Product ID:ASTROSOL ORANGE, MIL-PRF-87937C, TY1
MSDS Date:09/29/1998
FSC:6850
NIIN:01-461-0065
Status Code:A
MSDS Number: CJKQS

Emergency Phone: 800-255-3824 CHEM-TEL INC

Info Phone: 210-653-2060/FX2106530825

Preparer: BOB E. FLYNT

Cage: 55208

Telephone: 800-531-1088/ 210-653-2060

Cage: 55208

D-LIMONENE

CAS: 5989-27-5

RTECS: GW6360000

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYES, SKIN, CNS,
RESPIRATORY SYSTEM (HMIS). ACUTE - INHALATION: MODERATE HAZARD.
VAPOR HAZARDOUS. MAY CAUSE DIZZINESS, NAUSEA, HEADACHES. SKIN
CONTACT: MODERATE HAZARD. MAY CAUSE SKIN I RRITATION OR DERMATITIS.
SKIN ABSORPTION: LOW HAZARD. NO EVIDENCE OF SKIN ABSORPTION AT USE
DILUTION. EYE CONTACT: MODERATE HAZARD. CORROSIVE TO EYES. CHRONIC
- INHALATION: MODERATE HAZARD. MAY CAUSE DIZZINESS, NAUSEA,
HEADACHES. SKIN: LOW HAZARD. DERMATITIS MAY RESULT FROM CHRONIC
EXPOSURE. SKIN ABSORPTION: NO HAZARD. NO EVIDENCE OF SKIN
ABSORPTION AT USE DILUTION. EYE CONTACT:SLIGHT HAZARD. NO C HRONIC
EFFECTS EXPECTED.
Explanation of Carcinogenicity:NONE

First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN
IF NEEDED. INGESTION: CONSULT PHYSICIAN IMMEDIATELY.

Flash Point Method:PMCC
Flash Point:=62.8C, 145.F
Autoignition Temp:>204.4C, 400.F
Lower Limits:2%
Upper Limits:18%
Extinguishing Media:C02, FOAM OR OTHER SUITABLE METHOD. TREAT AS CLASS
B (OIL TYPE) FIRE.
Fire Fighting Procedures:SCBA REQUIRED, SAME AS FOR PETROLEUM NAPHTHA.
Unusual Fire/Explosion Hazard:NO KNOWN HAZARDS

Spill Release Procedures:CONTAIN AND CLEAN UP SPILL WITH ABSORBENT.
PREVENT FURTHER DISCHARGE

Handling and Storage Precautions:NOT PROVIDED

Respiratory Protection:SCBA IF PEL'S ARE EXCEEDED
Ventilation:100 FT MIN AIR FLOW
Protective Gloves:RUBBER, CHEMICAL RESISTANT
Eye Protection:GOGGLES AND FACE SHIELD
Other Protective Equipment:RUBBER BOOTS AND APRON
Work Hygienic Practices:AVOID PROLONGED SKIN CONTACT
Supplemental Safety and Health

HCC:V4
Boiling Pt:>98.9C, 210.F
Melt/Freeze Pt:<-12.2C, 10.F
Vapor Pres:10MMHG@20C
Vapor Density:1
Spec Gravity:1
VOC Pounds/Gallon:415
pH:10
Viscosity:(AS IS) 10
Evaporation Rate & Reference:0.5 (H20=1)
Solubility in Water:PARTIALLY SOLUBLE
Appearance and Odor:CLEAR THIN LIQUID, MILD ODOR
Percent Volatiles by Volume:55%

STRONG OXIDIZERS AND REACTIVE METALS
Hazardous Decomposition Products:NO KNOWN HAZARDOUS PRODUCTS FROM
DECOMPOSITION

Waste Disposal Methods:AS IS THE PRODUCT IS NOT CONSIDERED A HAZARDOUS
WASTE BY EPA GUIDELINES. CONSULT LOCAL, STATE, AND FEDERAL
REGULATORY AGENCIES FOR PROPER DISPOSAL..

Toxicological Information:NONE

Ecological:PRODUCT IS 85% BIODEGRADABLE BASED ON THE SHAKE FLASK METHOD
OF 40 CFR 796. SUBPART D.EPA 763 3100.

Transport Information:NOT REGULATED.

Federal Regulatory Information:ALL MATERIALS USED IN THE MANUFACTURING
HAVE BEEN CERTIFIED BY THEIR MANUFACTURER AS BEING ON OR EXEMPT
FROM THE CURRENT TOXIC SUBSTANCE CONTROL ACT (TSCA) INVENTORY.
State Regulatory Information:

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.