Product ID:2100 WEATHERSEAL FIBERED ROOF COATING
MSDS Date:01/18/1999
FSC:NIIN:Submitter:F BT
Status Code:A
MSDS Number: CJDGH

GARDNER ASPHALT CORP

4161 E 7TH AVENUE
TAMPA, FL 33605
US

Emergency Phone: (800)424-9300

Cage: 0VZ30

GARDNER ASPHALT CORP

5449 TAMPA, FL 33605 US

Telephone: 800-237-1155/813-248-2101

Cage: 0VZ30

PETROLEUM ASPHALT

CAS: 8052-42-4

RTECS: CI9900000

ACGIH TLV: 5 MG/M3

STODDARD SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

OSHA PEL 2900 MG/M3;500 PPM

ACGIH TLV: 525 MG/M3;100 PPM

CELLULOSE FIBER

MINERAL FILLER

CAS: 7631-86-9

WATER

CAS: 7732-18-5

RTECS: ZC0110000

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION. SKIN:
MODERATE IRRITATION. INHALATION: IRRITATION OF NOSE/THROAT,
ASPHYXIATION. INGESTION: ASPIRATION HAZARD
Effects of Overexposure:IRRITATION, REDNESS, TEARING, BLURRED VISION,
DEFATTING, DERMATITIS, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA,
HEADACHE, UNCONSCIOUSNESS.

First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. SKIN: WASH
EXPOSED AREA W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. IF
BREATHING IS DIFFICULT ADMINISTER OXYGEN, IF BREATHING HAS STOPPED
GIVE CP R. KEEP PERSON WARM & QUIET. INGESTION: ASPIRATION HAZARD.
DON'T INDUCE VOMITING. NOTE TO PHYSICIAN: PERFORM GASTRIC LAVAGE IN
ACCORDANCE W/PROCEDURES FOR INGESTION OF PETROLEUM PRODUCTS. OBTAIN
MEDIC AL ATTENTION IN ALL CASES.

Flash Point Method:TCC
Flash Point:=40.6C, 105.F
Autoignition Temp:>232.2C, 450.F
Lower Limits:0.9
Upper Limits:6
Extinguishing Media:DRY CHEMICAL & CO2/UNIVERSAL TYPE FOAM & WATER FOG
ARE EFFECTIVE BUT MAY CAUSE FROTHING.
Fire Fighting Procedures:DON'T USE WATER. PETROLEUM BASED COMPOUNDS
FLOAT ON WATER. FIGHT AS A FUEL OIL FIRE.

Spill Release Procedures:SHUT OFF & ELIMINATE ALL IGNITION SOURCES.
KEEP PEOPLE AWAY. RECOVER FREE PRODUCT. ADD SAND, EARTH/OTHER
SUITABLE ABSORBENTS TO SPILL AREA. MINIMIZE SKIN CONTACT &
BREATHING VAPORS. VENTILATE CONFINED SPACES. OPEN ALL WINDOWS &
DOORS. KEEP PRODUCT OUT OF SEWERS & WATER COURSES BY
DIKING/IMPOUNDING. ADVISE AUTHORITIES IF PRODUCT HAS ENTERED OR MAY
ENTER SEWERS, WATER COURSES/EXTENSIVE LAND AREAS.

Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. KEEP CONTAINERS COOL, DRY & AWAY FROM SOURCES OF IGNITION. USE
W/ADEQUATE VENTILATION. DON'T STORE NEAR HEAT, SPARKS,
FLAME/STRONG OXIDANTS. TO PREVENT FIRE/EX PLOSION RISK FROM STATIC
ACCUMULATION & DISCHARGE, EFFECTIVELY GROUND PRODUCT.
Other Precautions:EMPLOYEES WHO HAVE PROLONGED/REPEATED EXPOSURE SHOULD
WEAR GLOVES & CLOTHING THAT IS IMPERVIOUS TO PETROLEUM SOLVENTS &
ASPHALT COMPONENTS. MATERIAL IS COMBUSTIBLE. ALL ELECTRICAL
EQUIPMENT IN STORAGE /HANDLING AREAS MUST BE INSTALLED PER NFPA
REQUIREMENTS.

Respiratory Protection:AIR CONCENTRATIONS OF FUMES DETERMINE THE LEVEL
OF PROTECTION NEEDED. USE ONLY NIOSH APPROVED RESPIRATORY EQUIPMENT
W/THE LIMITS OF THE PROTECTION FACTORS FOR THAT EQUIPMENT.
Ventilation:USE ONLY W/VENTILATION SUFFICIENT TO PREVENT EXCEEDING
RECOMMENDED EXPOSURE LIMIT/BUILDUP OF EXPLOSIVE CONCENTRATIONS OF
VAPOR IN AIR.
Protective Gloves:CHEMICAL RESISTANT GLOVES SUCH AS
NEOPRENE/NITRILE-BUTADIENE RUBBER GLOVES
Eye Protection:SAFETY GLASSES, SPLASH GOGGLES/FACE SHIELD
Other Protective Equipment:USE EXPLOSION-PROOF EQUIPMENT. NO
SMOKING/OPEN LIGHTS. WEAR CLOTHING IMPERVIOUS TO PETROLEUM SOLVENTS
& ASPHALT COMPONENTS.
Work Hygienic Practices:CLEANSE HANDS THOROUGHLY BEFORE EATING/SMOKING.
MINIMIZE BREATHING VAPORS/MIST. REMOVE/LAUNDER CONTAMINATED
CLOTHING/SHOES BEFORE REUSE. PRODUCT IS READILY REMOVED FROM SKIN
W/WATERLESS HAND CLEANERS.
Supplemental Safety and Health
HANDLING & STORAGE CONT'D: FOR WORK ON TANKS, REFER TO OSHA REGULATION
ANSI Z49.1 & OTHER GOVERNMENTAL & INDUSTRIAL REFERENCES PERTAINING
TO CLEANING, REPAIRING, WELDING/OTHER CONTEMPLATED OPERATIONS.
BOILING PT: 300-390F.

Melt/Freeze Pt:>0.C, 32.F
Vapor Pres:6
Vapor Density:3.9
Spec Gravity:1-1.3
Viscosity:10,000-20,000
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:THICK BLACK COATING W/ PETROLEUM HYDROCARBON
SOLVENT ODOR/APPEARS METALLIC
Percent Volatiles by Volume:<35

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, LIQUID CHLORINE, CONCENTRATED OXYGEN, SODIUM
HYPOCHLORITE/CALCIUM HYPOCHLORITE.
Stability Condition to Avoid:OPEN FLAME
Hazardous Decomposition Products:CO2, CO & NITROGEN OXIDES

Waste Disposal Methods:DISPOSE OF IAW/LOCAL, STATE & FEDERAL
REGULATIONS. EMPTY CONTAINERS RETAIN RESIDUE & CAN BE DANGEROUS.
DON'T PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL, GRIND/EXPOSE TO
HEAT, FLAME, SPARKS/OTHER SOUR CES OF IGNITION, THEY MAY EXPLODE &
CAUSE INJURY/DEATH. DON'T ATTEMPT TO CLEAN SINCE RESIDUE IS DIFF
ICULT TO REMOVE. (SEE SUPP)

Toxicological Information:IN 1994 THE INTERNATIONAL AGENCY FOR RESEARCH
ON CANER RECONFIRMED ITS EARLIER ASSESSMENT THAT STUDIES OF WORKERS
EXPOSED TO ASPHALT PROVIDE INADEQUATE EVIDENCE OF CARCINOGENICITY.
IARC HAS PREVIOUSLY CLASSIFIED ASPHALT AS A GROUP 3 SUBSTANCE, NOT
CLASSIFIABLE AS TO ITS CARCINOGENICITY TO HUMANS.

Transport Information:DOT SHIPPING - LAND: ORM-D.

SARA Title III Information:PERCHLOROETHYLENE & ISOPROPYL ALCOHOL APPEAR
IN SECTION 313 OF THE TOXIC CHEMICALS LIST OF TITLE III OF THE
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT (SARA) OF 1986.
Federal Regulatory Information:ALL INGREDIENTS OF THIS PRODUCT ARE
LISTED ON THE TSCA INVENTORY.
State Regulatory Information:PROPOSITION 65: WARNING, USING THIS
PRODUCT WILL EXPOSE YOU TO A CHEMICAL KNOWN BY THE STATE OF
CALIFORNIA TO CAUSE CANCER.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.