Product ID:MECHANICALL SPRAY (M5S-6)
MSDS Date:06/01/1992
FSC:NIIN:Submitter:F BT
Status Code:A
MSDS Number: CJCYZ

Emergency Phone: 619-451-1799

Preparer: MARK K LOHKEMPER

Cage: 55403

Telephone: 858-486-8388

Cage: 55403

HYDROCARBON SOLVENT

CAS: 64742-88-7

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

DYMEL 152A

CAS: 75-37-6

RTECS: KI1410000

MECHANICALL M100L

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INHALATION: VAPOR IS HEAVIER THAN AIR
& CAN CAUSE SUFFOCATION BY REDUCING OXYGEN AVAILABLE FOR BREATHING.
IRRITATION OF NOSE & THROAT, NERVOUS SYSTEM DEPRESSION, LUNG
DISORDERS. EYES/SKIN: MILD IRRITA TION. INGESTION: LOW DEGREE OF
TOXICITY. IRRITATION OF DIGESTIVE TRACT, NERVOUS SYSTEM DEPRESSION.
ASPIRATION HAZARD. MATERIAL CAN ENTER LUNGS DURING
SWALLOWING/VOMITING & CAUSE LUNG INFLAMMATION & DA MAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, SUFFOCATION, HEADACHE,
LIGHTHEADEDNESS, DIZZINESS, SHORTNESS OF BREATH, DROWSINESS,
ASTHMA-LIKE CONDITIONS, STINGING, TEARING & REDNESS, CARDIAC
IRREGULARITIES, NARCOSIS
Medical Cond Aggravated by Exposure:ASTHMA-LIKE CONDITIONS.

First Aid:INHALATION: MOVE AWAY FROM EXPOSURE & INTO FRESH AIR. IF NOT
BREATHING GIVE CPR. IF BREATHING DIFFICULT GIVE OXYGEN. EYES: HOLD
EYELIDS APART & FLUSH W/CLEAN WATER FOR 15 MINS. SKIN: CLEAN W/MILD
SOAP & WATER. INGESTION: ASPIRATION HAZARD. DON'T INDUCE
VOMITING/GIVE ANYTHING BY MOUTH, DUE TO THIS MATERIALS ABILITY TO
ENTER THE LUNGS & CAUSE SEVERE LUNG DAMAGE. IF DROWSY/UNCONSCIOUS
PLACE ON THE LE FT SIDE W/HEAD DOWN. DON'T LEAVE VICTIM UNATTENDED.
OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:TCC
Flash Point:=51.7C, 125.F
Lower Limits:1
Upper Limits:8
Extinguishing Media:DRY CHEMICAL, CO2, HALON, POLAR/ALCOHOL FOAM/WATER
SPRAY IS RECOMMENDED. WATER MAY BE INEFFECTIVE.
Fire Fighting Procedures:WEAR APPROPRIATE PROTECTIVE EQUIPMENT
INCLUDING RESPIRATORY PROTECTION. MOVE UNDAMAGED CONTAINERS FROM
FIRE AREA. IF IT CAN BE DONE WITHOUT RISK. AVOID SPREADING BURNING
LIQUID W/WATER USED FOR COOLIN G PURPOSES. IF CONTAINER IS NOT
PROPERLY COOLED, IT MAY EXPLODE IN THE HEAT OF A FIRE.
Unusual Fire/Explosion Hazard:MATERIAL IS FLAMMABLE & MAY BE IGNITED BY
HEAT, SPARKS, FLAME/OTHER SOURCES OF IGNITION. VAPORS MAY TRAVEL
CONSIDERABLE DISTANCES TO A SOURCE OF IGNITION WHERE THEY MAY
IGNITE, FLASHBACK/EXPLODE. VAPO R/AIR EXPLOSION HAZARD
INDOORS/OUTDOORS/IN SEWERS. VAPORS ARE HEAVIER THAN AIR & MAY
ACCUMULATE IN LOW AREAS.

Spill Release Procedures:FLAMMABLE. KEEP AWAY FROM ALL SOURCES OF
IGNITION & HOT SURFACES. SPILLED MATERIAL MAY BE ABSORBED INTO ANY
ABSORBENT MATERIAL. WEAR APPROPRIATE PROTECTIVE EQUIPMENT INCLUDING
RESPIRATORY PROTECTION A S CONDITIONS WARRANT. VENTILATE AREA UNTIL
ODOR IS GONE. CLEAN UP OILY RESIDUE W/ANY STANDARD SOAP/DETERGENT
SOLUTION.

Handling and Storage Precautions:DON'T EXPOSE ANY AEROSOL CAN TO
SUNLIGHT/TEMPERATURES >120F. ALL AEROSOL CAUTIONS APPLY & USE IN
WELL VENTILATED AREAS. USE & STORE IN COOL, DRY, WELL VENTILATED
AREAS AWAY FROM HEAT, HOT SURFACES & A LL IGNITION SOURCES. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:INDOOR STORAGE SHOULD MEET OSHA STANDARDS &
APPROPRIATE CODES. AS W/ANY CHEMICAL PREPARATION USE ONLY AS
DIRECTED & WASH HANDS AFTER USE. AVOID BREATHING VAPORS & CONTACT
W/SKIN/EYES. DON'T BREATHE SM OKE/FUMES. WEAR APPROPRIATE
PROTECTIVE EQUIPMENT.

Respiratory Protection:NOT NECESSARY UNLESS USED IN AN UNVENTILATED
AREA/HIGH CONCENTRATIONS.
Ventilation:KEEP EXPOSURE BELOW LIMITS. KEEP WINDOWS OPEN. USE LOCAL
EXHAUST WHEN USED REPEATEDLY. ELECTRICAL SYSTEMS SAFE FOR SUCH
LOCATIONS MUST BE USED.
Protective Gloves:NOT NECESSARY BUT ADVISED
Eye Protection:REQUIRED WHEN USING AEROSOLS
Supplemental Safety and Health
BOILING POINT: 346F TO 406F.

Vapor Pres:1.2
Vapor Density:5.2
Spec Gravity:0.759
Evaporation Rate & Reference:(N-BU AC=1):<0.1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREEN IN COLOR, SLIGHT ETHEREAL/PETROLEUM ODOR

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & BASES, OXIDIZING AGENTS & SELECTED AMINES
Stability Condition to Avoid:OPEN FLAMES/HIGH TEMPERATURES, SOURCES OF
IGNITION
Hazardous Decomposition Products:CO, CO2
Conditions to Avoid Polymerization:OPEN FLAMES/HIGH TEMPERATURES

Waste Disposal Methods:HAZARDOUS WASTE #'S: F001 & F002. DISPOSE OF
IAW/LOCAL, STATE & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:MAGNESIUM NITRATE, 5.1, UN1474, III.

SARA Title III Information:311/312:( ACUTE, CHRONIC, FIRE). SECTION
313: NO.
Federal Regulatory Information:ON TSCA INVENTORY.
State Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.