Product ID:AEROSHELL GREASE 22
MSDS Date:04/05/1991
FSC:9150
NIIN:00-149-1592
Status Code:A
MSDS Number: CJGCZ

SHELL OIL COMPANY

PRODUCT SAFETY AND COMPLIANCE
HOUSTON, TX 77210
US

Emergency Phone: 713-473-9461

Info Phone: 713-241-4819

Cage: TO094

SHELL OIL COMPANY

4320 HOUSTON, TX 77210 US

Telephone: 713-241-4819

Cage: TO094

1-DECENE, HOMOPOLYMER, HYDROGENATED

CAS: 68037-01-4

BENTONITE (INORGANIC CLAY)

CAS: 1302-78-9

RTECS: CT9450000

OSHA PEL 5 MG/M3 (DUST)

ACGIH TLV: 5 MG/M3 (DUST)

FATTY ACID AMIDES

CAS: 64754-98-9

OTHER COMPONENTS

Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYE, SKIN (HMIS). ACUTE
- EYE CONTACT: PRODUCT MAY BE MILDLY IRRITATING TO THE EYES. SKIN
CONTACT: PROLONGED OR REPEATED CONTACT MAY CAUSE VARIOUS DISORDERS
SUCH AS DERMATITIS, FOLLICUL ITIS OR OIL ACNE. RELEASE DURING HIGH
PRESSUREUSAGE MAY RESULT IN INJECTION OF GREASE INTO THE SKIN
CAUSING LOCAL NECROSIS. INHALATION: NO SPECIFIC INFORMATION
IDENTIFIED. INGESTION: NO SPECIFIC INFOR MATION IDENTIFIED. CHRONIC
- THIS SPECIFIC PRODUCT HAS NOT BEEN TESTED IN LONG-TERM, CHRONIC
EXPOSURE TESTS. LUBRICATING GREASES ARE GENERALLY CONSIDERED TO BE
OF A LOW ORDER OF ACUTE TOXICITY TO HUM ANS AND EXPERIMENTAL
ANIMALS.
Explanation of Carcinogenicity:NOT CLASSIFIED AS CARCINOGENS BY IARC,
NTP OR OSHA.
Effects of Overexposure:IRRITATION, LOCAL NECROSIS IS EVIDENCED BY
DELAYED ONSET OF PAIN AND TISSUE DAMAGE A FEW HOURS FOLLOWING
INJECTION. SKIN DERMATITIS
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:INHALED: MOVE VICTIM TO FRESH AIR. PROVIDE OXYGEN IF
BREATHING IS DIFFICULT. GET MEDICAL ATTENTION. EYES: FLUSH WITH
WATER FOR 15 MINUTES WHILE HOLDING EYELIDS OPEN. CALL PHYSICIAN.
SKIN: REMOVE CONTA MINATED CLOTHING AND WIPE EXCESS OFF. WASH WITH
SOAP AND WATER OR A WATERLESS HAND CLEANER, FOLLOWED BY SOAP AND
WATER. DO NOT REUSE CLOTHING UNTIL THROUGHLY CLEANED. IF MATERIAL
IS INJECTED UNDER SK IN, GET MEDICAL ATTENTION PROMPTLY TO PREVENT
SERIOUS DAMAGE; DO NOT WAIT FOR SYMPTOMS TO DEVELOP. INGESTION: DO
NOT INDUCE VOMITING. IN GENERAL, NO TREATMENT IS NECESSARY UNLESS
LARGE QUANTITIES ARE INGESTED. HOWEVER, GET MEDICAL ADVICE.

Flash Point Method:PMCC
Flash Point:=235.C, 455.F
Extinguishing Media:USE WATER FOG, DRY CHEMICAL OR CARBON DIOXIDE. DO
NOT USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED ON SURFACE OF WATER.
Fire Fighting Procedures:DON'T ENTER CONFINED FIRE-SPACE WITH OUT
PROPER PROTECTIVE EQUIPMENT INCLUDING, NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED CONTAINERS
SURROUNDING EQUIPMENT AND STRUCTRUES WIT H WATER.

Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPIATE CLEANER.

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES.
Other Precautions:MINIMIZE SKIN CONTACT. WASH THOROUGHLY WITH SOAP AND
WATER AFTER HANDLING AND BEFORE EATING, DRINKING, APPLYING COSMETIC
OR USING TOILET FACILITIES. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. PROPERL Y DISPOSE OF CONTAMINATED LEATHER ARTICLES INCLUDING
SHOES THAT CANNOT BE DECONTAMINATED. KEEP OUT O F REACH OF
CHILDREN.

Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Protective Gloves:USE OIL RESISTANT GLOVES.
Eye Protection:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING AS NEEDED TO
MINIMIZE SKIN CONTACT. EYE BATH, WASHING FACILITY ARE RECOMMENDED.
Work Hygienic Practices:GOOD PRACTICE REQUIRES THAT GROSS AMOUNT OF ANY
CHEMICAL BE REMOVED FROM THE SKIN AS SOON AS PRACTICAL.
Supplemental Safety and Health
NOTE TO PHYSICIAN: IN GENERAL, EMESIS INDUCTION IS UNNECESSARY IN HIGH
VISCOSITY, LOW VOLATILITY PRODUCTS. I.E., MOST OILS AND GREASES.

HCC:V6
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER, SMOOTH GREASE - SLIGHT ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:AVOID HEAT, OPEN FLAME
Hazardous Decomposition Products:DEPENDS ON THE COMBUSTION CONDITIONS.
A COMPLEX MIXTURE OF AIRBORNE SOLID, LIQUID, PARTICULATES AND GASES
WILL EVOLVE. CARBON MONOXIDE, CARBON DIOXIDE, AND UNIDENTIFIED
ORGANIC COMPOUNDS MAY BE FORMED.

Waste Disposal Methods:DISPOSE OF IN AN APPROVED DISPOSAL FACILITY IN
COMPLIANCE WITH LOCAL, STATE, AND FEDERAL LAWS AND REGULATIONS.

Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE ON
THE EPA/TOXIC SUBSTANCE CONTROL ACT (TSCA) INVENTORY LIST.
State Regulatory Information:NONE

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.