROVED RESP PROT IS SUGGESTED.
INGEST:EFFECTS HAVE NOT BEEN EV ALUATED BUT ARE ASSUMED TO CAUSE
NAUSEA& VOMITING. CHRONIC:PRLNG/RPTD CONT W/SKIN CAN CAUSE SENSIT.
TARGET ORGANS:SKIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES:IMMED FLUSH W/LG AMTS OF WATER FOR AT LST 15 MINS,
LIFTING UPPER & LOWER LIDS. GET PROMPT MED ATTN. SKIN:FLUSH EXPOS
AREAS THORO W/SOAP & WATER UNTIL ALL CHEM IS REMOVED. REMOVE CONTAM
CLTHG & LA UNDER BEFORE REUSE. IF IRRIT PERSISTS, GET MED ATTN.
INHAL:REMOVE TO FRESH AIR. GET MED ATTN IF IRRIT PERSISTS.
INGEST:TREAT SYMPTOMATICALLY & SUPPORTIVELY. GET MED ATTN. DO NOT
ATTEMPT TO (SUPP DATA)

Flash Point Method:TCC
Flash Point:280F,138C
Extinguishing Media:WATER FOG, FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.

Spill Release Procedures:SCRAPE UP & PLACE IN SUITABLY LABELED
CONTAINER FOR DISPOSAL. FOR SAFETY & ENVIRONMENTAL PRECAUTIONS,
PLEASE REVIEW ENTIRE MSDS FOR NECESSARY INFORMATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORAGE TEMP: -40F. SPECIAL
SENSITIVITY: HEAT. PRODUCT CAN ONLY BE USED FOR THIN BOND LINE
APPLICATIONS OR RAPID EXOTHERMIC CURING REACTION MAY RSLT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NIOSH APPROVED RESPIRATOR IF REQUIRED. NIOSH
APPROVED SELF-CONTAINED BREATHING APPARATUS IN EMERGENCY &
NON-ROUTINE SITUATIONS.
Ventilation:VENT CURING EVEN TO OUTDOORS.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . EMPLOYEE MUST WEAR APPROP CLTHG & EQUIP TO PREVENT ANY
(SUPP DATA)
Work Hygienic Practices:IF CONT HAS OCCURRED, WASH W/SOAP & WATER
BEFORE EATING. IF PROD IS SPILLED ON CLOTHES, REMOVE IMMED &
LAUNDER (SUPDAT)
Supplemental Safety and Health
HAZ DECOMP PROD:COMBUST. THERMAL DECOMP PRODS ARE HAZ &/OR TOX. FIRST
AID PROC:GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. OTHER
PROT EQUIP:POSSIBILITY OF SKIN CONTACT W/THIS SUBSTANCE. HYGIENE P
RACT:BEFORE REUSE.

Spec Gravity:4.4 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:SILVER PASTE MIXTURE; ODORLESS.
Percent Volatiles by Volume:NIL

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS & ALKALINE MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN & UNKNOWN ORGS. POSS FORM OF CYANIDE CMPDS UPON
INCOMPLETE (SUPDAT)

Waste Disposal Methods:WASTE DISPOSAL SHOULD BE I/A/W EXISTING FEDERAL,
STATE & LOCAL ENVIRONMENTAL REGULATIONS. EMPTY CONTAINERS MAY
CONTAIN PRODUCT RESIDUE; FOLLOW MSDS & LABEL WARNINGS EVEN AFTER
THEY HAVE BEEN EMPTIED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.