Product ID:ASTROSOL ORANGE
MSDS Date:08/17/1999
FSC:6850
NIIN:01-461-0065
Status Code:A
MSDS Number: CJKQX

Emergency Phone: 800-255-3824

Info Phone: 210-653-2060/FX2106530825

Preparer: BOB E. FLYNT

Cage: 55208

Telephone: 800-531-1088/ 210-653-2060

Cage: 55208

D-LIMONENE

CAS: 5989-27-5

RTECS: GW6360000

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: N/P. ACUTE -
INHALATION: MODERATE HAZARD. VAPOR HAZARDOUS. MAY CAUSE DIZZINESS,
NAUSEA, HEADACHES. SKIN CONTACT: MODERATE HAZARD. MAY CAUSE SKIN
IRRITATION OR DERMATITIS. SKIN ABSORPTIO N: LOW HAZARD. NO EVIDENCE
OF SKIN ABSORPTION AT USE DILUTION. EYE CONTACT: MODERATE HAZARD.
CORROSIVE TO EYES. CHRONIC - INHALATION: MODERATE HAZARD. MAY CAUSE
DIZZINESS, NAUSEA, HEADACHES. SKIN: LOW HAZARD. DERMATITIS MAY
RESULT FROM CHRONIC EXPOSURE. SKIN ABSORPTION: NO HAZARD. NO
EVIDENCE OF SKIN ABSORPTION AT USE DILUTION. EYE CONTACT:SLIGHT
HAZARD. NO CHRONIC EFFECTS EXPECTED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DIZZINESS, NAUSEA, HEADACHES, IRRITATION,
DERMATITIS, CORROSIVE TO EYE.

First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN
IF NEEDED. INGESTION: CONSULT PHYSICIAN IMMEDIATELY.

Flash Point Method:PMCC
Flash Point:>62.8C, 145.F
Autoignition Temp:>204.4C, 400.F
Lower Limits:2%
Upper Limits:18%
Extinguishing Media:C02, FOAM, OR OTHER SUITABLE METHOD.
Fire Fighting Procedures:SCBA REQUIRED.
Unusual Fire/Explosion Hazard:NO KNOWN HAZARDS.

Spill Release Procedures:CONTAIN AND CLEAN UP SPILL WITH ABSORBENT.
PREVENT FURTHER DISCHARGE.

Handling and Storage Precautions:DO NOT STORE WHERE PRODUCT IS EXPOSED
TO EXTREME VARIATIONS TEMPERATURE.
Other Precautions:AVOID PROLONGED SKIN CONTACT. USE IN WELL VENTILATED
AREAS. CONSULT PRODUCT BULLETIN OR TECH ORDER FOR PROPER USE.

Respiratory Protection:SCBA IF PEL'S ARE EXCEEDED.
Ventilation:100 FT MIN AIR FLOW.
Protective Gloves:RUBBER, CHEMICAL RESISTANT.
Eye Protection:GOGGLES AND FACE SHIELD.
Other Protective Equipment:RUBBER BOOTS AND APRON.
Work Hygienic Practices:AVOID PROLONGED SKIN CONTACT.
Supplemental Safety and Health

HCC:V4
Boiling Pt:>98.9C, 210.F
Melt/Freeze Pt:<-12.2C, 10.F
Vapor Pres:10MMHG@20C
Vapor Density:1
Spec Gravity:1
VOC Pounds/Gallon:415
pH:10
Evaporation Rate & Reference:0.5 (H20=1)
Solubility in Water:PARTIALLY SOLUBLE
Appearance and Odor:CLEAR, AMBER, THIN LIQUID, CITRUS ODOR.
Percent Volatiles by Volume:55%

STRONG OXIDIZERS AND REACTIVE METALS.
Hazardous Decomposition Products:NO KNOWN HAZARDOUS PRODUCTS FROM
DECOMPOSITION.

Waste Disposal Methods:AS IS THIS PRODUCT IS NOT CONSIDERED A HAZARDOUS
WASTE BY EPA GUIDELINES. CONSULT LOCAL, STATE, AND FEDERAL
REGULATORY AGENCIES FOR PROPER DISPOSAL.

Toxicological Information:NONE

Ecological:PRODUCT IS 85% BIODEGRADABLE BASED ON THE SHAKE FLASK METHOD
OF 40 CFR 796. SUBPART D.EPA 763 3100.

Transport Information:NOT REGULATED.

SARA Title III Information:313: NOT REPORTABLE.
Federal Regulatory Information:ALL MATERIALS USED IN THE MANUFACTURING
HAVE BEEN CERTIFIED BY THEIR MANUFACTURER AS BEING ON OR EXEMPT
FROM THE CURRENT TOXIC SUBSTANCE CONTROL ACT (TSCA) INVENTORY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.